NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,017 reports84,000 miles · May 1, 2009
Latches/locks/linkages
DRIVERS SIDE REAR SLIDING DOOR WILL NOT OPEN...COST TO REPLACE FROM TOYOTA WAS APPROX $500 PARTS. DOOR JUST ALL OF A SUDDEN WAIT WORKING AROUND 55K MILES. NOW THE PASSENGER SIDE DOOR IS NOT WORKING (SLIDING) SAME SYMPTOMS. CAR ONLY HAS 84K MILES ON IT. I DID SOME SEARCHING AND NOTICED THERE ARE QUITE A FEW PEOPLE WITH THE S…
Read full complaint
DRIVERS SIDE REAR SLIDING DOOR WILL NOT OPEN...COST TO REPLACE FROM TOYOTA WAS APPROX $500 PARTS. DOOR JUST ALL OF A SUDDEN WAIT WORKING AROUND 55K MILES. NOW THE PASSENGER SIDE DOOR IS NOT WORKING (SLIDING) SAME SYMPTOMS. CAR ONLY HAS 84K MILES ON IT. I DID SOME SEARCHING AND NOTICED THERE ARE QUITE A FEW PEOPLE WITH THE SAME ISSUES, THEREFORE I AM FILING THIS REPORT. *TR
NHTSA ODI #10267510
34,300 miles · Apr 24, 2009
Power Train
TRANSMISSION FAILED AT SPEED ON I-95. WITH VAN, CARGO AND 5 OCCUPANTS AT TRAFFIC SPEED IN THE RIGHT LANE, THE ENGINE RACED, THE VAN DROPPED OUT OF CRUISE CONTROL, AND WE DRIFTED TO A HALT ON THE SIDE OF THE ROAD. WHILE MOVING, I SHIFTED TO "4" AND "3" THEN BACK TO "D" WITH NO ACCELERATION. HAD WE BEEN IN ANY OTHER LANE, THE T…
Read full complaint
TRANSMISSION FAILED AT SPEED ON I-95. WITH VAN, CARGO AND 5 OCCUPANTS AT TRAFFIC SPEED IN THE RIGHT LANE, THE ENGINE RACED, THE VAN DROPPED OUT OF CRUISE CONTROL, AND WE DRIFTED TO A HALT ON THE SIDE OF THE ROAD. WHILE MOVING, I SHIFTED TO "4" AND "3" THEN BACK TO "D" WITH NO ACCELERATION. HAD WE BEEN IN ANY OTHER LANE, THE TRANSITION WOULD HAVE BEEN HARDER AND MORE DANGEROUS THAN IT WAS. THE ENGINE AND OTHER VAN SYSTEMS CONTINUED TO OPERATE NORMALLY. WHEN WE WERE STOPPED, NO FORWARD GEAR PRODUCED MOVEMENT, THOUGH REVERSE WORKED. A CHECK SHOWED THE TRANSMISSION FLUID AT NORMAL HOT LEVEL, THOUGH IT WAS DARKER THAN NORMAL. IT TOOK AN HOUR ON THE SIDE OF THE ROAD, TRAFFIC PASSING ALONGSIDE THE VAN VERY CLOSE AND VERY FAST, BEFORE A AAA TOW TRUCK GOT TO US. AFTER A TOW TO A TOYOTA DEALERSHIP, THE TRANSMISSION WAS REPLACED UNDER THE POWERTRAIN WARRANTY DUE TO A REPORTED FAILURE OF THE FORWARD SPRAG. THE FAILED TRANSMISSION WAS RETAINED BY THE DEALER. *TR
NHTSA ODI #10266662
30,494 miles · Apr 19, 2009
Structure
SINCE PURCHASING OUR 2006 TOYOTA SIENNA XLE WE HAVE EXPERIENCED PROBLEMS WITH THE POWER SLIDING DOORS - A GRINDING AND/OR RATTLING SOUND AS WELL AS JERKY OPERATION (AS OPPOSED TO OPENING AND CLOSING SMOOTHLY). THE DEALERSHIP GREASED THE CABLES AND TRACK WHICH SEEMED TO ELIMINATE THE SOUNDS. LAST WEEK THE DOOR STOPPED OPENING A…
Read full complaint
