NHTSA owner reports · September 18, 2026 snapshot.
Seat Belts complaints
38 reportsClear category filter98,082 miles · Jul 21, 2013
Seat Belts
THE DRIVER-SIDE SEATBELT GOT STUCK AFTER BEING FULLY RETRACTED. AT THE TOP OF THE BELT, WHERE IT RETRACTS, THERE WAS A FOLD IN THE BELT AND IT GOT WEDGED INTO THE CURVE OF THE U-SHAPED HOUSING OF THE BELT. *TR I HAVE TRIED PULLING ON IT, MOVING THE ADJUSTABLE TRACK, USING PLIERS AND SCREWDRIVERS TO GET THE BELT TO UN-CINCH. …
Read full complaint
THE DRIVER-SIDE SEATBELT GOT STUCK AFTER BEING FULLY RETRACTED. AT THE TOP OF THE BELT, WHERE IT RETRACTS, THERE WAS A FOLD IN THE BELT AND IT GOT WEDGED INTO THE CURVE OF THE U-SHAPED HOUSING OF THE BELT. *TR I HAVE TRIED PULLING ON IT, MOVING THE ADJUSTABLE TRACK, USING PLIERS AND SCREWDRIVERS TO GET THE BELT TO UN-CINCH. I STILL HAVE NOT BEEN ABLE TO GET IT LOOSE. *TR
NHTSA ODI #10526002
120,000 miles · May 6, 2013
Seat Belts
FRONT DRIVER SEAT BELT JAMS AND WON'T RETRACT. HAPPENS OFTEN. SOMETIMES IT CANNOT BE FREED AND YOU MUST DRIVE HOME WITHOUT A SEAT BELT OR LEAVE THE CAR. *TR
NHTSA ODI #10510757
Mileage unknown · Sep 24, 2012
Air BagsElectrical SystemSeat Belts
2006 TOYOTA SIENNA. CONSUMER WRITES IN REGARDS TO REPAIR COST CONCERNING AIR BAG AND SEAT BELT ISSUES *TGW THE CONSUMER STATED THE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR AN INSPECTION. THE SERVICE ADVISOR, INFORMED THE CONSUMER IT WOULD COST $ 3,985 TO REPAIR THE AIR BAG ISSUE, BUT STATED IT WAS A SE…
Read full complaint
2006 TOYOTA SIENNA. CONSUMER WRITES IN REGARDS TO REPAIR COST CONCERNING AIR BAG AND SEAT BELT ISSUES *TGW THE CONSUMER STATED THE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR AN INSPECTION. THE SERVICE ADVISOR, INFORMED THE CONSUMER IT WOULD COST $ 3,985 TO REPAIR THE AIR BAG ISSUE, BUT STATED IT WAS A SEAT BELT ISSUE THAT REQUIRED A FLOOR WIRING HARNESS WHICH NEEDED TO BE REPLACED.
NHTSA ODI #10477682
38,000 miles · Aug 15, 2012
Seat Belts
PASSENGER SEAT BELTS ON THE RIGHT SIDE IN MIDDLE AND REAR ROW TIGHTEN, OR RETRACT, WHEN PASSENGER SITS BACK. THEN THEY DO NOT RELEASE WHEN THE PASSENGER LEANS FORWARD. THIS MEANS THAT THE SEAT BELT GETS TIGHTER AND TIGHTER UNTIL IT IS VERY UNCOMFORTABLE. OUR KIDS COMPLAINED ABOUT THE SEAT BELTS BEING TOO TIGHT BUT THEY SEEMED…
Read full complaint
PASSENGER SEAT BELTS ON THE RIGHT SIDE IN MIDDLE AND REAR ROW TIGHTEN, OR RETRACT, WHEN PASSENGER SITS BACK. THEN THEY DO NOT RELEASE WHEN THE PASSENGER LEANS FORWARD. THIS MEANS THAT THE SEAT BELT GETS TIGHTER AND TIGHTER UNTIL IT IS VERY UNCOMFORTABLE. OUR KIDS COMPLAINED ABOUT THE SEAT BELTS BEING TOO TIGHT BUT THEY SEEMED TO BE WORKING PROPERLY WHEN I CHECKED THEM. IT SEEMS TO BE AN INTERMITTENT PROBLEM. WHEN I FINALLY EXPERIENCED THIS MYSELF, WE WERE JUST OUT OF THE WARRANTY PERIOD. QUOTE WAS $500 TO REPAIR EACH ONE. *TR
NHTSA ODI #10470794
75,000 miles · Jul 13, 2012
Seat Belts
ONE DAY I FOUND THAT THE SEATBELT HAD TORN IN HALF IN THE REAR FOLDING SEAT. I SUSPECT THAT A COUPLE OF WEEKS EARLIER IT HAD GOTTEN CAUGHT IN THE MECHANICS OF THE FOLDING SEAT. THE FOLDING SEAT HAD GOTTEN STUCK FOR SOME REASON AND NEEDED A LOT OF FORCE TO OPEN IT BACK UP. MAYBE IT GOT A SMALL TEAR THEN WHICH GREW. I DON'T KNOW. …
Read full complaint
