Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1040–25K
6325–50K
7250–75K
7875–100K
112100–150K
106150K+
535 reports with mileage · 172 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 260 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 137 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
47 crash reports4 fire reports14 injury reports
What owners actually said
707 reports
1,300 miles · May 25, 2005
Structure
DT: CONSUMER WAS UNLOADING A MOTORCYCLE FROM HIS TRUCK AND THE REAR TAILGATE BENT IN ALMOST A V. THIS SHIFTED THE MOTORCYCLE'S WEIGHT, AND ALMOST RESULTED IN AN ACCIDENT. THE MOTORCYCLE COULD HAVE FALLEN OFF THE TAILGATE OR FALLEN UPON THE CALLER .THE OWNER'S MANUAL DOES NOT STATE HOW MUCH WEIGHT THE TAILGATE CAN SUPPORT OR …
Read full complaint
DT: CONSUMER WAS UNLOADING A MOTORCYCLE FROM HIS TRUCK AND THE REAR TAILGATE BENT IN ALMOST A V. THIS SHIFTED THE MOTORCYCLE'S WEIGHT, AND ALMOST RESULTED IN AN ACCIDENT. THE MOTORCYCLE COULD HAVE FALLEN OFF THE TAILGATE OR FALLEN UPON THE CALLER .THE OWNER'S MANUAL DOES NOT STATE HOW MUCH WEIGHT THE TAILGATE CAN SUPPORT OR ANY PRECAUTIONS ON LOADING ONTO A TAILGATE. *AK
NHTSA ODI #10122097
50 miles · May 25, 2005
Structure
THE PAINT ON MY 2005 TOYOTA TACOMA IS CHIPPING OF VERY RAPIDLY AND THE PAINT IS VERY SOFT AND CAN NOT WITH STAND THE NORMAL ROAD CONDITIONS IN MY STATE.THERE IS A PROBLEM WITH THE PAINT FROM THE FACTORY AND NO RESOLUTIONS ARE BEING MADE
NHTSA ODI #10122070
330 miles · May 23, 2005
Visibility
THE OUTSIDE REVIEW MIRRORS VIBRATE EXCESSIVELY ESPECIALLY ON WINDY DAYS, SO MUCH THAT VEHICLES OR ANY OTHER OBJECT IS INDISERNABLE. I HAVE TAKEN MY PROBLEM TO TWO DIFFERENT DEALERSHIPS, THE DEALER WHERE I PURCHASED FROM SWAPPED MY MIRRORS WITH ANOTHER VEHICLE TO NO AVAIL. I BELIEVE THIS TO BE A SAFETY DEFECT AND SHOULD BE FIXED…
Read full complaint
THE OUTSIDE REVIEW MIRRORS VIBRATE EXCESSIVELY ESPECIALLY ON WINDY DAYS, SO MUCH THAT VEHICLES OR ANY OTHER OBJECT IS INDISERNABLE. I HAVE TAKEN MY PROBLEM TO TWO DIFFERENT DEALERSHIPS, THE DEALER WHERE I PURCHASED FROM SWAPPED MY MIRRORS WITH ANOTHER VEHICLE TO NO AVAIL. I BELIEVE THIS TO BE A SAFETY DEFECT AND SHOULD BE FIXED BY TOYOTA BY ENGINEERING A BETTER OUTSIDE REAR VIEW MIRROR FREE FROM VIBRATION.
NHTSA ODI #10121858
Mileage unknown · May 10, 2005
Latches/locks/linkages
NO LOCKS ON THE ACCESS DOOR'S. WHERE THE SEAT BELT'S ATTACHE THE DOOR CAN OPEN ON IMPACT.