SINCE PURCHASING OUR 2006 TOYOTA SIENNA XLE WE HAVE EXPERIENCED PROBLEMS WITH THE POWER SLIDING DOORS - A GRINDING AND/OR RATTLING SOUND AS WELL AS JERKY OPERATION (AS OPPOSED TO OPENING AND CLOSING SMOOTHLY). THE DEALERSHIP GREASED THE CABLES AND TRACK WHICH SEEMED TO ELIMINATE THE SOUNDS. LAST WEEK THE DOOR STOPPED OPENING ALL THE WAY - IT WOULD OPEN ABOUT A QUARTER OF THE WAY AND THEN AUTOMATICALLY CLOSE ON ITS OWN. THIS PROBLEM OCCURRED WHETHER THE DOOR WAS OPERATED WITH THE KEY FOB REMOTE OR THE INTERIOR BUTTON. I CHECKED THE TRACK AND THERE WERE NO OBSTRUCTIONS. WE TOOK THE CAR TO THE DEALERSHIP WHERE IT WAS PURCHASED AND ALTHOUGH THEY COULD REPLICATE THE PROBLEM ONLY ONCE (NATURALLY) THEY REPLACED THE POWER DOOR MOTOR AND CLUTCH ASSEMBLY UNDER WARRANTY (WE ARE WITHIN THE WARRANTY PERIOD). IMPORTANT TO NOTE IS THAT THE REASON THEY REPLACED THE MOTOR AND CLUTCH ASSEMBLY IS BECAUSE WE HAD BROUGHT THE VEHICLE IN COMPLAINING OF THE DOOR OPERATING POORLY IN THE PAST. HAD WE NOT HAD PROBLEMS PREVIOUSLY AND BROUGHT THEM TO THE ATTENTION OF THE DEALERSHIP I SUSPECT THEY WOULD HAVE CLAIMED THERE WERE NO PROBLEMS WITH THE OPERATION OF THE DOOR. THEREFORE, I STRONGLY RECOMMEND THAT ANYONE HAVING ISSUES WITH THEIR POWER SLIDING DOORS REPORT THEIR PROBLEMS TO THE DEALERSHIP AND DOCUMENT THEIR PROBLEMS/COMPLAINTS WITH THE DEALERSHIP. *TR
NHTSA ODI #10265989
23,000 miles · Apr 13, 2009
Service Brakes, HydraulicCrashInjury
I WAS DRIVING DOWN A STREET APPROACHING A 4 WAY STOP. THERE WAS A CAR A GOOD DISTANCE AHEAD OF ME. WHEN I APPLIED THE BRAKES TO STOP, NOTHING HAPPENED.. I PICKED MY FOOT UP AND PUSHED ON THE BRAKE PEDAL AGAIN, STILL GOING FASTER. NOW I AM GETTING PRETTY CLOSE TO THE OTHER CAR WHICH IS STOPPING FOR THE STOP SIGN. I PUSHED…
Read full complaint
I WAS DRIVING DOWN A STREET APPROACHING A 4 WAY STOP. THERE WAS A CAR A GOOD DISTANCE AHEAD OF ME. WHEN I APPLIED THE BRAKES TO STOP, NOTHING HAPPENED.. I PICKED MY FOOT UP AND PUSHED ON THE BRAKE PEDAL AGAIN, STILL GOING FASTER. NOW I AM GETTING PRETTY CLOSE TO THE OTHER CAR WHICH IS STOPPING FOR THE STOP SIGN. I PUSHED HARD AS I COULD ON THE BRAKE (I'M SURE IT WAS THE BRAKE, I PICKED MY FOOT UP AND PUT IT BACK ON THE BRAKE PEDAL AT LEAST 2 OR 3 TIMES) SO I SWERVED TO THE LEFT TO AVOID THE CAR. BY NOW I AM GOING PRETTY FAST. THERE WERE CARS COMING THE OTHER WAY, SO I TRIED TO TURN THE CORNER TO AVOID HITTING THEM, WAS GOING TOO FAST TO MAKE THE CORNER, SO WOUND UP HITTING A CONCRETE WALL. I AM VERY SORE, CHEST, RIGHT HAND, LEFT KNEE. LOTS OF BRUISES, LUCKILY NO BROKEN BONES THAT I KNOW OF. I AM NOT SURE ABOUT THE AIR BAG. THE POLICE ASKED ME IF IT DEPLOYED, I LOOKED DOWN AT THE STEERING COLUMN AND SAW IT THERE, DEFLATED AND WITH A RIP IN IT, BUT I DON'T REMEMBER BEING ACTUALLY HIT WITH IT, HOWEVER I DON'T REMEMBER HITTING MY HAND OR KNEE EITHER,BUT OBVIOUSLY I DID. I HEARD ONE OF THE POLICEMEN SAY I MISTAKENLY HIT THE GAS INSTEAD OF THE BRAKE, BUT THAT IS JUST NOT TRUE. I KNOW I WAS ON THE BRAKE. THE CAR IS TOTALED, SO NO REPAIRS. *TR
NHTSA ODI #10265162
41,000 miles · Apr 11, 2009
Tires
I CONTACTED TOYOTA CUSTOMER SERVICE ON 01/16/2007 (FILE #200701190685) ABOUT VEHICLE DEFECTS OF MY NEWLY PURCHASED 2006 TOYOTA SIENNA BUT DIDN'T RECEIVE ANY RESPONSE EXCEPT THE NOTICE OF RECEPTION OF MY COMPLAIN. PROBLEM: RUN ON LOW TIRE PRESSURE (22 PSI INSTEAD OF INDICATED 35 PSI) FOR ONE YEAR FROM THE TIME I PURCHASED THI…
