NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
50 reportsClear category filter99,000 miles · Aug 3, 2018
Service BrakesSteeringVehicle Speed Control
I WAS DRIVING 65 MPH ON THE HIGHWAY GOING STRAIGHT ON DRY PAVEMENT AND SUDDENLY A BUZZER SOUNDED, THE VSC LIGHT CAME ON, AND THE STEERING WHEEL AND BRAKES WERE TAKEN OVER BY THE VSC SYSTEM AND THE CAR STARTED WEAVING OUT OF CONTROL. I COULD NOT STEER OR BREAK THE CAR. THE SITUATION IS UNPREDICTABLE. IT EASILY HAPPENED ON CURVY…
Read full complaint
I WAS DRIVING 65 MPH ON THE HIGHWAY GOING STRAIGHT ON DRY PAVEMENT AND SUDDENLY A BUZZER SOUNDED, THE VSC LIGHT CAME ON, AND THE STEERING WHEEL AND BRAKES WERE TAKEN OVER BY THE VSC SYSTEM AND THE CAR STARTED WEAVING OUT OF CONTROL. I COULD NOT STEER OR BREAK THE CAR. THE SITUATION IS UNPREDICTABLE. IT EASILY HAPPENED ON CURVY OR BEND ROAD AND HAS HAPPENED 3-4 TIMES IN THIS YEAR. IT IS SCARY.
NHTSA ODI #11115614
130,000 miles · Jul 14, 2018
Service Brakes
THE VEHICLE WAS IN MOTION . DRIVING UP THE MOUNTAIN . WHEN THE TRACTION CONTROL SENSORS WENT ON AND BRAKED AND BEGAN MOVING THE STEERING WHEEL . ALARMS WHERE GOING OFF WHEN NO DANGER OCCURRED . THE NEXT TWO HOURS THE SENSORS WOULD ALARM. DID NOT MATTER HOW SLOW OR FAST WE DROVE IT WOULD BRAKE GOING UP AND DOWN THE HILL. TOOK…
Read full complaint
THE VEHICLE WAS IN MOTION . DRIVING UP THE MOUNTAIN . WHEN THE TRACTION CONTROL SENSORS WENT ON AND BRAKED AND BEGAN MOVING THE STEERING WHEEL . ALARMS WHERE GOING OFF WHEN NO DANGER OCCURRED . THE NEXT TWO HOURS THE SENSORS WOULD ALARM. DID NOT MATTER HOW SLOW OR FAST WE DROVE IT WOULD BRAKE GOING UP AND DOWN THE HILL. TOOK CAR TO DEALERSHIP AND THEY STATED THAT IT WAS A YAW SENSOR MALFUNCTION PART NUMBER 89180-45010. $900+ CHARGE
NHTSA ODI #11111343
59,000 miles · Jul 9, 2018
Electrical SystemEngineService Brakes
A/C SYSTEM HAS HAD PROBLEMS SINCE 2010, THEY REPLACED THE BELTS & TOLD ME IT WAS FINE UNTIL THE WARRANTY EXPIRED.I HAVE HAD RECALLS ON ALL THE DOORS, AIRBAGS &NAV SYSTEM REPLACED THREE TIMES, 2013 A/C WAS REPLACED, 2016 A/C REPLACED AGAIN, & A/C IS BEING REPLACED FOR A 3RD TIME ALONG WITH TWO OTHER RECALLS. TIRE WARNINGS ARE PE…
Read full complaint
A/C SYSTEM HAS HAD PROBLEMS SINCE 2010, THEY REPLACED THE BELTS & TOLD ME IT WAS FINE UNTIL THE WARRANTY EXPIRED.I HAVE HAD RECALLS ON ALL THE DOORS, AIRBAGS &NAV SYSTEM REPLACED THREE TIMES, 2013 A/C WAS REPLACED, 2016 A/C REPLACED AGAIN, & A/C IS BEING REPLACED FOR A 3RD TIME ALONG WITH TWO OTHER RECALLS. TIRE WARNINGS ARE PERSISTENT. I'VE NEVER WORN OUT TIRES OR BRAKES BEFORE, EXCEPT WITH THIS VEHICLE AT A RATE OF EVERY 25,000 MILES. (4TIMES TD)
NHTSA ODI #11110354
143,332 miles · Mar 15, 2018
Air BagsEngineService Brakes
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE DRIVING 25 MPH, THE VEHICLE STALLED AND THE AIR BAG AND BRAKE WARNING INDICATORS ILLUMINATED. THE CONTACT HEARD AN ABNORMAL BEEPING NOISE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE DRIVING 25 MPH, THE VEHICLE STALLED AND THE AIR BAG AND BRAKE WARNING INDICATORS ILLUMINATED. THE CONTACT HEARD AN ABNORMAL BEEPING NOISE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 143,332.
