IllustrationTRACTION CONTROL AND ABS ACTIVATED ON DRY ROADS ACTING LIKE THE VEHICLE THOUGHT IT WAS GOING INTO A SLIDE/SKID. THIS COULD HAVE CAUSED A SERIOUS CRASH!
2006 Toyota Sienna
Owner reports · Recalls · Investigations
More warning signs than most Sienna years
Owner complaints for the 2006 Toyota Sienna are substantially higher than the model-year median of 183.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sienna years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1000–25K
14425–50K
19150–75K
17875–100K
142100–150K
65150K+
820 reports with mileage · 197 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 307 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 261 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 85 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports2 fire reports37 injury reports
Steering complaints
61 reportsTHE SLIP INDICATOR LIGHT (CAR WITH SWERVE LINES) STARTED COMING ON INTERMITTENTLY WHILE TURNING ON HIGHWAYS ETC. (BUT NOT WHEN ANY RISK OF TIRE SLIPPING). THEN VSC LIGHT ALSO CAME ON AND ALARM SOMETIMES SOUNDED. VISIT TO OUR OWN MECHANIC, NO PROBLEMS FOUND. IN THE LAST 2 YEARS THE ABS SYSTEM HAS ACTIVATED (DAILY) IT UNEXPECT…
Read full complaint
THE SLIP INDICATOR LIGHT (CAR WITH SWERVE LINES) STARTED COMING ON INTERMITTENTLY WHILE TURNING ON HIGHWAYS ETC. (BUT NOT WHEN ANY RISK OF TIRE SLIPPING). THEN VSC LIGHT ALSO CAME ON AND ALARM SOMETIMES SOUNDED. VISIT TO OUR OWN MECHANIC, NO PROBLEMS FOUND. IN THE LAST 2 YEARS THE ABS SYSTEM HAS ACTIVATED (DAILY) IT UNEXPECTEDLY APPLIES THE BRAKES WHILE IN MOTION. IT IS ON SPECIFIC TYPES OF CURVE AND WHILE DRIVING AT LEAST 30MPH, BUT HAS DONE AT 35, 55, 70 MPH, ON SLIGHT OR MEDIUM TURNS (NOT REAL SHARP TURNS), GOING UPHILL OR DOWNHILL AND LEFT OR RIGHT. TOOK MY MECHANIC FOR A RIDE WITH THE DIAGNOSTIC COMPUTER HOOKED UP, IT DID THE ABS BRAKING, WARNING LIGHT, AND BEEPING 5 TIMES BUT COMPUTER SHOWED NO CODES. SUGGESTED RESETTING YAW WHICH WE DID, IT DID NOT HELP. SUGGESTED CALLING TOYOTA, THEY WERE NO HELP, SAID THEY HAD NEVER HEARD OF THAT PROBLEM AND MY MECHANIC PROBABLY DID NOT KNOW HOW TO READ THE COMPUTER. WHEN ABS ACTIVATES IT'S VERY DANGEROUS - THINKING ABOUT DEACTIVATING ENTIRE VSC SYSTEM. I BELIEVE THE RACK AND PINION MAY PLAY A ROLE, THERE ARE RATTLE AND BUMP SOUNDS, PERHAPS A LOOSE SUSPENSION IS THE CULPRIT, THAT IS OUR NEXT OPTION. I HAVE ALREADY REPLACED STRUTS, FRONT WHEEL BEARINGS, ALL NEW TIRES, HAD IT ALIGNED, DID NEW BRAKE PADS, AND ROTORS. ABSOLUTELY FED UP WITH THIS PROBLEM! *TR
ELECTRONIC ANTI-SWAY OVERRIDE KICKS IN FOR NO APPARENT REASON AT HIGHWAY SPEEDS. USUALLY WHEN TAKING SLIGHT BANKS OR TURNS OVER 35 MPH.