NHTSA ODI #10120580
225 miles · May 3, 2005
Service Brakes, HydraulicTires
I HAVE A 2005 TOYOTA TACOMA 4 DOOR AND EVER SINCE TAKING IT OFF THE LOT 5 DAYS AGO, WHEN APPLYING THE BRAKES IN ANY WEATHER, ON ANY SURFACE OF ROAD, I GET A THUMPING IN THE PEDAL AND THE STEERING WHEEL WHEN APPLYING THE BRAKES TO STOP. IT GETS WORSE WITH MORE PRESSURE APPLIED TO THE BRAKES. THE FRONT END SEEMS TO BOUNCE, AND FEE…
Read full complaint
I HAVE A 2005 TOYOTA TACOMA 4 DOOR AND EVER SINCE TAKING IT OFF THE LOT 5 DAYS AGO, WHEN APPLYING THE BRAKES IN ANY WEATHER, ON ANY SURFACE OF ROAD, I GET A THUMPING IN THE PEDAL AND THE STEERING WHEEL WHEN APPLYING THE BRAKES TO STOP. IT GETS WORSE WITH MORE PRESSURE APPLIED TO THE BRAKES. THE FRONT END SEEMS TO BOUNCE, AND FEELS LIKE IT WILL GO OUT OF CONTROL. THE TRUCK HAS 230 MILES ON IT, I WILL BE CALLING THE DEALER TODAY.
NHTSA ODI #10119499
235 miles · Mar 31, 2005
Service Brakes, Air
2005 TACOMA PRERUNNER. AUTOMATIC-PACKAGE 2. HAD NEW VEHICLE SURGE 3 DIFFERENT TIMES AFTER PURCHASE FIRST WEEK OF MARCH. LAST TIME SENT ME INTO MIDDLE OF BUSY INTERSECTION. THIS WAS TUESDAY MARCH 29, 2005. CALLED DEALER AND THEY SENT A TOW TRUCK. ALL PEOPLE AT DEALERSHIP HAVE BEEN VERY NICE, BUT SAY THEY HAVE FOUND NOTHING WRONG …
Read full complaint
2005 TACOMA PRERUNNER. AUTOMATIC-PACKAGE 2. HAD NEW VEHICLE SURGE 3 DIFFERENT TIMES AFTER PURCHASE FIRST WEEK OF MARCH. LAST TIME SENT ME INTO MIDDLE OF BUSY INTERSECTION. THIS WAS TUESDAY MARCH 29, 2005. CALLED DEALER AND THEY SENT A TOW TRUCK. ALL PEOPLE AT DEALERSHIP HAVE BEEN VERY NICE, BUT SAY THEY HAVE FOUND NOTHING WRONG WITH IT. FOUND OUT LAST WEEK, THAT A LADY ON A TEST DRIVE HAD A CAR SURGE THROUGH THE SHOWROOM WINDOW AT SAME DEALERSHIP. I HAVE NO FAITH THAT THE VEHICLE WON'T DO THIS AGAIN. I AM REFUSING TO PICK VEHICLE UP AT DEALERSHIP, EVEN THOUGH I PAID CASH.
NHTSA ODI #10116155
600 miles · Mar 20, 2005
Structure
I HAVE A 2005 TOYOTA TACOMA WITH ALMOST 600 MILES ON IT. TODAY I DROVE IT IT WAS A LITTLE WINDY OUT GOT HOME AND LOOKED AT THE TRUCK,IT WAS COVERED WITH ROCK CHIPS!! I HAVE READ ON TOYOTANATION.COM OF OTHER PEOPLE HAVING THE SAME PROBLEM AND THINK IT IS DUE TO WEAK PAINT, AND NEEDS TO BE FIXED. *AK
NHTSA ODI #10114384
Mileage unknown · Mar 14, 2005
Structure
WHILE DRIVING TAILGATE FAILED. UPON PUSHING UP ON THE TAILGATE THE CABLES DISENGAGED, CAUSING THE TAILGATE TO HANG. *AK
NHTSA ODI #10115090
Mileage unknown · Mar 11, 2005
Visibility
CONSUMER STATES WHILE DRIVING REAR VIEW MIRROR CREATES A BLIND SPOT IN THE RIGHT FRONT SECTOR AREA. THE MIRROR IS TOO BIG. CONTACTED TOYOTA, BUT PROBLEM IS OCCURS. *AK
NHTSA ODI #10115010
250 miles · Mar 9, 2005
Structure
