2003 Toyota Tacoma

I AM THE OWNER OF A 2003 TOYOTA TACOMA WITH APPROXIMATELY 29,000 MILES, LIVING IN THE NORTHEAST. THE FRAME AND THE UNDERCARRIAGE OF THE VEHICLE HAVE EXTENSIVE RUST FROM FRONT TO REAR. I BELIEVE THE FRAME IS RUSTING FROM THE INSIDE OUT AND WILL CONTINUE TO DO SO. AT THIS POINT, THE TRANSMISSION SHIELD AND THE FUEL TANK SHIELD ARE IN DANGER OF FALLING OFF OF THE VEHICLE. THE LEAF SPRINGS ARE SO CORRODED THAT THEY NO LONGER FUNCTION PROPERLY. THE EXHAUST SYSTEM AND MUFFLER ARE COMPLETELY RUSTED OUT. *TR

TL*THE CONTACT OWNS A 2003 TOYOTA TACOMA. THERE WERE 14 MILES ON THE VEHICLE AT THE TIME OF PURCHASE. THE CONTACT STATED THAT THE PAINT WAS CHIPPING ON THE VEHICLE. HE FILED A COMPLAINT WITH THE MANUFACTURER AND THEY DECLINED ANY LIABILITY FOR THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 36,461. THE VEHICLE ALSO HAD FRAME RUST. UPDATED 09/09/09.*JB

VERY LOOSE STEERING WHEEL. PROBLEM IS THE SLIP SHAFT IN THE STEERING COLUMN. OVER TIME THE LOVER SHAFT WEARS AND THE STEERING BECOMES LOOSE AND SLOPPY. PROBLEM FIRST SHOWS UP AS LOOSENESS IN THE WHEEL AND EVENTUALLY TURNS INTO A CLUNK WHEN DRIVING OVER MINOR ROUGH ROADS. FROM TALKING TO MECHANICS AND OTHER TACOMA OWNERS THIS IS A VERY COMMON PROBLEM THAT TOYOTA WILL NOT ADDRESS. PROBLEMS INCLUDE DIFFICULTY MAINTAINING CONTROL OVER ROUGH PAVEMENT. WANDERING AT ALL SPEEDS. MAJOR DIRECTION CHANGES WHEN BREAKING ON ALL ROADS. SMOOTH OR ROUGH. OVER ALL THE TRUCK IS VERY DIFFICULT TO DRIVE. I'VE HAD THE TRUCK ACTUALLY CHANGE LANES WHEN I HIT AN UNEXPECTED ROUGH PATCH OF ROAD AT APPOX 30 MPH. THERE WAS NOTHING I COULD DUE BECAUSE OF THE SLOP IN THE STEERING WHEEL. PLEASE NOTE THAT THIS TRUCK IS VERY WELL MAINTAINED AND I HAVE GONE THROUGH THE ENTIRE FRONT SUSPENSION AND STEERING TRYING TO FIX THIS PROBLEM WITH NO LUCK. I'M NOW FACED WITH SPENDING EVEN MORE MONEY TO REPLACE A STEERING COLUMN. *TR

TL*THE CONTACT OWNS A 2003 TOYOTA TACOMA. WHEN ENTERING THE VEHICLE, THE CONTACT NOTICED RUST ON THE FRAME. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY PREDICTED THAT THE FRAME WOULD FAIL WITHIN THE YEAR. THE CONTACT RECEIVED A RECALL NOTICE FROM THE MANUFACTURER REGARDING THE FRAME FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY CONDUCTED A TEST BY TAKING A HAMMER AND STRIKING THE RUST SPOTS TO SEE IF THE HAMMER WOULD GO COMPLETELY THROUGH. THE FAILURE COULD NOT BE DUPLICATED, WHICH MEANT THAT THE VEHICLE WAS NOT COMPLETELY FAILING. THE CONTACT WAS INFORMED TO BRING THE VEHICLE BACK FOR INSPECTION BY A REGIONAL INSPECTOR. THE CONTACT FEELS THAT THE ISSUE NEEDS TO BE REMEDIED BEFORE A CRASH OCCURS. HE CALLED THE MANUFACTURER AND WAS INFORMED THAT A REGIONAL INSPECTOR WOULD CALL HIM TO SCHEDULE AN APPOINTMENT FOR FURTHER INSPECTION. THE FAILURE MILEAGE WAS 45,000 AND CURRENT MILEAGE WAS 61,200.

