NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
85 reportsClear category filter33,500 miles · Mar 4, 2011
Electrical System
2006 TOYOTA SIENNA LIMITED VAN (34,000 MILES) WITH AUTOMATIC REAR AND SLIDING DOORS. 1 MONTH AGO RIGHT REAR SLIDING DOOR STOPPED OPENING WHEN USING MANUAL DOOR LATCH. IF YOU MANUALLY UNLATCH DOOR, YOU MUST MANUALLY OPEN IT ABOUT ONE THIRD BEFORE MOTOR KICKS IN TO OPEN IT FULLY. WORKS OK USING OVERHEAD CONSOLE BUTTON AND WHEN USI…
Read full complaint
2006 TOYOTA SIENNA LIMITED VAN (34,000 MILES) WITH AUTOMATIC REAR AND SLIDING DOORS. 1 MONTH AGO RIGHT REAR SLIDING DOOR STOPPED OPENING WHEN USING MANUAL DOOR LATCH. IF YOU MANUALLY UNLATCH DOOR, YOU MUST MANUALLY OPEN IT ABOUT ONE THIRD BEFORE MOTOR KICKS IN TO OPEN IT FULLY. WORKS OK USING OVERHEAD CONSOLE BUTTON AND WHEN USING FOB BUTTONS. TOOK VAN TO TOYOTA DEALER ON 2/28/11. THEY COULD NOT DUPLICATE PROBLEM. WENT TO PICK VAN UP ON 3/1/11. SLIDING DOOR AGAIN NOT WORKING. THEY KEPT VAN SEVERAL MORE HOURS FOR TROUBLESHOOTING. PROBLEM REMAINS. THEY SAID THERE IS NO FIX FOR THIS PROBLEM BUT THEY DID SEND IN A TECHNICAL REPORT TO TOYOTA. AFTER CHECKING OUT AND FINALLY GETTING READY TO LEAVE DEALER THE VAN WOULD NOT START. THE BATTERY HAD DIED. DEALER REPLACED BATTERY. AFTER THAT AND FOR 2 MORE DAYS, THE SLIDING DOOR WORKED OK. ON MORNING OF THIRD DAY, THE SLIDING DOOR PROBLEM RETURNED. STILL WILL NOT OPEN AUTOMATICALLY USING MANUAL DOOR LATCH. *TR
NHTSA ODI #10386482
78,500 miles · Jan 4, 2011
Electrical System
LATCHES/LOCKS/LINKAGES SLIDING ELECTRIC SIDE DOOR JAMMED. THE DOOR WILL NOT SHUT OR OPEN. IT IS BASICALLY JAMMED AND I HAVE TO PUT ALL OF MY WEIGHT INTO THE DOOR TO GET IT TO LATCH SHUT. BASED ON ONLINE COMPLAINTS, IT IS NOT COVERED UNDER WARRANTY AND WILL COST ABOUT $1500 TO FIX
NHTSA ODI #10375630
72,000 miles · Oct 24, 2010
Electrical SystemPower Train
TOYOTA SIENNA LE 2006 WITH 72,000 MILES AUTOMATIC BROKE DOWN ON THE HIGHWAY --- REFUSING TO GO BEYOND 35MILES AN HOUR AND CHECK ENGINE LIGHT CAME ON. THE TOYOTA DEALER CLAIMED THAT THE TRANSMISSION HAD TO BE REPLACED AT A COST OF ABOUT 5500 + AND DIAGNOSED ONLY TRANSMISSION PROBLEM. TO GET A SECOND OPINION, WE GOT THE VEHICLE TO…
Read full complaint
TOYOTA SIENNA LE 2006 WITH 72,000 MILES AUTOMATIC BROKE DOWN ON THE HIGHWAY --- REFUSING TO GO BEYOND 35MILES AN HOUR AND CHECK ENGINE LIGHT CAME ON. THE TOYOTA DEALER CLAIMED THAT THE TRANSMISSION HAD TO BE REPLACED AT A COST OF ABOUT 5500 + AND DIAGNOSED ONLY TRANSMISSION PROBLEM. TO GET A SECOND OPINION, WE GOT THE VEHICLE TOWED TO AAMCO, THE TRANSMISSION EXPERTS. AAMCO REPLACED VALVE