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHEN THE CONTACT DEPRESSED THE ACCELERATOR PEDAL, THE STEERING WHEEL SEIZED. THE CONTACT ATTEMPTED TO STOP THE VEHICLE, BUT THE BRAKE PEDAL FAILED TO OPERATE. THE VEHICLE SPUN AROUND AT LEAST FOUR TIMES TO THE LEFT AND CRASHED INTO A PARKED VEHICLE TWICE WHILE SPINNING. THE CONTACT QUIC…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHEN THE CONTACT DEPRESSED THE ACCELERATOR PEDAL, THE STEERING WHEEL SEIZED. THE CONTACT ATTEMPTED TO STOP THE VEHICLE, BUT THE BRAKE PEDAL FAILED TO OPERATE. THE VEHICLE SPUN AROUND AT LEAST FOUR TIMES TO THE LEFT AND CRASHED INTO A PARKED VEHICLE TWICE WHILE SPINNING. THE CONTACT QUICKLY POWERED OFF THE ENGINE TO STOP THE VEHICLE FROM SPINNING. THE CONTACT WAITED ONE HOUR BEFORE THE VEHICLE WAS RESTARTED AND WAS ABLE TO DRIVE HOME. THE CONTACT STATED THAT SHE WAS IN SHOCK AND WAS NOT AWARE OF ANY WARNING INDICATORS ILLUMINATED. THE CONTACT SUSTAINED FOOT, RIGHT HIP, AND BACK INJURIES. THE FRONT PASSENGER ALSO SUSTAINED BACK INJURIES. BOTH OCCUPANTS REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
CHECK ENGINE LIGHT, VSC LIGHT, TRACTION CONTROL LIGHT. ALL 3 LIGHTS CAME ON AT SAME TIME. THEY SAY IT'S THE GAS CAP, IT'S NOT THE GAS CAP, THEY SAY TO RESET IT, THAT DOESN'T WORK. I WAS DRIVING HOME, NOTHING HAPPENED, THE LIGHTS JUST CAME ON. NO WARNING SOUND, NOTHING TO INDICATE THERE WAS A PROBLEM, MY CAR SEEMS TO DRIVE JUST F…
Read full complaint
CHECK ENGINE LIGHT, VSC LIGHT, TRACTION CONTROL LIGHT. ALL 3 LIGHTS CAME ON AT SAME TIME. THEY SAY IT'S THE GAS CAP, IT'S NOT THE GAS CAP, THEY SAY TO RESET IT, THAT DOESN'T WORK. I WAS DRIVING HOME, NOTHING HAPPENED, THE LIGHTS JUST CAME ON. NO WARNING SOUND, NOTHING TO INDICATE THERE WAS A PROBLEM, MY CAR SEEMS TO DRIVE JUST FINE, BUT THE LIGHTS WON'T GO OFF, AND I HAVE 3 KIDS THAT I TAKE AND PICK UP FROM SCHOOL
I WAS DRIVING 65 MPH ON THE HIGHWAY GOING STRAIGHT ON DRY PAVEMENT AND SUDDENLY A BUZZER SOUNDED, THE VSC LIGHT CAME ON, AND THE STEERING WHEEL AND BRAKES WERE TAKEN OVER BY THE VSC SYSTEM AND THE CAR STARTED WEAVING OUT OF CONTROL. I COULD NOT STEER OR BREAK THE CAR. THE SITUATION IS UNPREDICTABLE. IT EASILY HAPPENED ON CURVY…
Read full complaint
I WAS DRIVING 65 MPH ON THE HIGHWAY GOING STRAIGHT ON DRY PAVEMENT AND SUDDENLY A BUZZER SOUNDED, THE VSC LIGHT CAME ON, AND THE STEERING WHEEL AND BRAKES WERE TAKEN OVER BY THE VSC SYSTEM AND THE CAR STARTED WEAVING OUT OF CONTROL. I COULD NOT STEER OR BREAK THE CAR. THE SITUATION IS UNPREDICTABLE. IT EASILY HAPPENED ON CURVY OR BEND ROAD AND HAS HAPPENED 3-4 TIMES IN THIS YEAR. IT IS SCARY.
