2003 Toyota Tacoma

The contact owned a 2003 Toyota Tacoma. The contact stated that while driving up the driveway at 5 MPH and turning into the garage, the accelerator pedal was depressed but went down to the floorboard and became stuck. The contact lost control of the vehicle, and the vehicle crashed into the fence gate and the corner of the neighbor's residence. The air bags did not deploy. There was no injury sustained. There was no police report filed. The vehicle was towed to a salvage yard, where it was totaled. The contact related the failure to NHTSA Campaign Number: 09V388000 (Vehicle Speed Control). The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 230,000.

LOSS OF ACCELERATOR DUE TO BAD THROTTLE POSITION SENSOR/THROTTLE BODY. WHEN YOU EASE OFF THE ACCELERATOR THE VEHICLE WILL LOSE ALL THROTTLE RESPONSE. THEN YOU HAVE TO "WORK" THE ACCELERATOR IN AND OUT UNTIL IT STARTS RESPONDING AGAIN. IT HAPPENS ON TAKE OFF OR ANYTIME YOU BACK OFF ON THE ACCELERATOR. IT HAS CUT OFF ON ME TRYING TO PULL OUT INTO TRAFFIC AND I ALMOST GOT HIT! IT HAS HAPPENED ON THE INTERSTATE AND I HAD TO TRY TO WORK MY WAY OVER WITH NO THROTTLE AND TRY NOT TO GET RUN OVER! IT NOW HAPPENS EVERY TIME I DRIVE IT. TOYOTA DOESN'T SELL A NEW TPS FOR THIS VEHICLE NOW ( A $40 TO $50 PART)TOYOTA WILL BE HAPPY TO SELL ME A NEW THROTTLE BODY FOR $1400 AND THAT DOESN'T INCLUDE LABOR. I THOUGHT MANUFACTURERS WERE REQUIRED TO PROVIDE PARTS FOR THEIR VEHICLES.

I WAS DRIVING DOWN THE HIGHWAY EXPERIENCE LOSS OF POWER SUCH AS FUEL PUSH THE THROTTLE DOWN A COUPLE OF TIMES IT PICK BACK UP HAPPENED TO MORE TIMES WITHIN 10 MI1NUTES IT DID NOT THROW A CODE BEEN CHECKING IT MAY RELATE TO A THROTTLE BODY PROBLEM BEEN READING ABOUT PROBLEMS WITH THE THROTTLE BODY DO NOT WANT THIS TO HAPPEN IN HEAVY TRAFFIC OR PULLING OUT IN FRONT OF TRAFFIC PLEASE LET ME KNOW WHAT OR HOW TO TAKE CARE OF THIS PROBLEM

WHILE DRIVING DOWN THE HIGHWAY, I MOVED INTO THE LEFT LANE TO PASS ANOTHER CAR. WHEN I STEPPED ON THE ACCELERATOR THE NOSE PITCHED FORWARD AND THE ENGINE FELT LIKE IT WAS NOT GETTING ANY GAS. I WAS ABLE TO PRESS THE ACCELERATOR NEARLY ALL THE WAY TO THE FLOOR TO CONTINUE GETTING POWER TO THE ENGINE, BUT THE FIRST 2/3 OF THE PEDAL STROKE WERE COMPLETELY UNRESPONSIVE. A CHECK ENGINE LIGHT CAME ON AND IT WAS DIAGNOSED AS A THROTTLE BODY ISSUE. AFTER DOING SOME RESEARCH, THIS SEEMS TO BE A WELL DOCUMENTED ISSUE ON A NUMBER OF TACOMA FORUMS. THE COST TO REPLACE WILL BE $1400 DOLLARS NEW OR $400 DOLLARS USED. I AM SKEPTICAL TO PURCHASE A REFURBISHED PART DUE TO THE KNOWN ISSUE WITH IT. THIS HAS HAPPENED A TOTAL OF 6 TIMES IN 3.5 YEARS OF OWNING THE VEHICLE AND SEEMS TO OCCUR IN COLDER WEATHER. TYPICALLY AFTER PULLING OVER AND SHUTTING THE CAR OFF FOR 30 SECONDS, THE ISSUE IS GONE. IT WILL UNDOUBTEDLY HAPPEN AGAIN, BUT YOU NEVER KNOW WHEN.

