Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 17 of 26 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seat Belts. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
26 reports
Mileage unknown · Sep 17, 2023
Service BrakesStructureSuspension
Took my truck to a body shop to have dings and a few rusted spots on it repaired. The business owner and repair person put it on the rack and after examination, informed me that it was not worth the repairs, because the frame and undercarriage was too extensive and might as such cause safety issues. I chose not to have it repair…
Read full complaint
Took my truck to a body shop to have dings and a few rusted spots on it repaired. The business owner and repair person put it on the rack and after examination, informed me that it was not worth the repairs, because the frame and undercarriage was too extensive and might as such cause safety issues. I chose not to have it repaired because of this issue.
NHTSA ODI #11545062
Mileage unknown · Jul 13, 2018
Structure
OWNED SINCE 2003, THE TRUCK HAS ONLY 140,000 MILES, BUT MY MECHANIC ADVISES THAT FRAME IS BADLY RUSTED AND IS UNSAFE TO DRIVE. I'VE LEARNED THIS IS A COMMON ISSUE AND THAT TOYOTA HAS AN ACTIVE RECALL. REAR BUMPER HAS ALSO RUSTED THROUGH. I NEED ADVICE ON HOW TO PROCEED. VEHICLE IS PARKED AT MY RESIDENCE.
NHTSA ODI #11111118
99,300 miles · Jun 13, 2016
Service BrakesStructure
TL* THE CONTACT OWNS A 1998 TOYOTA T100. THE CONTACT STATED THAT THE ENTIRE FRAME OF THE VEHICLE HAD SEVERE CORROSION. THE CONTACT OBSERVED BRAKE FLUID LEAKING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 99,300.
NHTSA ODI #10873975
Mileage unknown · Nov 26, 2015
Structure
THE BODY TO FRAME MOUNT HAS RUSTED AWAY BREAKING THREE PARTS OF THE FRAME. THE TOP OF THE FRAME IS THE ONLY PART HOLDING THE TRUCK TOGETHER, CAUSING A SAFETY HAZARD WHICH RESULTED IN NOT BEING ABLE TO PASS STATE INSPECTION.
NHTSA ODI #10807111
98,000 miles · Nov 9, 2015
Unknown Or Other
THE TRUCK HAS 98,000 MILES. THE FRAME IS RUSTED THROUGH ON THE RIGHT SIDE BEHIND THE FRONT WHEEL AND IN FRONT OF THE BACK WHEEL. THE TRUCK WILL NOT PASS PA STATE INSPECTION.
NHTSA ODI #10789353
143,120 miles · Jul 30, 2015
StructureUnknown Or Other
I HAVE A 1998 TOYOTA T100 WITH 143K MILES ON IT. THE FRAME IS NOW BROKE UNDER THE BED NEAR THE FRONT LEAF SPRING SHACKLE, BESIDE A BED MOUNT. THE OTHER SIDE IS ALSO CRACKED BAD AND IS ABOUT TO BREAK. I ALSO NOTICED THE CROSS-MEMBER THAT THE CARRIER BEARING ATTACHES TOO IS ALSO CRACKED ON ONE SIDE AND ALL BUT CRACKED ON THE OTHER…
Read full complaint
I HAVE A 1998 TOYOTA T100 WITH 143K MILES ON IT. THE FRAME IS NOW BROKE UNDER THE BED NEAR THE FRONT LEAF SPRING SHACKLE, BESIDE A BED MOUNT. THE OTHER SIDE IS ALSO CRACKED BAD AND IS ABOUT TO BREAK. I ALSO NOTICED THE CROSS-MEMBER THAT THE CARRIER BEARING ATTACHES TOO IS ALSO CRACKED ON ONE SIDE AND ALL BUT CRACKED ON THE OTHER SIDE. I CALLED TOYOTA BECAUSE I KNOW THEY ARE DOING THE TACOMAS AROUND THE SAME YEAR AS WELL AS THE TUNDRAS. TOYOTA SAID THAT THERE IS NO RECALL OR ANYTHING THEY CAN DO. I KNOW THIS IS AN ISSUE WITH SEVERAL OTHER T100S AND AM VERY UPSET THAT THEY WONT DO ANYTHING WITH THE T100S.