I WAS DRIVING MY 2003 TACOMA WHEN THE BATTERY AND OIL LIGHTS CAME ON AND THE TRUCK BECAME UNDRIVEABLE. WHEN THE LIGHTS WENT OFF I WAS ABLE TO DRIVE AGAIN. I HAD TRUCK TOWED TO MECHANIC AND FOUND OUT THAT CRANKSHAFT BOLT WAS BROKEN/SHEARED OFF. HAD TRUCK TOWED TO DEALERSHIP FOR CONFIRMATION - THEY CONFIRMED. HAD INSURANCE ADJUSTER LOOK AT IT TO DETERMINE IF RELATED TO ANY ACCIDENTS - NO RELATION. CALLED TOYOTA CORP AND THEY SAID THAT BOLT SHOULD NOT BREAK UNLESS UNDER EXTREME TORQUE OF DEFECT. MECHANIC, DEALERSHIP AND INSURANCE ADJUSTER ALL SAID THE SAME. THE BOLT IS MADE OUT OF CASE-HARDENED STEEL. I HAVE NOT HAD ANY MAJOR WORK DONE TO THE TRUCK THAT WOULD INVOLVE THE CRANKSHAFT BOLT!! DEALERSHIP IS QUOTING COST OF APPROX $4000 FOR SHORT BLOCK REPAIR. IF BOLT IS/WAS DEFECTIVE I SHOULD NOT HAVE TO PAY FOR ANY OF THE REPAIRS THAT SHOULD FALL ON TOYOTA WHETHER OR NOT THE TRUCK IS OUT OF WARRANTY. I NEED THIS FIXED! *TR

2003 TOYOTA TACOMA 4WD CREW CAB PICKUP I WOULD LIKE TO RELATE A RECENT EXPERIENCE I HAD WITH MY 2003 TOYOTA PICKUP. I WAS DRIVING THE TRUCK THROUGH A PARKING LOT IN LARGO, MARYLAND ON JANUARY 29, 2009. SUDDENLY THERE WAS A LOUD NOISE AND THE VEHICLE DROPPED DOWN IN THE FRONT END AND I CAME TO A STOP. THE FRONT DRIVER SIDE WHEEL HAD DROPPED DOWN INTO THE WHEEL WELL. I HAD THE VEHICLE TOWED BY BOSWELL AUTO SERVICE OF WALDORF, MARYLAND NEAR WHERE I LIVE. I WAS TOLD BY THE MECHANIC THAT THE CASTLE NUT ON THE DRIVER SIDE BALL JOINT ASSEMBLY HAD COME OFF. I WAS TOLD THAT THIS WAS AN EXTRAORDINARY EVENT. THE BALL JOINT ASSEMBLY SEPARATED AND AS A CONSEQUENCE FRONT AXLE WAS BROKEN AS WELL. IN REVIEWING MY RECORDS I SAW THE RECALL FOR THE LOWER BALL JOINT FOR MY TOYOTA. I HAD THIS RECALL WORK COMPLETED AT WALDORF TOYOTA ON DECEMBER 29, 2005. I BROUGHT THIS TO THE ATTENTION OF THE MECHANIC WHO FIXED MY TRUCK. HE TOLD ME I SHOULD MAKE THE DEALERSHIP SERVICE DEPARTMENT AWARE OF THIS INCIDENT. IN HIS OPINION, THIS EVENT SHOULD NOT HAPPEN IF THE BALL JOINT CASTLE NUT IS INSTALLED CORRECTLY. I TOOK THE INFORMATION TO WALDORF TOYOTA ON FEBRUARY 3, 2009. I SPOKE WITH THE SERVICE MANAGER (MICHAEL PAVAN, 301-843-3700, MPAVAN@TOYOTAOFWALDORF.COM) AND A MAN I BELIEVE WAS A MECHANIC OR SERVICE SUPERVISOR. I SHOWED THEM PHOTOGRAPHS AND THE BROKEN BALL JOINT ASSEMBLY. THEY TOLD ME THAT THE REMNANTS OF THE COTTER PIN WERE STILL IN SO THAT THEY BELIEVE THEY HAD INSTALLED THE CASTLE NUT CORRECTLY. I LEFT THE BROKEN BALL JOINT ASSEMBLY WITH THEM. THE SERVICE MANAGER TOLD ME HE WOULD REPORT IT TO HIS REGIONAL MANAGER. *TR