THERE IS A SERIOUS HAZARD WITH THE THROTTLE BODY WHERE HITTING THE GAS PEDAL WHEN ACCELERATING WILL SOMETIMES CAUSE THE TRUCK TO ACT AS THOUGH YOU TOOK YOUR FOOT OFF THE PEDAL - TURNING LEFT WITH ONCOMING TRAFFIC ALMOST CAUSED AN ACCIDENT WHEN THE TRUCK DID NOT ACCELERATE AS YOU WOULD EXPECT WHEN PRESSING THE GAS PEDAL. I HAD MY MECHANIC TRY TO DIAGNOSE THE PROBLEM BEFORE LOOKING UP THE SYMPTOMS ONLINE, AND HE TRACED IT TO THE ACTUATOR IN THE ELECTRONIC THROTTLE BODY SYSTEM. RESEARCHING ONLINE AFTER DISCOVERING THIS, IT SEEMS THERE IS A MAJOR ISSUE WITH THE 2003/2004 TRUCKS WITH THIS ELECTRONIC THROTTLE CONTROL SYSTEM HYBRID. THIS IS EXTREMELY DANGEROUS AND I WOULD HAVE THOUGHT THIS WOULD HAVE BEEN RECALLED BASED ON THE KNOWN ISSUES WITH TOYOTA'S THROTTLE CONTROL SYSTEMS IN THE PAST. THE SYSTEM DOES NOT THROW A CHECK ENGINE LIGHT CODE WHEN THIS HAPPENS.

WHILE DRIVING IN TRAFFIC THE THROTTLE STUCK AT ABOVE NORMAL IDLE AND THE CHECK ENGINE LIGHT CAME ON. I WAS ABLE TO EXIT THE TRAFFIC BUT THE IDLE WOULD NOT COME BACK TO NORMAL CURB IDLE. WHAT MY MECHANIC HAS TOLD ME IS THAT THE THROTTLE BODY ASSEMBLY HAS FAILED AND THEY CAN ONLY GET THE PART FROM THE DEALER. IF THIS HAD HAPPENED ON THE FREEWAY THE OUTCOME COULD HAVE NOT BEEN SO GOOD. I HOPE TOYOTA IS AWARE OF THIS PROBLEM AND GOING TO ADDRESS THE SITUATION. *TR

THE PROBLEM THAT EXISTS IS ON MY 2003 TOYOTA TACOMA. IT WILL ALL OF A SUDDEN LOSE POWER AND HAVE NO THROTTLE RESPONSE, ALMOST AS IF IT WAS HITTING AN ENGINE GOVERNOR. THE RPMS USUALLY DROP ANYWHERE FROM 200-500 AND THEN COMES BACK UP. THE POWER WOULD SLOWLY COME BACK AFTER KEEPING MY FOOT ON THE THROTTLE. IT CONSISTENTLY DOES IT AFTER ACCELERATING OUT OF AN INTERSECTION (USUALLY AROUND 25 MPH OR WHILE CRUISING (AROUND BOTH 45 MPH OR 75 MPH) ON THE HIGHWAY. THIS DROP OF POWER OR LACK THEREOF IS A HUGE SAFETY ISSUE, ESPECIALLY WHEN PULLING INTO AN INTERSECTION OR NEEDING QUICK ACCELERATION TO AVOID AN ACCIDENT. I HAVE READ ABOUT MANY OTHERS WITH THE SAME ISSUES WITH THEIR LATE MODEL TACOMAS. THE PARTS TO FIX THE ISSUE ARE VERY COSTLY AND THE PROBLEM SEEMS TO BE WIDESPREAD. [XXX] REQUEST RESEARCH. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

COMING TO A STOP APPROX 2 MPH THE ENGINE SUDDENLY REVVED VERY LOUDLY AND THE TRUCK SHOW FORWARD. THE BRAKES DID NOT STOP THE TRUCK. I SWERVED TO AVOID THE CAMPSITE WE WERE AT AND HIT A TREE VERY HARD. THE ENGINE HOWEVER CONTINUED TO REV LOUDLY AND I SHIFTED TO PARK. WITH THE ENGINE STILL VERY LOUD AND THE WHEELS SPINNING I HAD TO SHUT THE ENGINE BY REMOVING THE KEY. *TR