NHTSA ODI #11079614
120,000 miles · Jan 24, 2018
Electronic Stability Control (esc)Service BrakesSteering
WHILE DRIVING THE STABILITY WARNING LIGHT COMES ON, STARTS BEEPING LOUDLY AND MY BRAKES AND STEERING WHEEL LOCK UP. THIS HAS HAPPENED MULTIPLE TIMES ON THE FREEWAY, ON FREEWAY ENTRANCES WITH A SLIGHT TURN AND EVEN WHILE JUST DRIVING STRAIGHT. EACH TIME, THE WEATHER WAS CLEAR AND THE ROADS ARE DRY. THIS HAPPENS WHETHER I AM DR…
Read full complaint
WHILE DRIVING THE STABILITY WARNING LIGHT COMES ON, STARTS BEEPING LOUDLY AND MY BRAKES AND STEERING WHEEL LOCK UP. THIS HAS HAPPENED MULTIPLE TIMES ON THE FREEWAY, ON FREEWAY ENTRANCES WITH A SLIGHT TURN AND EVEN WHILE JUST DRIVING STRAIGHT. EACH TIME, THE WEATHER WAS CLEAR AND THE ROADS ARE DRY. THIS HAPPENS WHETHER I AM DRIVING AT A SLOW SPEED ENTERING A SLIGHT TURN ON THE HIGHWAY ANYWHERE FROM 20 TO 40 MPH AND HAS RECENTLY HAPPENED WHILE DRIVING ABOUT 50 MPH ON A DRY HIGHWAY JUST DRIVING STRAIGHT. THE CAR HAS ALSO BEGAN BEEPING AND FLASHING THE STABILITY LIGHT WITHOUT LOCKING UP THE STEERING AND BRAKES. I HAVE ALMOST CAUSE A FEW ACCIDENTS WITH CARS ALMOST REAR ENDING MY VAN AND ME ALMOST SIDESWIPING OTHER CARS WHILE THIS IS HAPPENING AND I HAVE NO CONTROL OF THE CAR. THIS IS FRIGHTENING! I HAVE HAD MY STRUTS REPLACED, RIGHT DRIVE SHAFT, BRAKES, TIRES, ALIGNMENT. THE REPAIR SHOPS SAY THEY HAVE NOT BEEN ABLE TO DUPLICATE THIS ISSUE WHEN THEY DRIVE IT. THERE DOES NOT APPEAR TO BE A RECALL ON ANYTHING TO DO WITH THIS WHICH IS SHOCKING. I HAVE A SIENNA VAN SO I CAN CARRY MULTIPLE PEOPLE WITH ME. I HAVE MY INFANT GRANDCHILD WITH ME IN THIS VAN EACH DAY AS WELL AS MY TEENAGE DAUGHTER. I HAVE AN APPOINTMENT WITH MAITA TOYOTA TOMORROW MORNING (1/25/18), WE'LL SEE WHAT THEY SAY, BUT HONESTLY, I FEEL TOYOTA NEEDS TO STAND BY THEIR CARS AND FIX THIS ISSUE AT NO CHARGE. THERE ARE COMPLAINTS DESCRIBING THIS EXACT ISSUE ALL OVER THE INTERNET SO IT IS NOT AN ISOLATED PROBLEM. THIS FORM ASKS FOR THE DATE THIS HAPPENED BELOW, I'LL ADD TODAYS DATE, BUT IT HAS BEEN GOING ON FOR OVER A YEAR.