BODY, TORQUE CONVERTER, AND THEIR STANDARD BANNER KIT + TRANSMISSION COOLING SYSTEM FLUSH AND CLEAN. AAMCO ASKED US TO BE SOFT ON THE TRANSMISSION FOR A TANK OF GAS. INSPITE OF DRIVING SLOWLY, WE NOTICED THAT THE TRANSMISSION CHANGE FROM ABOUT 1ST TO 2ND GEAR WAS VERY SLOW AND THE CAR HAD LIKE A HICCUP WHEN TRYING TO ACCELERATE AND EXHIBITED VIBRATION AT HIGHER SPEEDS. WHEN WE TOOK IT BACK TO AAMCO, THEY TEST DROVE THE SAME AND NOW CLAIM THE COMPUTER (ECM?) IS NOT LEARNING THE GEAR SHIFT AND NEEDS TO BE REPLACED. TOYOTA DEALER CLAIMS THAT THE 8YR/80000MILE WARRANTY ON THE COMPUTER IS ONLY FOR A MANUFACTURING DEFECT AND REFUSES TO ACKNOWLEDGE THAT THE COMPUTER IS MISBEHAVING. THERE IS NO CHECK ENGINE LIGHT OR ERROR CODE, BUT THE VEHICLE REMAINS SLUGGISH. WE ARE WAITING FOR THE PRICING OF THE ECM MODULE AND WOULD SINCERELY APPRECIATE IF THE PROBLEM IS ACKNOWLEDGED AND RESOLVED BY TOYOTA. GONE ARE THE DAYS WHEN TOYOTA WAS A RELIABLE CAR --- WE ARE FRUSTRATED WITH THE WHOLE EPISODE AND UNFORTUNATELY ARE NOT CONFIDENT OF WHAT ELSE NEEDS TO GET REPLACED TO GET THE CAR UP AND RUNNING. *TR
NHTSA ODI #10362120
92,000 miles · Oct 22, 2010
Electrical System
1. THE PASSENGER-SIDE, SLIDING DOOR ON MY '04 XLE, 93,000 MI MINIVAN JUST FAILED 2. DOORS ARE KEY TO SAFETY AND SECURITY! ITS HAPPENING MORE OFTEN AND I'M AFRAID TO CARRY MY CHILD IN THE CAR FOR THE CASE OF EMERGENCY. 3. I COULD NOT AFFORD TO PAY $2200 REPAIR COST OF THE DOOR. IT IS SAME PROBLEM WITH EVERYONE ELSE THAT …
Read full complaint
1. THE PASSENGER-SIDE, SLIDING DOOR ON MY '04 XLE, 93,000 MI MINIVAN JUST FAILED 2. DOORS ARE KEY TO SAFETY AND SECURITY! ITS HAPPENING MORE OFTEN AND I'M AFRAID TO CARRY MY CHILD IN THE CAR FOR THE CASE OF EMERGENCY. 3. I COULD NOT AFFORD TO PAY $2200 REPAIR COST OF THE DOOR. IT IS SAME PROBLEM WITH EVERYONE ELSE THAT I HAVE CAME ACROSS WITH! "THE CABLE" AND ITS NOT COVERED BY THE EXTENDED WARRANTY SINCE THEY KNEW IT WAS GOING TO HAPPEN. THE EXACT PARTS THAT WERE IN THE NEEDS WERE LISTED NOT TO BE COVERED. THIS IS OBVIOUS REASONS THAT IS BEEN RECOGNIZED FROM THE TOYOTA COMPANY. I HAVE CHECK AND MOST OF THE SIENNA OWNERS ARE SUFFERING FROM THE EXACT PROBLEM. THIS GOT TO STOP! *TR
NHTSA ODI #10361682
64,000 miles · Oct 4, 2010
Electrical SystemStructure
THE REAR HATCH ON MY 2006 TOYOTA SIENNA XLE HAD THE STRUTS REPLACED UNDER RECALL. NOW, THE POWER HATCH WILL OCCASIONALLY FAIL TO CLOSE. I HAVE STARTED DRIVING THE VAN ON ONE OR TWO OCCASIONS WITHOUT REALIZING THAT THE REAR HATCH WAS STILL OPEN BECAUSE IT HAD FAILED TO CLOSE. LUCKILY, NOTHING FELL OUT OF THE BACK OF THE VAN, B…
Read full complaint