ONE DAY I FOUND THAT THE SEATBELT HAD TORN IN HALF IN THE REAR FOLDING SEAT. I SUSPECT THAT A COUPLE OF WEEKS EARLIER IT HAD GOTTEN CAUGHT IN THE MECHANICS OF THE FOLDING SEAT. THE FOLDING SEAT HAD GOTTEN STUCK FOR SOME REASON AND NEEDED A LOT OF FORCE TO OPEN IT BACK UP. MAYBE IT GOT A SMALL TEAR THEN WHICH GREW. I DON'T KNOW. REGARDLESS, ONE DAY I FOUND IT COMPLETELY TORN IN TWO AND UNUSABLE IN THE REAR DRIVERS SIDE. *TR
NHTSA ODI #10465494
Mileage unknown · Aug 8, 2011
Seat Belts
DRIVER'S SIDE FRONT SEAT BELT BECOMES FOLDED AND ENTRAPPED IN THE SLOT WHERE IT COMES OUT OF SIDE COLUMN AND WILL NOT RETRACT, MAKING IT ABSOLUTELY USELESS FOR ITS INTENDED PURPOSE. THIS RESULT IN DRIVER NOT BEING RESTRAINED PROPERLY. HAVE TAKEN IT BACK TO DEALER AT LEAST 3 TIMES TO HAVE THEM RELEASE THE ENTRAPMENT AS WELL AS FI…
Read full complaint
DRIVER'S SIDE FRONT SEAT BELT BECOMES FOLDED AND ENTRAPPED IN THE SLOT WHERE IT COMES OUT OF SIDE COLUMN AND WILL NOT RETRACT, MAKING IT ABSOLUTELY USELESS FOR ITS INTENDED PURPOSE. THIS RESULT IN DRIVER NOT BEING RESTRAINED PROPERLY. HAVE TAKEN IT BACK TO DEALER AT LEAST 3 TIMES TO HAVE THEM RELEASE THE ENTRAPMENT AS WELL AS FIXING IT MYSELF NUMEROUS TIMES. MY WIFE CANNOT DO THE REPAIR HERSELF SO SHE IS OFTEN DRIVING AROUND BASICALLY WITH NO SEAT BELT UNTIL SHE GET TO THE DEALER OR HOME FOR IT TO BE REPAIRED. *TR
NHTSA ODI #10417933
Mileage unknown · Aug 8, 2011
Seat Belts
PROBLEM IS WITH THE REAR SEAT BELTS IN MY 2006 TOYOTA SIENNA LE VAN. ANYTIME SOMEONE (MYSELF INCLUDED) RIDES IN THE BACK ROW, THE SEAT BELTS LOCK UP AND BECOME SO UNCOMFORTABLE THAT THEY MUST BE RELEASED TO AVOID EXTREME DISCOMFORT, THIS RESULTS IN THE SEAT BELT BEING UNFASTENED DURING VEHICLE MOVEMENT AND OFTEN I FIND MY PASSEN…
Read full complaint
PROBLEM IS WITH THE REAR SEAT BELTS IN MY 2006 TOYOTA SIENNA LE VAN. ANYTIME SOMEONE (MYSELF INCLUDED) RIDES IN THE BACK ROW, THE SEAT BELTS LOCK UP AND BECOME SO UNCOMFORTABLE THAT THEY MUST BE RELEASED TO AVOID EXTREME DISCOMFORT, THIS RESULTS IN THE SEAT BELT BEING UNFASTENED DURING VEHICLE MOVEMENT AND OFTEN I FIND MY PASSENGERS JUST NOT USING THEM DUE TO THIS SELF-TIGHTENING. *TR
NHTSA ODI #10417926
Mileage unknown · Feb 3, 2011
Child SeatSeat Belts
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA WITH A 2010 GRACO BOOSTER SEAT, MODEL NUMBER PD144968A. THE CONTACT STATED THAT THE SEAT BELT WOULD NOT HOLD THE CHILD IN PLACE WHILE IN THE BOOSTER. THE CHILD HAD THE ABILITY TO MOVE FREELY IN THE SEAT FROM ONE SIDE TO ANOTHER AND WAS ALSO ABLE TO UNCLIP THE SEAT BELT. THE BOOSTER SEAT …
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA WITH A 2010 GRACO BOOSTER SEAT, MODEL NUMBER PD144968A. THE CONTACT STATED THAT THE SEAT BELT WOULD NOT HOLD THE CHILD IN PLACE WHILE IN THE BOOSTER. THE CHILD HAD THE ABILITY TO MOVE FREELY IN THE SEAT FROM ONE SIDE TO ANOTHER AND WAS ALSO ABLE TO UNCLIP THE SEAT BELT. THE BOOSTER SEAT MANUFACTURER WAS CONTACTED AND ASKED IF THERE WAS A CLIP THAT COULD BE INSTALLED FOR THE VEHICLE SEAT BELT TO HAVE A TIGHTER FIT. THE MANUFACTURER OF THE VEHICLE ADVISED THAT THEY DID NOT HAVE A CLIP OR ANY SUGGESTIONS TO REMEDY THE SITUATION. THE FAILURE AND CURRENT MILEAGE WAS UNKNOWN. UPDATED 3/14/11 *CN UPDATED 04/22/11
NHTSA ODI #10380105
76,000 miles · Oct 27, 2010
Seat Belts
TOYOTA SIENNA 2006 1. NORMAL DRIVING WITH ABSOLUTELY NO ACCIDENTS IN THE HISTORY OF THE VEHICLE. 2. DRIVER'S SIDE FRONT SEAT BELT WILL NOT RETRACT, MAKING IS ABSOLUTELY USELESS FOR ITS INTENDED PURPOSE. THIS IS A MAJOR SAFETY ISSUE. 3. CONTACTED TOYOTA HEADQUARTERS WHO CLAIMS THAT THE VEHICLE IS OUTSIDE THE NORMAL 3 YEAR WAR…