TOOK MY SIENNA 2006 FOR A CHECK UP AND WAS TOLD THAT THE POWER STEERING FLUID IS LEAKING, REQUIRING THE INSTALLATION OF A NEW RACK AND PINION UNIT. TOYOTA RECALLED 2006 TOYOTA SIENNA IN 2011 FOR THIS VERY PROBLEM. I CALLED THE MANUFACTURER BUT THEY ARE UNWILLING TO FIX MY TOYOTA. THEY CLAIM THAT MY VIN NUMBER WAS NOT PART OF THE…
Read full complaint
TOOK MY SIENNA 2006 FOR A CHECK UP AND WAS TOLD THAT THE POWER STEERING FLUID IS LEAKING, REQUIRING THE INSTALLATION OF A NEW RACK AND PINION UNIT. TOYOTA RECALLED 2006 TOYOTA SIENNA IN 2011 FOR THIS VERY PROBLEM. I CALLED THE MANUFACTURER BUT THEY ARE UNWILLING TO FIX MY TOYOTA. THEY CLAIM THAT MY VIN NUMBER WAS NOT PART OF THE 2011 RECALL. INSTEAD, TOYOTA DID OFFER A $ 1000 TOWARDS THE PURCHASE OF A CERTIFIED TOYOTA VEHICLE. I FELT I SHOULD REPORT THIS ISSUE BECAUSE IT IS A SAFETY CONCERN AND OTHER DRIVERS MIGHT BE EXPERIENCING THE SAME PROBLEM. IN ADDITION, EVER SINCE I BOUGHT THIS CAR BACK IN 2012, I NOTICED THAT THE ALIGNMENT WAS NEVER QUITE RIGHT EVEN THOUGH DID THE ALIGNMENT TWO TIMES. I NOW THINK I KNOW WHY: THE RACK AND PINION ALREADY HAD AN ISSUE BACK THEN.
AT 90K MILES, POWER STEERING FLUID LEAKAGE AT RACK AND PINION. PASSENGER SIDE BOOT TORN.
WHILE DRIVING THE STABILITY WARNING LIGHT COMES ON, STARTS BEEPING LOUDLY AND MY BRAKES AND STEERING WHEEL LOCK UP. THIS HAS HAPPENED MULTIPLE TIMES ON THE FREEWAY, ON FREEWAY ENTRANCES WITH A SLIGHT TURN AND EVEN WHILE JUST DRIVING STRAIGHT. EACH TIME, THE WEATHER WAS CLEAR AND THE ROADS ARE DRY. THIS HAPPENS WHETHER I AM DR…
Read full complaint
WHILE DRIVING THE STABILITY WARNING LIGHT COMES ON, STARTS BEEPING LOUDLY AND MY BRAKES AND STEERING WHEEL LOCK UP. THIS HAS HAPPENED MULTIPLE TIMES ON THE FREEWAY, ON FREEWAY ENTRANCES WITH A SLIGHT TURN AND EVEN WHILE JUST DRIVING STRAIGHT. EACH TIME, THE WEATHER WAS CLEAR AND THE ROADS ARE DRY. THIS HAPPENS WHETHER I AM DRIVING AT A SLOW SPEED ENTERING A SLIGHT TURN ON THE HIGHWAY ANYWHERE FROM 20 TO 40 MPH AND HAS RECENTLY HAPPENED WHILE DRIVING ABOUT 50 MPH ON A DRY HIGHWAY JUST DRIVING STRAIGHT. THE CAR HAS ALSO BEGAN BEEPING AND FLASHING THE STABILITY LIGHT WITHOUT LOCKING UP THE STEERING AND BRAKES. I HAVE ALMOST CAUSE A FEW ACCIDENTS WITH CARS ALMOST REAR ENDING MY VAN AND ME ALMOST SIDESWIPING OTHER CARS WHILE THIS IS HAPPENING AND I HAVE NO CONTROL OF THE CAR. THIS IS FRIGHTENING! I HAVE HAD MY STRUTS REPLACED, RIGHT DRIVE SHAFT, BRAKES, TIRES, ALIGNMENT. THE REPAIR SHOPS SAY THEY HAVE NOT BEEN ABLE TO DUPLICATE THIS ISSUE WHEN THEY DRIVE IT. THERE DOES NOT APPEAR TO BE A RECALL ON ANYTHING TO DO WITH THIS WHICH IS SHOCKING. I HAVE A SIENNA VAN SO I CAN CARRY MULTIPLE PEOPLE WITH ME. I HAVE MY INFANT GRANDCHILD WITH ME IN THIS VAN EACH DAY AS WELL AS MY TEENAGE DAUGHTER. I HAVE AN APPOINTMENT WITH MAITA TOYOTA TOMORROW MORNING (1/25/18), WE'LL SEE WHAT THEY SAY, BUT HONESTLY, I FEEL TOYOTA NEEDS TO STAND BY THEIR CARS AND FIX THIS ISSUE AT NO CHARGE. THERE ARE COMPLAINTS DESCRIBING THIS EXACT ISSUE ALL OVER THE INTERNET SO IT IS NOT AN ISOLATED PROBLEM. THIS FORM ASKS FOR THE DATE THIS HAPPENED BELOW, I'LL ADD TODAYS DATE, BUT IT HAS BEEN GOING ON FOR OVER A YEAR.