THE REAR HATCH ON MY 2006 TOYOTA SIENNA XLE HAD THE STRUTS REPLACED UNDER RECALL. NOW, THE POWER HATCH WILL OCCASIONALLY FAIL TO CLOSE. I HAVE STARTED DRIVING THE VAN ON ONE OR TWO OCCASIONS WITHOUT REALIZING THAT THE REAR HATCH WAS STILL OPEN BECAUSE IT HAD FAILED TO CLOSE. LUCKILY, NOTHING FELL OUT OF THE BACK OF THE VAN, BUT I THINK IT IS A REAL DANGER. I BROUGHT IT UP WITH TOYOTA, AND THEY TOLD ME IT WOULD COST $1500 TO FIX. THE PROBLEM DID NOT START UNTIL THE RECALLED LIFT SUPPORTS WERE PUT IN SO I DON'T THINK I SHOULD BE RESPONSIBLE FOR THESE INCOMPATIBLE PARTS. I DID AN ONLINE SEARCH OF THIS PROBLEM, AND IT IS CLEAR THAT THIS IS A VERY COMMON PROBLEM FOR THOSE OF US WHO HAVE HAD OUR LIFT SUPPORTS CHANGED OUT. *TR
NHTSA ODI #10358993
31,500 miles · Sep 14, 2010
Electrical SystemStructure
BACK HATCH ON TOYOTA SIENNA XLE (2006) WILL NOT CLOSE AUTOMATICALLY (VIA BUTTONS OR FOB) IN WARM WEATHER (I.E. OVER APPROX. 83 DEGREES). MUST BE CLOSED MANUALLY. ONLY HAPPENS WHEN VEHICLE HAS BEEN SITTING IN SUN. HAVE HEARD SAME COMPLAINT FROM NUMEROUS OTHER OWNERS OF SAME MAKE AND MODEL AND LATER MODELS. STARTED OCCURRING SHORT…
Read full complaint
BACK HATCH ON TOYOTA SIENNA XLE (2006) WILL NOT CLOSE AUTOMATICALLY (VIA BUTTONS OR FOB) IN WARM WEATHER (I.E. OVER APPROX. 83 DEGREES). MUST BE CLOSED MANUALLY. ONLY HAPPENS WHEN VEHICLE HAS BEEN SITTING IN SUN. HAVE HEARD SAME COMPLAINT FROM NUMEROUS OTHER OWNERS OF SAME MAKE AND MODEL AND LATER MODELS. STARTED OCCURRING SHORTLY AFTER NEW STRUTS WERE INSTALLED TO ADDRESS RECALL FOR HATCHBACK UNEXPECTEDLY FALLING DOWN WITHOUT WARNING. SEVERAL ENGINEERS HAVE SUGGESTED THE NEW STRUTS ARE TOO STRONG FOR EXISTING HATCHBACK MOTOR (STRONGER STRUT MECHANISM USED TO PREVENT HATCHBACK FROM FALLING). RECOMMEND NEW MOTOR TO MATCH STRENGTH OF RECALL REPLACEMENT STRUTS. *TR
NHTSA ODI #10355452
72,000 miles · Jun 1, 2010
Electrical System
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE DRIVING AT APPROXIMATE SPEEDS OF 40 MPH, THE AUTOMOTIVE SKID CONTROL ACTIVATED WITHOUT WARRANT AND WOULD CAUSE THE VEHICLE TO DRIVE AS IF IN NEUTRAL. WHEN THE FAILURE WOULD OCCUR, ALL WARNING LIGHTS WOULD ILLUMINATE ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOS…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE DRIVING AT APPROXIMATE SPEEDS OF 40 MPH, THE AUTOMOTIVE SKID CONTROL ACTIVATED WITHOUT WARRANT AND WOULD CAUSE THE VEHICLE TO DRIVE AS IF IN NEUTRAL. WHEN THE FAILURE WOULD OCCUR, ALL WARNING LIGHTS WOULD ILLUMINATE ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING YET THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 72,000.