Read full complaint
TOYOTA SIENNA 2006 1. NORMAL DRIVING WITH ABSOLUTELY NO ACCIDENTS IN THE HISTORY OF THE VEHICLE. 2. DRIVER'S SIDE FRONT SEAT BELT WILL NOT RETRACT, MAKING IS ABSOLUTELY USELESS FOR ITS INTENDED PURPOSE. THIS IS A MAJOR SAFETY ISSUE. 3. CONTACTED TOYOTA HEADQUARTERS WHO CLAIMS THAT THE VEHICLE IS OUTSIDE THE NORMAL 3 YEAR WARRANTY PERIOD. *TR
NHTSA ODI #10362597
1,000 miles · Aug 8, 2010
Seat Belts
PROBLEM IS WITH THE SECOND ROW SEAT BELTS IN MY 2006 TOYOTA SIENNA XLE VAN. ANYTIME SOMEONE (MYSELF INCLUDED) RIDES IN THE SECOND ROW, THE SEAT BELTS LOCK UP AND BECOME SO UNCOMFORTABLE AS THEY CONTINUE TO TIGHTEN THAT WE JUST END UP NOT USING THEM SOON AFTER THE TRIP BEGINS. NOT USING THEM BECAUSE OF THIS DEFECT POSES A REAL …
Read full complaint
PROBLEM IS WITH THE SECOND ROW SEAT BELTS IN MY 2006 TOYOTA SIENNA XLE VAN. ANYTIME SOMEONE (MYSELF INCLUDED) RIDES IN THE SECOND ROW, THE SEAT BELTS LOCK UP AND BECOME SO UNCOMFORTABLE AS THEY CONTINUE TO TIGHTEN THAT WE JUST END UP NOT USING THEM SOON AFTER THE TRIP BEGINS. NOT USING THEM BECAUSE OF THIS DEFECT POSES A REAL SAFETY HAZARD IF WE WERE TO HAVE AN ACCIDENT. EARLIER ON I COMPLAINED SEVERAL TIMES. I WAS ALWAYS TOLD THERE IS NOTHING WRONG WITH THEM. WE PROBABLY WEREN'T USING THEM CORRECTLY AND I WAS EVEN GIVEN INSTRUCTION BY THE SERVICE DEPARTMENT ON HOW TO HOOK UP THE SEAT BELT. MY COMPLAINTS FELL ON DEAF EARS AND I REALLY DO THINK IT IS A SAFETY HAZARD. I TOLD THEM THEY MIGHT HAVE TO RIDE IT LONGER THAN THE FEW MINUTES THEY DID. I'M NOT SO SURE THIS PROBLEM IS ABOUT MY SIENNA ONLY. WHEN I RIDE IN THE BACK SEAT OF OTHER VEHICLES THE SEAT BELT SEEMS TO TIGHTEN. IF I HAD TO GUESS, I'D SAY THEY DON'T PUT THE SAME QUALITY SEAT BELT IN THE BACK OF A VEHICLE AS THEY DO THE FRONT SEATS JUST BECAUSE THEY WOULD COST MORE. ANYTHING YOU COULD DO TO REMEDY THIS SITUATION WOULD BE GREATLY APPRECIATED. SINCE THIS HAPPENS ANY TIME SOMEONE IS IN THE BACK SEAT, I AM PICKING A RANDOM INCIDENT DATE. *TR
NHTSA ODI #10348044
Official recalls
11Oct 18, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.
Consequence & remedy
Consequence: If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Consequence & remedy
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 25, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.
Consequence & remedy
Consequence: THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Remedy: TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 3, 2008
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.
Consequence & remedy
Consequence: IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.
Remedy: DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA08024 · Steering Intermediate Shaft Binding
Opened Oct 28, 2008 · Closed Jul 16, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Additional source detail variants (3)
Steering:column
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
EA06020 · Unexpected Closing Of Power Liftgate
Opened Dec 1, 2006 · Closed Jun 25, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hatchback/liftgate:lock; Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:hinge And Attachments; Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Additional source detail variants (4)
Latches/locks/linkages:hatchback/liftgate:lock
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:hinge And Attachments
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Illustration