SOMETIMES WHEN STARTING FOR THE FIRST TIME, I TRY TO TURN THE WHEEL BUT IT IS LOCKED (AS IF IT IS ALL THE WAY TO ONE SIDE BUT IT IS NOT) - THE WHEELS ARE TURNED THE OPPOSITE SIDE. THE TIMES I HAVE NOTICED THIS BEHAVIOR MY WHEELS HAVE BEEN TURNED TO THE RIGHT, AND WHEN I TRY TO BACK OUT OF THE DRIVEWAY I AM TRYING TO TURN THE WH…
Read full complaint
SOMETIMES WHEN STARTING FOR THE FIRST TIME, I TRY TO TURN THE WHEEL BUT IT IS LOCKED (AS IF IT IS ALL THE WAY TO ONE SIDE BUT IT IS NOT) - THE WHEELS ARE TURNED THE OPPOSITE SIDE. THE TIMES I HAVE NOTICED THIS BEHAVIOR MY WHEELS HAVE BEEN TURNED TO THE RIGHT, AND WHEN I TRY TO BACK OUT OF THE DRIVEWAY I AM TRYING TO TURN THE WHEEL TO THE LEFT BUT THE STEERING WHEEL IS LOCKED UP AS IF IT IS ALL THE WAY LEFT AND CANT GO ANY MORE. TO FREE IT UP I NEED TO TURN THE WHEEL SLIGHTLY TO THE RIGHT (MAYBE A QUARTER TURN) THEN I CAN TURN THE STEERING WHEEL BACK TO THE LEFT A COUPLE TURNS IF I LIKE AND EVERYTHING IS NORMAL. I USUALLY NOTICE THIS ON SUNDAY MORNINGS - THE CAR MAY HAVE BEEN SITTING ALL DAY SATURDAY .. I AM TRYING TO PUT MY FINGER ON IT BUT CAN'T SEEM TO. I HAVE NOT NOTICED ANY ISSUES WHILE DRIVING DOWN THE ROAD .. BUT IT IS A LITTLE CONCERNING. THE PROBLEM HAS BEEN HAPPENING FOR QUITE SOME TIME NOW AND I THOUGHT MAYBE I SHOULD REPORT THIS .
Official recalls
1117V657000 · Power Train:automatic Transmission
Oct 18, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.
Consequence & remedy
Consequence: If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.
16V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
14V273000 · Tires:temporary/emergency Spare Tire
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
10V270000 · Seats
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
10V160000 · Structure
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Consequence & remedy
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V234000 · Equipment:other:labels
Jun 25, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.
Consequence & remedy
Consequence: THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Remedy: TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
09V223000 · Equipment:other:labels
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
08V244000 · Structure:body:hatchback/liftgate
Jun 3, 2008
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.
Consequence & remedy
Consequence: IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.
Remedy: DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA08024 · Steering Intermediate Shaft Binding
Opened Oct 28, 2008 · Closed Jul 16, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Additional source detail variants (3)
Steering:column
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
EA06020 · Unexpected Closing Of Power Liftgate
Opened Dec 1, 2006 · Closed Jun 25, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hatchback/liftgate:lock; Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:hinge And Attachments; Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Additional source detail variants (4)
Latches/locks/linkages:hatchback/liftgate:lock
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:hinge And Attachments
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.