Read full complaint
I CONTACTED TOYOTA CUSTOMER SERVICE ON 01/16/2007 (FILE #200701190685) ABOUT VEHICLE DEFECTS OF MY NEWLY PURCHASED 2006 TOYOTA SIENNA BUT DIDN'T RECEIVE ANY RESPONSE EXCEPT THE NOTICE OF RECEPTION OF MY COMPLAIN. PROBLEM: RUN ON LOW TIRE PRESSURE (22 PSI INSTEAD OF INDICATED 35 PSI) FOR ONE YEAR FROM THE TIME I PURCHASED THIS VEHICLE FROM THE DEALER TILL THAT I FOUND OUT THE PROBLEM. REASON: THE DEALER (UNIVERSAL TOYOTA SAN ANTONIO) ADMITTED THAT THEY NEEDED TO LOWER THE TIRE PRESSURE OF THE VEHICLE DURING TRANSPORTATION FROM FACTORY TO DEALERSHIP BUT SOMEONE FORGOT TO SET IT BACK BEFORE IT WAS HANDED OUT TO CUSTOMER. THE MAINTENANCE DEALERSHIP (CAVENDER SAN ANTONIO) ALSO DIDN'T DO THEIR JOB TO CHECK THE TIRE PRESSURE UNTIL ONE YEAR LATER I ASKED THEM TO DO SO. TOYOTA SOLUTION FOR THIS PROBLEM: THE MANAGER OF CAVENDER SAN ANTONIO PROMISED TO GIVE ME A FREE TANK OF GAS AND A FREE MAINTENANCE NEXT TIME. I ACCEPTED. HOWEVER, I ASKED THE DEALERSHIP TO REPLACE THE FOUR TIRES BECAUSE THEY WERE DAMAGED, BUT THEY DIDN'T AGREE, ARGUING THAT EVEN UNDER LOW PRESSURE, THESE TIRES SHOULD BE FINE. CONSEQUENCES: THREE OF FOUR TIRES ON THIS VEHICLE WERE DEFLATED ON HIGHWAY IN LESS THAN ONE YEAR (3/22/2008, 9/6/2008, 3/20/2009). THE LAST TIRE DEFLATION WAS TERRIBLE AND ALMOST CAUSED FIVE LIVES ON THE VEHICLE BECAUSE IT WAS SUDDEN AND THE VEHICLE WAS LOST OF CONTROL. THE TIRE PRESSURE ALERT DIDN'T EVEN LIGHT UP AT THE BEGINNING. AFTER THIS ACCIDENT, I DECIDED THAT I CAN'T TAKE ANY CHANCE WITH THESE TIRES AND REPLACED ALL FOUR TIRES. I KEPT ALL THESE RECEIPTS. MY REQUESTS: COMPENSATE THE COST OF THESE TIRES, THE DAMAGE TO MY VEHICLE AND TOYOTA'S NEGLECT FOR SO LONG UNTIL IT BECAME A BIG PROBLEM. *TR
NHTSA ODI #10264986
52,000 miles · Mar 31, 2009
Air BagsCrashInjury
ON MARCH 14, 2009 MY HUSBAND HIT A TREE HEAD ON WITH THE VAN WHILE TRYING TO AVOID A DEER. THE AIRBAG DID NOT DEPLOY. HE HIT HIS HEAD ON THE STEERING WHEEL AND BROKE A BONE IN HIS HAND. THE AIRBAG TRIED TO DEPLOY BUT FAILED. PART OF THE SECTION ON THE STEERING WHEEL IN FRONT OF THE AIRBAG SEPARATED BUT THE BAG DID NOT INFLATE. *…
Read full complaint
ON MARCH 14, 2009 MY HUSBAND HIT A TREE HEAD ON WITH THE VAN WHILE TRYING TO AVOID A DEER. THE AIRBAG DID NOT DEPLOY. HE HIT HIS HEAD ON THE STEERING WHEEL AND BROKE A BONE IN HIS HAND. THE AIRBAG TRIED TO DEPLOY BUT FAILED. PART OF THE SECTION ON THE STEERING WHEEL IN FRONT OF THE AIRBAG SEPARATED BUT THE BAG DID NOT INFLATE. *TR
NHTSA ODI #10263778
71,000 miles · Mar 31, 2009
Air BagsEquipment
2006 TOYOTA SIENNA - AIR BAG LIGHT FLASHING ON DASH. DEALER SAYS NEEDS BOTH DRIVER AND PASSENGER SENSOR REPLACED. COST $995.00 TOYOTA WILL ONLY COVER REPAIR TO 60,000 MILES - CURRENT MILEAGE IS 71,000 MILES GERMAIN TOYOTA WHERE VEHICLE WAS PURCHASED SOLD US A FAKE EXT WARRANTY FOR 100,000 MILES. IF WE WERE SOLD THE TOYOTA WARR…
Read full complaint
