IllustrationMY 1996 TOYOTA T100 FIRE WALL UNDER CLUTCH ASSEMBLY FAILED AND CRACKED FROM FATIGUE. DISTANCE OF CLUTCH TRAVEL WAS INADEQUATE TO DISENGAGE. REPLACED CLUTCH FOR NO REASON. *TR
1996 Toyota T100
Owner reports · Recalls · Investigations
More warning signs than most T100 years
Owner complaints for the 1996 Toyota T100 are substantially higher than the model-year median of 26.
About this comparison →How this year compares
Owner complaints by model year
Compare all T100 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
025–50K
450–75K
1275–100K
7100–150K
12150K+
37 reports with mileage · 72 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports3 injury reports
Power Train complaints
26 reportsCLUTCH MOUNTING BRACKET IS WEAK AND CAUSES BREAKAGE , THEN BREAKS FIRE WALL. HAVE REPAIRED IT 4 TIMES NOW. *TR
CLUTCH PEDAL BRACKET FAILURE. BRACKET IS COMPLETELY BROKEN AT FIREWALL AND CRACKED ON THE SIDE. CAN NOT SHIFT INTO GEAR. DEALER UNABLE TO SAY IF THEY CAN GET REPLACEMENT PART.*AK
THE FIREWALL ON MY 1996 TOYOTA T100 HAS CRACKED WHERE THE MASTER CLUTCH CYLINDER ATTACHES. I AM UNABLE TO GET THE TRUCK INTO GEAR. APPROXIMATELY 80,000 MILES. MANY OTHER PEOPLE HAVE REPORTED THIS PROBLEM AS WELL YET TOYOTA REFUSES TO ACCEPT RESPONSIBILITY. *LA
CLUTCH PEDAL BRACKET CRACKED, CAUSING THE CLUTCH PEDAL TO COLLAPSE TO THE FLOOR AND BE INOPERABLE. *LA
CONSUMER STATES THAT REAR AXLE IS CRACKED ON BOTH SIDES OF VEHICLE. DEALER NOTIFIED.*AK
COULD NOT SHIFT INTO 1ST, 2ND, 5TH, REVERSE. REPLACED CRACKED CLUTCH PEDAL BRACKET AND REPAIRED CRACKS IN FIREWALL WHERE BRACKET ATTACHES. PROBLEM APPEARS TO BE FIXXED. *AK
I READ IN THE LOCAL PAPER THAT THERE HAD BEEN 14 CLUTCH BRACKET FAILURES ON TOYOTA T100 PICKUPS. I HAD THIS OCCUR ON MY PICKUP. THE BRACKET FAILED GRADUALLY OVER TIME UNTIL I THOUGH THE CLUTCH HAD GONE OUT. I TOOK IT TO THE DEALER AND THEY IDENTIFIED THE FAILED BRACKET AS THE ROOT CAUSE. I HAD TO PAY FOR THE REPAIR.*AK
WHILE TRAVELING, NOTICED GEARS WERE HARD TO SHIFT. CONSUMER WAS UNABLE TO SHIFT. DEALER HAS SERVICED VEHICLE AT CONSUMER'S COST. DEALER REPLACED CLUTCH PEDAL BRACKET. *AK TWO DAYS AFTER THE CLUTCH WAS FIXED THERE WAS A LOUD SNAP WHEN THE PEDAL WAS DEPRESSED. IT WAS FOUND THAT THE CLUTCH PEDAL WAS DEFECTIVE. IT WAS REPLACED…
Read full complaint
WHILE TRAVELING, NOTICED GEARS WERE HARD TO SHIFT. CONSUMER WAS UNABLE TO SHIFT. DEALER HAS SERVICED VEHICLE AT CONSUMER'S COST. DEALER REPLACED CLUTCH PEDAL BRACKET. *AK TWO DAYS AFTER THE CLUTCH WAS FIXED THERE WAS A LOUD SNAP WHEN THE PEDAL WAS DEPRESSED. IT WAS FOUND THAT THE CLUTCH PEDAL WAS DEFECTIVE. IT WAS REPLACED AT CONSUMERS EXPENSE AND THE SQUEAK NOISE RETURNED. *JG
FIRST THE CLUTCH PEDAL BRACKET BOLT FELL OUT WHLE STOPPING AT AN INTERSECTION. AFTER PUSHING THE VEHICLE ACROSS THREE LANES OF TRAFFIC I PUT THE BOLT BACK IN AND PROCEEDED TO MY DESTINATION. THE CLUTCH DID NOT SEEM TO WORK CORRECTLY THEREAFTER. I TOOK IT TO AN INDEPENDENT TOYOTA MAINTENANCE SHOP AND HAD THEY ADJUSTED THE CLUTCH …
Read full complaint
FIRST THE CLUTCH PEDAL BRACKET BOLT FELL OUT WHLE STOPPING AT AN INTERSECTION. AFTER PUSHING THE VEHICLE ACROSS THREE LANES OF TRAFFIC I PUT THE BOLT BACK IN AND PROCEEDED TO MY DESTINATION. THE CLUTCH DID NOT SEEM TO WORK CORRECTLY THEREAFTER. I TOOK IT TO AN INDEPENDENT TOYOTA MAINTENANCE SHOP AND HAD THEY ADJUSTED THE CLUTCH PEDAL. THINGS APPEARED TO WORK OK AFTER THAT FOR ABOUT A MONTH. THEN THE BOLT STARTED BACKING OUT AGAIN, SO I OBSERVED THE LOCK WASHER WAS NO LONGER FUNCTIONING AS DESIGNED AND REPLACED THE LOCK WASHER. THINGS SEEMED OK FOR ABOUT ANOTHER MONTH, AND THEN I HEARD POPPING AND SQUEAKING WHEN I DEPRESSED THE CLUTCH PEDAL. ON FURTHER INSPECTION, I FOUND THE CLUTCH PEDAL BRACKET TO BE CRACKED AT THE FIREWALL. TOYOTA CUSTOMER SERVICE REFUSES TO ADMIT THEY HAVE A SAFETY DESIGN PROBLEM AND HAVE NO SERVICE BULLETINS ON THE ISSUE. *AK
Official recalls
105V389000 · Steering:linkages:rod:relay:connecting
Sep 6, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, IF THE STEERING WHEEL IS REPEATEDLY TURNED UNDER CERTAIN CONDITIONS WHERE HIGH STEERING EFFORT AND POWER ASSIST ARE REQUIRED, FOR INSTANCE, WHEN FULLY TURNING THE WHEEL WHILE THE VEHICLE IS STOPPED, A FATIGUE CRACK MAY DEVELOP IN THE STEERING RELAY ROD.
Consequence & remedy
Consequence: IF THE VEHICLE IS CONTINUED TO BE OPERATED IN THIS CONDITION, THE RELAY ROD MAY FRACTURE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE STEERING RELAY ROD. THE RECALL BEGAN OCTOBER 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE02039 · Clutch Pedal Bracket/firewall
Opened Apr 1, 2002 · Closed Jul 30, 2002
Status: closed (inferred from source dates) · Power Train
No summary supplied.