NHTSA ODI #11064761
196,000 miles · Dec 23, 2017
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
MY SLIP INDICATOR LIGHT COMES ON AS I ROUND TURNS AND THE ENGINE SEEMS TO RPM DOWN. THIS HAPPENS AT NORMAL SPEEDS, ON DRY ROADS. UNABLE TO DRIVE ON THE HIGHWAY, BECAUSE WHEN SLIP INDICATOR LIGHT COMES ON, IT ALSO APPLIES THE FRONT BRAKES AT HIGHWAY SPEEDS. OTHER OWNERS OF TOYOTA SIENNA ARE ALSO HAVING THE SAME PROBLEM. HTTP…
Read full complaint
MY SLIP INDICATOR LIGHT COMES ON AS I ROUND TURNS AND THE ENGINE SEEMS TO RPM DOWN. THIS HAPPENS AT NORMAL SPEEDS, ON DRY ROADS. UNABLE TO DRIVE ON THE HIGHWAY, BECAUSE WHEN SLIP INDICATOR LIGHT COMES ON, IT ALSO APPLIES THE FRONT BRAKES AT HIGHWAY SPEEDS. OTHER OWNERS OF TOYOTA SIENNA ARE ALSO HAVING THE SAME PROBLEM. HTTPS://WWW.CARGURUS.COM/CARS/DISCUSSION-C9152_DS656326 HTTPS://WWW.YOUTUBE.COM/WATCH?V=TGMJAFPIFKO HTTPS://WWW.JUSTANSWER.COM/TOYOTA/4RMYW-TOYOTA-SIENNA-2004-SIENNA-WHEN-SLIP-LIGHT-INDICATOR.HTML
NHTSA ODI #11056256
205,000 miles · Dec 12, 2017
Electronic Stability Control (esc)Service BrakesSteering
STABILITY AND/OR TRACTION CONTROLS (YAW ?) SEEMED TO WANT TO BELIEVE THE VEHICLE WAS IN AN UNDERSTEER -- CAUSING THE VEHICLE TO WANT TO BRAKE AUTOMATICALLY, SOUNDING A TRACTION CONTROL ALARM. ON A BONE - DRY ROAD !!!
NHTSA ODI #11054242
102,000 miles · Aug 14, 2017
Service Brakes
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE DRIVING BETWEEN 10-35 MPH, THE BRAKES ACTIVATED INDEPENDENTLY AND THE VEHICLE CONTROL SYSTEM ALARM SOUNDED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (TOYOTA OF HUNTINGTON BEACH LOCATED AT 18881 BEACH BLVD HUNTINGTON BEACH, CA 92648, 855-661-4272), BUT WAS NOT DIAGNOSED OR REPAIRED.…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE DRIVING BETWEEN 10-35 MPH, THE BRAKES ACTIVATED INDEPENDENTLY AND THE VEHICLE CONTROL SYSTEM ALARM SOUNDED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (TOYOTA OF HUNTINGTON BEACH LOCATED AT 18881 BEACH BLVD HUNTINGTON BEACH, CA 92648, 855-661-4272), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OPENED CASE NUMBER: 1708143994. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 102,000.