NHTSA ODI #10745043
137,925 miles · Sep 19, 2013
StructureSuspension
TL* THE CONTACT OWNS A 1998 TOYOTA T100. THE CONTACT STATED THAT THE TIRE SPECIALIST ADVISED HIM THAT THE DRIVER'S SIDE REAR FRAME SPRINGS MOUNT WERE SEVERELY CORRODED AND EXHIBITED HOLES. THE TIRE SPECIALIST ADVISED THAT IT WAS UNSAFE TO DRIVE THE VEHICLE. THE TIRE WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. T…
Read full complaint
TL* THE CONTACT OWNS A 1998 TOYOTA T100. THE CONTACT STATED THAT THE TIRE SPECIALIST ADVISED HIM THAT THE DRIVER'S SIDE REAR FRAME SPRINGS MOUNT WERE SEVERELY CORRODED AND EXHIBITED HOLES. THE TIRE SPECIALIST ADVISED THAT IT WAS UNSAFE TO DRIVE THE VEHICLE. THE TIRE WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 137,925.
NHTSA ODI #10544356
Mileage unknown · Sep 11, 2013
Structure
THIS 1998 T100 WAS AN AWESOME TRUCK, BUT LIKE ALL TOYOTAS THE FRAME IS ROTTED THROUGH. THE STEEL THAT IS USED ON THESE IS COMPLETE JUNK.. THIS IS WHERE THE AMERICAN COMPANY'S HAVE IT. I LIKE THE QUESTIONS TO ANSWER, WAS THERE A CRASH? NOT YET, WAS THERE AN INJURY OR FATALITY? WILL THAT MAKE TOYOTA DO A RECALL? I THINK NOT!!…
Read full complaint
THIS 1998 T100 WAS AN AWESOME TRUCK, BUT LIKE ALL TOYOTAS THE FRAME IS ROTTED THROUGH. THE STEEL THAT IS USED ON THESE IS COMPLETE JUNK.. THIS IS WHERE THE AMERICAN COMPANY'S HAVE IT. I LIKE THE QUESTIONS TO ANSWER, WAS THERE A CRASH? NOT YET, WAS THERE AN INJURY OR FATALITY? WILL THAT MAKE TOYOTA DO A RECALL? I THINK NOT!! THE FRAME ON ALL THESE T100 SHOULD BE TAKEN CARE OF BY TOYOTA.. IT JUST SEEMS LIKE TOYOTA JUST DOESN'T CARE ANYMORE. TOYOTA SHOULD GET A HUGE FINE FOR KNOWING THIS PROBLEM, AND DOING NOTHING ABOUT IT... LETS SEE HOW MANY PEOPLE HAVE TO DIE BEFORE SOMETHING IS DONE.. *TR
NHTSA ODI #10543179
65,000 miles · May 1, 2012
Suspension
WHEN BACKING OUT OF A PARKING SPACE LOWER LEFT A-ARM BROKE (RUST) AND LEFT FRONT TIRE COLLAPSED. HAVE LEARNED THAT TOYOTA TACOMA TRUCKS MADE IN '90S HAD DEFECTIVE FRAMES AND THERE WAS A BUY BACK. SHOP TELLS ME MY FRAME IS BAD. TRUCK HAS ONLY 69K MILES ON IT. TRUCK IS PRACTICALLY THE SAME AS A TACOMA, IS TOYOTA DOING ANYTHING F…
Read full complaint
WHEN BACKING OUT OF A PARKING SPACE LOWER LEFT A-ARM BROKE (RUST) AND LEFT FRONT TIRE COLLAPSED. HAVE LEARNED THAT TOYOTA TACOMA TRUCKS MADE IN '90S HAD DEFECTIVE FRAMES AND THERE WAS A BUY BACK. SHOP TELLS ME MY FRAME IS BAD. TRUCK HAS ONLY 69K MILES ON IT. TRUCK IS PRACTICALLY THE SAME AS A TACOMA, IS TOYOTA DOING ANYTHING FOR T-100S? DEALER SAID NO? *JS
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, IF THE STEERING WHEEL IS REPEATEDLY TURNED UNDER CERTAIN CONDITIONS WHERE HIGH STEERING EFFORT AND POWER ASSIST ARE REQUIRED, FOR INSTANCE, WHEN FULLY TURNING THE WHEEL WHILE THE VEHICLE IS STOPPED, A FATIGUE CRACK MAY DEVELOP IN THE STEERING RELAY ROD.
Consequence & remedy
Consequence: IF THE VEHICLE IS CONTINUED TO BE OPERATED IN THIS CONDITION, THE RELAY ROD MAY FRACTURE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE STEERING RELAY ROD. THE RECALL BEGAN OCTOBER 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE02039 · Clutch Pedal Bracket/firewall
Opened Apr 1, 2002 · Closed Jul 30, 2002
Status: closed (inferred from source dates) · Power Train
No summary supplied.
1998 Toyota T100 Problems, Complaints & Recalls | Skip That Year
Illustration