NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
242 reportsClear category filter23,880 miles · Nov 11, 2013
Structure
AT ANNUAL INSPECTION MECHANIC NOTED RUST HOLES IN THE FRAME AND CORROSION IN CONNECTIONS OF PLATES TO FRAME. THIS IS OF COURSE A SAFETY HAZARD THAT PREVENTS THE VEHICLE FROM PASSING INSPECTION. DEALER INSPECTED AND CONFIRMED THE CORROSION. WE PURCHASED THE TRUCK NEW. WE LIVE ON A DIRT ROAD WITH NO SALT USE, KEEP THE TRUCK GAR…
Read full complaint
AT ANNUAL INSPECTION MECHANIC NOTED RUST HOLES IN THE FRAME AND CORROSION IN CONNECTIONS OF PLATES TO FRAME. THIS IS OF COURSE A SAFETY HAZARD THAT PREVENTS THE VEHICLE FROM PASSING INSPECTION. DEALER INSPECTED AND CONFIRMED THE CORROSION. WE PURCHASED THE TRUCK NEW. WE LIVE ON A DIRT ROAD WITH NO SALT USE, KEEP THE TRUCK GARAGED IN WINTER, AND DO NOT DRIVE IT REGULARLY IN WINTER. IT IS OTHERWISE A SOUND AND TROUBLE-FREE VEHICLE. *TR
NHTSA ODI #10551807
202,456 miles · Nov 4, 2013
Structure
THE FRAME ON MY 2006 TOYOTA TACOMA HAS A RUST HOLE BY THE TRANS CROSS MEMBER. THE FRAME IS ALSO RUSTED VERY BADLY. I DRIVE 150 MILES A DAY ROUND TRIP TO WORK AND ALSO MY FAMILY IN THIS VEHICLE. *TR
NHTSA ODI #10550747
95,000 miles · Oct 30, 2013
Structure
FRAME ON MY 2006 TACOMA IS RUSTING/ROTTING OUT(ALMOST A HOLE BESIDE THE TRANSMISSION). TOYOTA WILL NOT ASSIST. I HAVE PIC'S AVAILABLE. *TR
NHTSA ODI #10550107
78,765 miles · Oct 29, 2013
Structure
THE FRAME ON MY 2006 TACOMA IS SHOWING MODERATE RUST AFTER 78,000 MILES. I DON'T LIVE IN A COLD WEATHER STATE. I'VE PROBABLY ONLY DRIVEN IT ON SALTED ROADS FOR A COUPLE OF WEEKS IN MAYBE 2 OF THE WINTERS I'VE OWNED IT. THE RUST IS WORST ABOVE WHERE THE REAR LEAF SPRINGS ARE, BUT BASICALLY THE ENTIRE FRAME SHOWS SIGN OF RUSTING. …
Read full complaint
THE FRAME ON MY 2006 TACOMA IS SHOWING MODERATE RUST AFTER 78,000 MILES. I DON'T LIVE IN A COLD WEATHER STATE. I'VE PROBABLY ONLY DRIVEN IT ON SALTED ROADS FOR A COUPLE OF WEEKS IN MAYBE 2 OF THE WINTERS I'VE OWNED IT. THE RUST IS WORST ABOVE WHERE THE REAR LEAF SPRINGS ARE, BUT BASICALLY THE ENTIRE FRAME SHOWS SIGN OF RUSTING. THE TACOMA IS TERRIBLE COMPARED TO THE FORD F-250 THAT WE'VE HAD FOR THE SAME AMOUNT OF TIME WITH MORE THAN 40,000 EXTRA MILES. THE FORD BARELY HAS ANY RUST AT ALL. I'M WORRIED THAT WITHIN 2 YEARS THAT MY FRAME WILL HAVE HOLES IN IT, AND THE TRUCK WILL NOT BE SAFE TO DRIVE. *TR
NHTSA ODI #10550035
100,000 miles · Oct 27, 2013
Structure
THE TRUCK WAS TAKEN TO A SERVICE GARAGE FOR THE REQUIRED ANNUAL STATE OF MAINE SAFETY INSPECTION. THE RESULTS DISCLOSED SEVERE RUSTING OF THE FRAME, ENGINE MOUNTS, AND CAB MOUNTS. BECAUSE THERE WERE NO PERFORATIONS IN THE FRAME, THE VEHICLE PASSED INSPECTION. THE MECHANIC ADVISED THAT THE TRUCK IS IN IMMINENT NEED OF FRAME RE…
Read full complaint
THE TRUCK WAS TAKEN TO A SERVICE GARAGE FOR THE REQUIRED ANNUAL STATE OF MAINE SAFETY INSPECTION. THE RESULTS DISCLOSED SEVERE RUSTING OF THE FRAME, ENGINE MOUNTS, AND CAB MOUNTS. BECAUSE THERE WERE NO PERFORATIONS IN THE FRAME, THE VEHICLE PASSED INSPECTION. THE MECHANIC ADVISED THAT THE TRUCK IS IN IMMINENT NEED OF FRAME REPLACEMENT. *TR
NHTSA ODI #10549673
100,006 miles · Oct 17, 2013
StructureSuspension
