NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,017 reports72,000 miles · Jun 1, 2010
Electrical System
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE DRIVING AT APPROXIMATE SPEEDS OF 40 MPH, THE AUTOMOTIVE SKID CONTROL ACTIVATED WITHOUT WARRANT AND WOULD CAUSE THE VEHICLE TO DRIVE AS IF IN NEUTRAL. WHEN THE FAILURE WOULD OCCUR, ALL WARNING LIGHTS WOULD ILLUMINATE ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOS…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE DRIVING AT APPROXIMATE SPEEDS OF 40 MPH, THE AUTOMOTIVE SKID CONTROL ACTIVATED WITHOUT WARRANT AND WOULD CAUSE THE VEHICLE TO DRIVE AS IF IN NEUTRAL. WHEN THE FAILURE WOULD OCCUR, ALL WARNING LIGHTS WOULD ILLUMINATE ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING YET THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 72,000.
NHTSA ODI #10333991
55,000 miles · May 28, 2010
Latches/locks/linkagesStructure
I OWN A 2006 TOYOTA SIENNA VAN AND THE PASSENGER SIDE SLIDING DOOR IS NOT WORKING CORRECTLY. THE SLIDING AUTOMATIC DOOR DOES NOT CLOSE COMPLETELY ON A CONSISTENT BASIS. IT REQUIRES ASSISTANCE TO CLOSE AND WHEN SHUT, IT DOESN'T SEEM TO BE FULLY/SAFELY LATCHED. WE CAN HEAR MORE ROAD NOISE NOW THAT BEFORE. WE CONTRACTED THE LOC…
Read full complaint
I OWN A 2006 TOYOTA SIENNA VAN AND THE PASSENGER SIDE SLIDING DOOR IS NOT WORKING CORRECTLY. THE SLIDING AUTOMATIC DOOR DOES NOT CLOSE COMPLETELY ON A CONSISTENT BASIS. IT REQUIRES ASSISTANCE TO CLOSE AND WHEN SHUT, IT DOESN'T SEEM TO BE FULLY/SAFELY LATCHED. WE CAN HEAR MORE ROAD NOISE NOW THAT BEFORE. WE CONTRACTED THE LOCAL TOYOTA DEALERSHIP WHERE WE PURCHASED THE VAN AND THEY KNEW RIGHT AWAY THAT THE DOOR MOTOR WAS STARTING TO FAIL AND WE WERE TOLD IT COULD NOT BE FIXED WITHOUT REPLACEMENT. WE WERE QUOTED $1800 TO REPAIR WITHOUT ANYONE EVEN WANTING TO LOOK AT THE PROBLEM. THEY INDICATED THAT THIS IS A PRETTY COMMON PROBLEM WITH THESE VANS. AFTER REVIEWING SOME WEB POSTINGS ON THIS PROBLEM, I AM IN THE SAME BOAT AS A LARGE AMOUNT OF CONSUMERS THAT HAVE PURCHASED THIS MAKE/MODEL/YEAR OF VAN. SAFETY IS OF UTMOST CONCERN TO ENSURE MY CHILDREN ARE SAFELY RIDING IN THE PASSENGER AREA OF MY VAN. I AM CONCERNED THAT THIS DOOR CLOSING PROBLEM COULD LEAD TO AN ACCIDENT. TOYOTA IS REFUSING TO PAY FOR THE NECESSARY REPAIRS AND I FEEL THAT THEY SHOULD STAND BEHIND THEIR PRODUCT BETTER. *TR
NHTSA ODI #10332632
127,358 miles · May 25, 2010
Power TrainService Brakes, HydraulicVehicle Speed Control
I WAS DRIVING ON A STRAIGHT, LEVEL DRY ROAD WITH CRUISE CONTROL SET AT 58MPH. SUDDENLY CAR BEGAN TO DOWNSHIFT. ASSUMING TRANSMISSION PROBLEM I DISENGAGED CRUISE CONTROL AND CAR ALMOST CAME TO A STOP. I PUSHED GAS PEDAL AND DROVE IN LOW GEAR TO NEAREST PULL-OFF. DISCOVERED LEFT FRONT BRAKE WAS SMOKING. AFTER THINGS COOLED OF…