2006 TOYOTA SIENNA - AIR BAG LIGHT FLASHING ON DASH. DEALER SAYS NEEDS BOTH DRIVER AND PASSENGER SENSOR REPLACED. COST $995.00 TOYOTA WILL ONLY COVER REPAIR TO 60,000 MILES - CURRENT MILEAGE IS 71,000 MILES GERMAIN TOYOTA WHERE VEHICLE WAS PURCHASED SOLD US A FAKE EXT WARRANTY FOR 100,000 MILES. IF WE WERE SOLD THE TOYOTA WARRANTY THIS PROBLEM WOULD HAVE BEEN COVERED. HAVE CONTACTED THE OHIO AG OFFICE & OHIO DEPT OF INSURANCE. *TR
NHTSA ODI #10263717
31,000 miles · Mar 24, 2009
Visibility
DRIVING ON THE HIGHWAY JUST NORTH OF MERRITT BC APPROXIMATELY 60 MPH THE SUN ROOF BLEW OUT DROPPING GLASS INSIDE OUR VAN AND ON TOP OF THE DRIVER AND PASSENGER. HAD THE SUNROOF TAPED AND SEALED BY SPEEDY GLASS UNTIL WE GET HOME TO CHECK WARRANTIES AND INSURANCE. *TR
NHTSA ODI #10262877
51,000 miles · Mar 5, 2009
Latches/locks/linkagesInjury
THE GAS STRUTS ON THE MANUAL LIFTGATE ON MY TOYOTA SIENNA HAVE FAILED AND THEY ARE ONLY RECALLING TO POWER STRUTS. BUT IF THEY ARE THE SAME STRUTS USED ON THE POWER AND MANUAL LIFTGATE THEN THEY NEED TO BE INCLUDED IN THE RECALL ALSO. THE LIFTGATE ITSELF IS VERY HEAVY AND HAS NEARLY SMASHED ONE OF MY CHILDREN, IT COULD HAVE CU…
Read full complaint
THE GAS STRUTS ON THE MANUAL LIFTGATE ON MY TOYOTA SIENNA HAVE FAILED AND THEY ARE ONLY RECALLING TO POWER STRUTS. BUT IF THEY ARE THE SAME STRUTS USED ON THE POWER AND MANUAL LIFTGATE THEN THEY NEED TO BE INCLUDED IN THE RECALL ALSO. THE LIFTGATE ITSELF IS VERY HEAVY AND HAS NEARLY SMASHED ONE OF MY CHILDREN, IT COULD HAVE CUT HER IN HALF
NHTSA ODI #10260875
Mileage unknown · Mar 4, 2009
Structure
SLIDING DOOR STOPPED WORKING CANNOT OPEN. *TR
NHTSA ODI #10260675
Official recalls
11Oct 18, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.
Consequence & remedy
Consequence: If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Consequence & remedy
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 25, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.
Consequence & remedy
Consequence: THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Remedy: TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 3, 2008
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.
Consequence & remedy
Consequence: IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.
Remedy: DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA08024 · Steering Intermediate Shaft Binding
Opened Oct 28, 2008 · Closed Jul 16, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Additional source detail variants (3)
Steering:column
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
EA06020 · Unexpected Closing Of Power Liftgate
Opened Dec 1, 2006 · Closed Jun 25, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hatchback/liftgate:lock; Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:hinge And Attachments; Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Additional source detail variants (4)
Latches/locks/linkages:hatchback/liftgate:lock
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:hinge And Attachments
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Illustration