I BROUGHT CAR IN FOR ROUTINE OIL CHANGE. MECHANIC CALLED ME IN TO SHOW ME THE EXTREME RUST UNDER THE FRAME. IT IS FLAKING OFF IN CHUNKS AND ALMOST RUSTED THROUGH IN SOME PARTS. MECHANIC INFORMED ME THAT THIS WAS NOT NORMAL AND I SHOULD CONTACT TOYOTA FOR POSSIBLE RECALL INFORMATION. I CONTACTED TOYOTA, BUT HAVE NOT HEARD BAC…
Read full complaint
I BROUGHT CAR IN FOR ROUTINE OIL CHANGE. MECHANIC CALLED ME IN TO SHOW ME THE EXTREME RUST UNDER THE FRAME. IT IS FLAKING OFF IN CHUNKS AND ALMOST RUSTED THROUGH IN SOME PARTS. MECHANIC INFORMED ME THAT THIS WAS NOT NORMAL AND I SHOULD CONTACT TOYOTA FOR POSSIBLE RECALL INFORMATION. I CONTACTED TOYOTA, BUT HAVE NOT HEARD BACK FOR OVER ONE MONTH. *TR
NHTSA ODI #10548318
110,000 miles · Oct 17, 2013
Structure
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT HE TOOK THE VEHICLE TO A MECHANIC TO HAVE ROUTINE MAINTENANCE PERFORMED WHEN THE MECHANIC STATED THAT THE CHASSIS WAS CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER FOR FURTHER INSPECTION BUT THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT WAS UNAB…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT HE TOOK THE VEHICLE TO A MECHANIC TO HAVE ROUTINE MAINTENANCE PERFORMED WHEN THE MECHANIC STATED THAT THE CHASSIS WAS CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER FOR FURTHER INSPECTION BUT THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT WAS UNABLE TO PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 110,000. UPDATED 11/26/13*LJ
NHTSA ODI #10548224
83,500 miles · Oct 9, 2013
StructureSuspension
TOOK TRUCK INTO DEALER FOR SERVICE AND WAS INFORMED THAT THE FRAME HAD RUSTED TO THE POINT THAT THERE WAS NOW A HOLE IN IT. CONTACTED TOYOTA VIA PHONE AND EMAIL AND WAS TOLD ON BOTH OCCASIONS THAT THERE WAS NOT A "PROGRAM" IN PLACE TO ASSIST OWNERS WITH THIS PROBLEM. PREVIOUS REPLACEMENT PROGRAM COVERED TACOMAS MADE FROM 1998-2…
Read full complaint
TOOK TRUCK INTO DEALER FOR SERVICE AND WAS INFORMED THAT THE FRAME HAD RUSTED TO THE POINT THAT THERE WAS NOW A HOLE IN IT. CONTACTED TOYOTA VIA PHONE AND EMAIL AND WAS TOLD ON BOTH OCCASIONS THAT THERE WAS NOT A "PROGRAM" IN PLACE TO ASSIST OWNERS WITH THIS PROBLEM. PREVIOUS REPLACEMENT PROGRAM COVERED TACOMAS MADE FROM 1998-2004 THAT EXHIBITED THE SAME ISSUES, PREMATURE RUSTING/CORROSION OF THE TRUCKS' FAMES. MY LIMITED RESEARCH HAS SHOWN NUMEROUS CASES WHERE THE FRAMES OF THE TRUCK CORRODES TO THE POINT THAT IT IS UNSAFE TO DRIVE. PLEASE SEE FORUM AT THIS LINK FOR OTHER EXAMPLES HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2006/TOYOTA/TACOMA/FRAME. OBVIOUSLY THIS IS A DEFECT WITH THE MOST IMPORTANT PART OF THE TRUCK AND ONE THAT TOYOTA HAS BEEN MADE AWARE OF NUMEROUS TIMES, BUT REFUSES TO ADDRESS. IT IS MY BELIEVE THAT THEY SHOULD ASSIST THEIR CUSTOMERS BY REPLACING THE FRAMES THAT HAVE DETERIORATED PREMATURELY. AFTER TALKING WITH TOYOTA AND MULTIPLE DEALERS, I HAVE NO WHERE ELSE TO TURN FOR ASSISTANCE. ANY HELP YOU CAN BE WOULD BE GREATLY APPRECIATED. *TR
NHTSA ODI #10547407
100,006 miles · Sep 10, 2013
Structure
BROUGHT MY TACOMA IN FOR REGULAR MAINTENANCE. MECHANIC POINTED OUT THAT THERE IS SEVERE ROT/RUST ON THE FRAME. THERE IS SEVERE FLAKING IN SEVERAL DIFFERENT AREAS. THE MOST AFFECTED PART IS THE FRONT DRIVER'S SIDE. *TR
NHTSA ODI #10542969
Mileage unknown · Aug 17, 2013