Read full complaint
I WAS DRIVING ON A STRAIGHT, LEVEL DRY ROAD WITH CRUISE CONTROL SET AT 58MPH. SUDDENLY CAR BEGAN TO DOWNSHIFT. ASSUMING TRANSMISSION PROBLEM I DISENGAGED CRUISE CONTROL AND CAR ALMOST CAME TO A STOP. I PUSHED GAS PEDAL AND DROVE IN LOW GEAR TO NEAREST PULL-OFF. DISCOVERED LEFT FRONT BRAKE WAS SMOKING. AFTER THINGS COOLED OFF I DROVE CAR IN LOW GEAR ABOUT 6 MILES TO LOCAL SERVICE STATION. MECHANIC FOUND ALL BRAKES LOCKED AND REMOVED ALL WHEELS. HE INSPECTED ALL ROTORS, CALIPERS BRAKE LINES, ETC AND FOUND NO PROBLEMS. (I HAD NEW BRAKES INSTALLED AT DEALERSHIP ABOUT 4 MONTHS EARLIER.) WHEN MECHANIC MANIPULATED LEFT FRONT CALIPER ALL BRAKES DISENGAGED. MECHANIC FOUND BRAKE FLUID LEVEL WAS NORMAL. I'VE DRIVEN CAR ABOUT 500 MILES SINCE PROBLEM OCCURRED WITH NO PROBLEMS. I DON'T USE CRUISE CONTROL OFTEN - AND HAVEN'T USED IT SINCE PROBLEM OCCURRED. I'M WONDERING IF PROBLEM IS WITH CRUISE CONTROL RATHER THAN BRAKES?? THIS COULD HAVE BEEN A DISASTER IF IT HAPPENED ON A FREEWAY AT HIGHER SPEEDS! *TR
NHTSA ODI #10332104
55,793 miles · May 20, 2010
Structure
TL*THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHEN THE CONTACT OPENED THE HATCHBACK, IT CLOSED WITH FORCE ON HER BACK. SHE WAS NOT INJURED. SHE ALSO ALLOWED THE HATCHBACK TO CLOSE WHEN THE COMPLAINT WAS FILED IN ORDER TO DEMONSTRATE THE SOUND OF IT CLOSING. SHE NOTIFIED TOYOTA REGARDING A PREVIOUS RECALL FOR THE HYDRAULIC LIFT AND W…
Read full complaint
TL*THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHEN THE CONTACT OPENED THE HATCHBACK, IT CLOSED WITH FORCE ON HER BACK. SHE WAS NOT INJURED. SHE ALSO ALLOWED THE HATCHBACK TO CLOSE WHEN THE COMPLAINT WAS FILED IN ORDER TO DEMONSTRATE THE SOUND OF IT CLOSING. SHE NOTIFIED TOYOTA REGARDING A PREVIOUS RECALL FOR THE HYDRAULIC LIFT AND WAS INFORMED THAT WAS NOT RELATED TO HER YEAR, MAKE AND MODEL VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 55,793.
NHTSA ODI #10331404
Mileage unknown · May 2, 2010
Air Bags
I HAVE 2006 SIENNA LE. AIRBAGS SIGNAL IS ON AND OFF IN THE DASHBOARD. ITS JUST UNDER 30000 MILES AND 3+ YEARS. ITS REALLY FRUSTRATING AND AFTER DEEP RESEARCH IT LOOKS LIKE ALL THE OWNERS HAVE SIMILAR PROBLEMS. TOYOTA SHOULD RECALL THIS ASAP. *TR
NHTSA ODI #10328397
Mileage unknown · Apr 30, 2010
Power Train
2006 TOYOTA SIENNA SURGE AND DECELERATION WHILE DRIVING. SEEMS THE VEHICLE CAN'T DECIDE WHICH GEAR TO GO IN. *KB THE CONSUMER STATED THE TRANSMISSION WOULD SHIFT LATE AT TIMES.
NHTSA ODI #10317595
Mileage unknown · Apr 28, 2010
Vehicle Speed Control
2006 TOYOTA SIENNA CONCERN *GR THE CONSUMER STATED THE VEHICLE SEEMED TO TRAVEL EXTREMELY FAST EVEN THOUGH SHE WAS DRIVING BETWEEN 60-65 MPH.