1. FROM DAY ONE ;2. LOUD POPPING NOISES FROM UNDER SIDE - CABIN ATTACHMENT TO THE CHASIS. ITS BEEN TWO WEEKS SINCE I TOOK THE VEHICLE AND ITS GETTING WORSE. OCCURRS WHEN GOING OVER EVEN SMALL BUMPS/RUTS/MANHOLE COVERS OR OTHER IMPERFECTIONS IN THE ROAD ESPECIALLY AT SLOW SPEEDS. AND, THERE IS SIGNIFICANT "SWAYING" IN THE CABIN. …
Read full complaint
1. FROM DAY ONE ;2. LOUD POPPING NOISES FROM UNDER SIDE - CABIN ATTACHMENT TO THE CHASIS. ITS BEEN TWO WEEKS SINCE I TOOK THE VEHICLE AND ITS GETTING WORSE. OCCURRS WHEN GOING OVER EVEN SMALL BUMPS/RUTS/MANHOLE COVERS OR OTHER IMPERFECTIONS IN THE ROAD ESPECIALLY AT SLOW SPEEDS. AND, THERE IS SIGNIFICANT "SWAYING" IN THE CABIN. PROBABLY DUE TO IMPROPER SECUREMENT OF THE CAB TO CHASIS. 3. HAVE BEEN TO THE DEALER WHO CALLED TOYOTA IN CALIFORNIA WHO ACKNOWLEDGE THE PROBLEM IN A LOT OF THE 05 TACOMAS WITH TRD, 4X4, 4 DOOR, SHORT BED MODELS, BUT HAVE NO IDEA WHAT TO DO YET. IS THIS VEHICLE SAFE FOR ME AND MY FAMILY? THE DEALER,VERY NICE, SAID HE WILL HAVE TO WAIT FOR TOYOTA TO COME UP WITH A SOLUTION. FURTHER RESEARCHING ON EDMUNDS' TOYOTA TACOMA FORUMS, I SEE MANY MANY NEW OWNERS WITH SIMILAR PROBLEMS WHICH ACTUALLY HAS BEEN REPORTED SINCE THE INTRODUCTION OF THE VEHICLE LAST OCT/NOV. ITS BEEN MOR THAN 4 MONTHS AND TOYOTA IS SELLING IT WITH THE SAME PROBLEM.*AK
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Consequence & remedy
Consequence: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
ON CERTAIN REGULAR CAB PICKUP TRUCKS EQUIPPED WITH A BENCH SEAT, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR CONNECTOR PINS ARE INCORRECTLY POSITIONED DUE TO A WIRE HARNESS MANUFACTURING PROCESS ERROR.
Consequence & remedy
Consequence: IN THIS CONDITION, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR MAY NOT FUNCTION AS DESIGNED, AFFECTING THE ADAPTIVE AIR BAG DEPLOYMENT, WHICH IF THE VEHICLE IS INVOLVED IN A CRASH, COULD RESULT IN IMPROPER OCCUPANT RESTRAINT.
Remedy: DEALERS WILL INSPECT THE SEAT POSITION AND SEAT BELT FASTENING CONDITION SENSOR CONNECTOR. AN ADDITIONAL SUB-WIRE HARNESS WILL BE INSTALLED TO CORRECT THE CONNECTOR PIN MANUFACTURING ERROR, IF NECESSARY. THE RECALL BEGAN ON JULY 25, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-431-4331.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THERE IS A POSSIBILITY THAT THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. IN THIS CONDITION, THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW THE VEHICLE TO ROLL IF THE TRANSMISSION IS NOT PLACED INTO THE "PARK" POSITION AND THE VEHICLE IS PARKED ON A SLOPE, THUS RAISING THE POSSIBILITY OF A CRASH.
Remedy: DEALERS WILL INSPECT AND TIGHTEN THE PARKING BRAKE PEDAL CABLE LOCK NUT TO THE PROPER TORQUE SPECIFICATION FREE OF CHARGE. THE RECALL BEGAN ON MARCH 3, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Toyota Tacoma Problems, Complaints & Recalls | Skip That Year
Illustration