StructureSuspension
WHILE CHANGING THE OIL ON MY 2006 TOYOTA TACOMA, I NOTICES SIGNIFICANT RUST ON THE FRAME OF MY TRUCK. I SCRAPED AT SOME AND CHUNKS FELL OFF REVEALING A WEAKENED FRAME. MY SPARE HAS NOT BEEN ABLE TO HOLD AIR AND UPON INSPECTION THE ENTIRE METAL AREA THAT HOLDS THE TIRE IN PLACE IS RUSTED. THE MILEAGE IS UNDER 90K I WOULD LIKE TO…
Read full complaint
WHILE CHANGING THE OIL ON MY 2006 TOYOTA TACOMA, I NOTICES SIGNIFICANT RUST ON THE FRAME OF MY TRUCK. I SCRAPED AT SOME AND CHUNKS FELL OFF REVEALING A WEAKENED FRAME. MY SPARE HAS NOT BEEN ABLE TO HOLD AIR AND UPON INSPECTION THE ENTIRE METAL AREA THAT HOLDS THE TIRE IN PLACE IS RUSTED. THE MILEAGE IS UNDER 90K I WOULD LIKE TO HAVE THIS DOCUMENTED AS I HAVE BEEN READING OTHER COMPLAINTS FROM 2006 TACOMA OWNERS THEY ARE EXPERIENCING THE SAME PROBLEM AS MYSELF. THIS CAR IS AS A FAMILY VEHICLE AS UTILIZE IT IN CAMPING, CANOEING AND OTHER OUTDOOR ACTIVITIES. THANK YOU *TR
NHTSA ODI #10535856
Official recalls
11Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Apr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Mar 2, 2006
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
Consequence & remedy
Consequence: IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP08001 · Sudden And Uncontrolled Acceleration
Opened Jan 31, 2008 · Closed Aug 27, 2008
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (3)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MODEL YEAR (MY) 2006 TOYOTA TACOMA EQUIPPED WITH A V6 ENGINE AND AUTOMATIC TRANSMISSION.IN A PETITION SENT TO NHTSA'S OFFICE OF DEFECTS INVESTIGATION (ODI) DATED JANUARY 10, 2008, HE ALLEGES HE EXPERIENCED TWO INCIDENTS OF UNWANTED ACCELERATION WHILE DRIVING HIS TACOMA.THE PETITIONER REPORTED THAT DURING BOTH INCIDENTS, WHILE APPLYING THE BRAKE, THE ENGINE SPEED INCREASED OF ITS OWN ACCORD (WITHOUT ACCELERATOR APPLICATION), CAUSING SUDDEN AND UNCONTROLLED ACCELERATION.THE PETITIONER REQUESTED THAT THE AGENCY COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT RELATED TO MOTOR VEHICLE SAFETY INVOLVING THE ELECTRONICALLY ACTUATED THROTTLE CONTROL SYSTEM.ODI REVIEWED THE PETITION, ASSESSED VOQS, INTERVIEWED PERSONS WHO FILED VOQS, TESTED THE VEHICLE, AND REVIEWED TOYOTA'S RESPONSE TO AN AGENCY INFORMATION REQUEST.THE COMPLAINTS FELL INTO THREE GROUPS.A MAJORITY OF THE COMPLAINTS MAY HAVE INVOLVED THE TACOMA'S THROTTLE CONTROL SYSTEM.SOME COMPLAINTS DID NOT INVOLVE A FAILURE OF THE THROTTLE CONTROL SYSTEM.FOR THE REMAINING REPORTS, ALTHOUGH THERE MAY HAVE BEEN AN ISSUE WITH THE THROTTLE CONTROL SYSTEM AS ONE POSSIBLE EXPLANATION, WE HAVE BEEN UNABLE TO DETERMINE A CAUSE RELATED TO THROTTLE CONTROL OR ANY UNDERLYING CAUSE THAT GAVE RISE TO THE COMPLAINT.FOR THOSE VEHICLES WHERE THE THROTTLE CONTROL SYSTEM DID NOT PERFORM AS THE OWNER BELIEVES IT SHOULD HAVE, THE INFORMATION SUGGESTING A POSSIBLE DEFECT RELATED TO MOTOR VEHICLE SAFETY IS QUITE LIMITED.ADDITIONAL INVESTIGATION IS UNLIKELY TO RESULT IN A FINDING THAT A DEFECT RELATED TO MOTOR VEHICLE SAFETY EXISTS OR A NHTSA ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT AS REQUESTED BY THE PETITIONER.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THEFEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Illustration