NHTSA ODI #10327451
48,000 miles · Apr 24, 2010
Latches/locks/linkagesStructure
SIDE SLIDING DOOR CABLE/MOTOR BROKE. THERE IS NO WAY TO MANUALLY CLOSE DOOR WHEN THIS HAPPENS. I HAD TO DRIVE A CONSIDERABLE DISTANCE WITH 3 LITTLE KIDS IN THE CAR AND THE SIDE DOOR OPEN. TOYOTA HAS TO REPLACE THE CABLE AND MOTOR ASSEMBLY AND WILL CHARGE $1800 TO DO THAT. *TR
NHTSA ODI #10327293
68,000 miles · Apr 23, 2010
Structure
WE HAVE A 2006 TOYOTA SIENNA THAT WE HAVE HAD FOR 3 YEARS. YESTERDAY THE PASSENGER SIDE AUTOMATIC DOOR JAMMED. I HAD TO MANUALLY CLOSE IT AS FAR AS I COULD. I HAD TO DRIVE AROUND WITH IT PARTIALLY OPEN. WHEN I GOT HOME I GOT DOWN UNDER IT AND NOTICED THAT A PIECE OF PLASTIC CASING THAT SURROUNDS THE CABLE(THAT SHUTS THE DOOR…
Read full complaint
WE HAVE A 2006 TOYOTA SIENNA THAT WE HAVE HAD FOR 3 YEARS. YESTERDAY THE PASSENGER SIDE AUTOMATIC DOOR JAMMED. I HAD TO MANUALLY CLOSE IT AS FAR AS I COULD. I HAD TO DRIVE AROUND WITH IT PARTIALLY OPEN. WHEN I GOT HOME I GOT DOWN UNDER IT AND NOTICED THAT A PIECE OF PLASTIC CASING THAT SURROUNDS THE CABLE(THAT SHUTS THE DOOR) WAS CRACKED OPEN, IT HAD SPLIT OFF OF THE CABLE AND WAS WRAPPING ALL AROUND THE WHEELS THAT SLIDE IN THE CHANNEL THAT SHUTS THE DOOR. THERE WAS ALSO A LARGER PIECE OF PLASTIC THAT HAD BROKEN OFF SOMEWHERE UP INSIDE THE DOOR. NOW THE AUTOMATIC DOOR WON'T WORK AT ALL, NOR WILL IT OPEN OR SHUT MANUALLY WITHOUT A LOT OF FORCE. I CALLED THE DEALERSHIP AND FOUND OUT THAT THERE WAS NOT A RECALL ON THIS WHICH IS SURPRISING US BECAUSE OF ALL OF THE COMPLAINTS ONLINE ABOUT THIS PROBLEM. THE DEALER INFORMED ME THAT IT WOULD COST $1200-1500 TO FIX THE PROBLEM BECAUSE THE CABLE IS COMBINED WITH THE MOTOR. OBVIOUSLY THE DESIGN IS INFERIOR AND THEY HAVE USED CHEAP PLASTIC PARTS IN THE MANUFACTURING. I ALSO THINK TOYOTA IS PRICE GOUGING BECAUSE THEIR DESIGN IS COMBINED INTO A "ONE UNIT" PRICE TO FIX THIS PROBLEM. NOW WE ARE GOING TO BE FORCED TO CUT THE CABLE THAT RUNS THE AUTOMATIC DOOR, JUST TO BE ABLE TO OPERATE THE DOOR MANUALLY. WHO CAN AFFORD TO PUT OUT THAT KIND OF MONEY FOR A DOOR MOTOR? MY VEHICLE ONLY HAS 68,000 MILES ON IT. PLEASE HELP US. HELP THE LITTLE GUY. TOYOTA HAS ALREADY GIVEN OUT EXTENDED WARRANTY/RECALLS ON THIS VEHICLE FOR THE TWO FRONT DOORS - POPPING. AND THE REAR HATCH STRUTS. I THINK THIS PROBLEM SHOULD BE ADDED TO THIS LIST. TOYOTA NEEDS TO BE HELD RESPONSIBLE FOR THIS POOR WORKMANSHIP. THANK YOU FOR YOUR CONSIDERATION. *TR
NHTSA ODI #10327235
26,000 miles · Apr 23, 2010
Service Brakes, Hydraulic
TL* THE CONTACT OWNS 2006 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING AT SPEEDS OF 50 MPH DOWN AN OFF RAMP, THE BRAKE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE BRAKES THEN ENGAGED WITHOUT DRIVER INTENT, RAPIDLY DECREASING THE VEHICLE SPEED FROM 50 MPH TO 20 MPH. THE DEALER ADVISED THERE WERE NO FAILURES WI…
Read full complaint
TL* THE CONTACT OWNS 2006 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING AT SPEEDS OF 50 MPH DOWN AN OFF RAMP, THE BRAKE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE BRAKES THEN ENGAGED WITHOUT DRIVER INTENT, RAPIDLY DECREASING THE VEHICLE SPEED FROM 50 MPH TO 20 MPH. THE DEALER ADVISED THERE WERE NO FAILURES WITHIN THE VEHICLE. THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 26,000 AND THE CURRENT MILEAGE WAS 27,000.
NHTSA ODI #10327185
Official recalls
11Oct 18, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.
Consequence & remedy
Consequence: If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Consequence & remedy
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 25, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.
Consequence & remedy
Consequence: THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Remedy: TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 3, 2008
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.
Consequence & remedy
Consequence: IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.
Remedy: DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA08024 · Steering Intermediate Shaft Binding
Opened Oct 28, 2008 · Closed Jul 16, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Additional source detail variants (3)
Steering:column
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
EA06020 · Unexpected Closing Of Power Liftgate
Opened Dec 1, 2006 · Closed Jun 25, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hatchback/liftgate:lock; Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:hinge And Attachments; Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Additional source detail variants (4)
Latches/locks/linkages:hatchback/liftgate:lock
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:hinge And Attachments
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Illustration