NHTSA ODI #11015253
105,000 miles · Nov 11, 2015
Service BrakesVehicle Speed Control
THIS AFTERNOON I ENTERED THE HIGHWAY AND WAS GOING ABOUT 60-65 MPH WHEN MY CAR SUDDENLY STARTED ACCELERATING ON ITS OWN, I REPEATEDLY DEPRESSED THE BRAKE, EVEN STANDING ON IT IN AN ATTEMPT TO SLOW THE CAR. THE CAR WAS MAKING A REVVING SOUND AND THE BRAKES WERE DOING NOTHING TO SLOW THE CAR, IT JUST KEPT ACCELERATING. FINALLY, …
Read full complaint
THIS AFTERNOON I ENTERED THE HIGHWAY AND WAS GOING ABOUT 60-65 MPH WHEN MY CAR SUDDENLY STARTED ACCELERATING ON ITS OWN, I REPEATEDLY DEPRESSED THE BRAKE, EVEN STANDING ON IT IN AN ATTEMPT TO SLOW THE CAR. THE CAR WAS MAKING A REVVING SOUND AND THE BRAKES WERE DOING NOTHING TO SLOW THE CAR, IT JUST KEPT ACCELERATING. FINALLY, THE BRAKES SEEMED TO ENGAGE, THE REVVING STOPPED, AND THE CAR SEEMED NORMAL AGAIN. I PULLED OFF THE HIGHWAY AND CALLED AAA TO HAVE THE CAR TOWED TO MECHANIC. CAR HAS ABOUT 105,000 MILES ON IT AND IT'S BEEN VERY RELIABLE UP UNTIL NOW. I WILL REPORT TO TOYOTA AND I WILL NOT DRIVE THIS CAR AGAIN, MUCH LESS LET MY CHILDREN RIDE IN IT.
NHTSA ODI #10789865
128,000 miles · Oct 26, 2015
Electronic Stability Control (esc)Service Brakes
THE CAR'S VEHICLE STABILITY CONTROL (VSC) WILL ACTIVATE UNEXPECTEDLY, BRAKING HARD AND CAUSING TEMPORARY LOSS OF CONTROL. THERE IS ALSO AN AUDIBLE ALARM AND THE VSC LIGHT TURNS ON. OCCURS INTERMITTENTLY WHEN DRIVING BETWEEN 30-50 MPH, TYPICALLY ON A GENTLE CURVE LIKE A FREEWAY INTERCHANGE. HAS OCCURRED AS MANY AS 9 TIMES ON A SI…
Read full complaint
THE CAR'S VEHICLE STABILITY CONTROL (VSC) WILL ACTIVATE UNEXPECTEDLY, BRAKING HARD AND CAUSING TEMPORARY LOSS OF CONTROL. THERE IS ALSO AN AUDIBLE ALARM AND THE VSC LIGHT TURNS ON. OCCURS INTERMITTENTLY WHEN DRIVING BETWEEN 30-50 MPH, TYPICALLY ON A GENTLE CURVE LIKE A FREEWAY INTERCHANGE. HAS OCCURRED AS MANY AS 9 TIMES ON A SINGLE DRIVE, AND HAS CAUSED A COUPLE NEAR ACCIDENTS. AN INTERNET SEARCH OF ONLINE FORUMS SHOWS THAT THIS ISSUE IS COMMON IN SIENNAS AFTER 100,000 MILES. THUS FAR MY TOYOTA DEALER HAS CLAIMED THEY ARE UNABLE TO REPRODUCE THE PROBLEM.
NHTSA ODI #10786007
Official recalls
11Oct 18, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.
Consequence & remedy
Consequence: If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Consequence & remedy
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 25, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.
Consequence & remedy
Consequence: THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Remedy: TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 3, 2008
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.
Consequence & remedy
Consequence: IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.
Remedy: DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA08024 · Steering Intermediate Shaft Binding
Opened Oct 28, 2008 · Closed Jul 16, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Additional source detail variants (3)
Steering:column
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
EA06020 · Unexpected Closing Of Power Liftgate
Opened Dec 1, 2006 · Closed Jun 25, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hatchback/liftgate:lock; Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:hinge And Attachments; Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Additional source detail variants (4)
Latches/locks/linkages:hatchback/liftgate:lock
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:hinge And Attachments
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Illustration