NHTSA ODI #10333991
8,085 miles · Mar 18, 2010
Electrical System
2006 TOYOTA SIENNA HAS SEVERAL ELECTRICAL PROBLEMS. I HAVE BEEN TAKING MY CAR TO THE DEALERSHIP OVER SIX TIMES TO REPAIR BUT IT IS THE SAME THING. CHECK ENGINE LIGHT COMES ON AND I LOOSE POWER ON THE FREEWAY AND I PULL OVER AND TURN OFF THE CAR AND RESTART IT AND IT WORKS AGAIN. I HAD FAULTY SLIDING DOOR AND FAULTY AIRBAG. I…
Read full complaint
2006 TOYOTA SIENNA HAS SEVERAL ELECTRICAL PROBLEMS. I HAVE BEEN TAKING MY CAR TO THE DEALERSHIP OVER SIX TIMES TO REPAIR BUT IT IS THE SAME THING. CHECK ENGINE LIGHT COMES ON AND I LOOSE POWER ON THE FREEWAY AND I PULL OVER AND TURN OFF THE CAR AND RESTART IT AND IT WORKS AGAIN. I HAD FAULTY SLIDING DOOR AND FAULTY AIRBAG. I STILL HAVE CHECK ENGINE LIGHT COME ON AND POWER ISSUES THAT TOYOTA THAT WAS COVERED UNDER WARRANTY AND I HAVE EXTENDED WARRANTY BUT NOW THEY DO NOT WANT TO SERVICE MY CAR ANYMORE. THEY SAY I DON'T HAVE WARRANTY ANYMORE. *TR
NHTSA ODI #10320776
78,000 miles · Mar 9, 2010
Electrical System
TOYOTA SIENNA LE 2006 - TANK 3/4 OF THE WAY FULL. 1/2 MILE FROM OUR HOME, EVERY LIGHT CAME ON THE DASH BOARD AND WE WERE UNABLE TO ACCELERATE. THE VAN BEGAN BUCKING - RPM'S WENT FROM1 - 4 AND BACK AGAIN. WE WERE ABLE TO TURN AROUND AND LIMP BACK HOME. LATER THAT DAY, THE VAN OPERATED NORMALLY AND THE PROBLEM HAS NOT OCCU…
Read full complaint
TOYOTA SIENNA LE 2006 - TANK 3/4 OF THE WAY FULL. 1/2 MILE FROM OUR HOME, EVERY LIGHT CAME ON THE DASH BOARD AND WE WERE UNABLE TO ACCELERATE. THE VAN BEGAN BUCKING - RPM'S WENT FROM1 - 4 AND BACK AGAIN. WE WERE ABLE TO TURN AROUND AND LIMP BACK HOME. LATER THAT DAY, THE VAN OPERATED NORMALLY AND THE PROBLEM HAS NOT OCCURRED AGAIN. SINCE WE COULD NOT DUPLICATE IT, WE DID NOT TAKE IT TO THE DEALER. *TR
NHTSA ODI #10318130
10 miles · Mar 9, 2010
Electrical SystemPower TrainStructure
TL*THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE DRIVER STATED THAT WHILE DRIVING 10 MPH IN AN ATTEMPT TO INCREASE SPEED, THE VEHICLE BEGAN TO HESITATE AND SURGE. THE DEALER STATED THAT THERE WAS NOTHING THEY COULD DO TO ASSIST HIM SINCE THE FAILURE WAS ELECTRICAL WHICH WAS ALSO A NORMAL FUNCTION OF THE VEHICLE. THE FAILURE MILEAG…
Read full complaint
TL*THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE DRIVER STATED THAT WHILE DRIVING 10 MPH IN AN ATTEMPT TO INCREASE SPEED, THE VEHICLE BEGAN TO HESITATE AND SURGE. THE DEALER STATED THAT THERE WAS NOTHING THEY COULD DO TO ASSIST HIM SINCE THE FAILURE WAS ELECTRICAL WHICH WAS ALSO A NORMAL FUNCTION OF THE VEHICLE. THE FAILURE MILEAGE WAS 10 AND THE CURRENT MILEAGE WAS 75,000. THE CONSUMER STATED WHEN SLOWING DOWN BETWEEN 5- 10 MPH AND THEN SPEEDING BACK UP AGAIN, THE VAN WOULD HESITATE AND THEN SURGE FORWARD TO THE POINT OF JERKING THE CONSUMERS NECK. THE VEHICLE WOULD SLOW DOWN ONCE THE ACCELERATOR WAS RELEASED. ALSO, THE DRIVERS SIDE DOOR WAS EXHIBITING A POPPING/SCRAPPING NOISE WHEN IT WAS BEING OPENED OR CLOSED. THE CONSUMER TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THERE WAS A RECALL REGARDING THE THINNESS OF METAL WHICH ALLOWED THE CRACKING OF THE METAL WHERE THE DOOR STOP WAS ATTACHED TO THE DOOR. UPDATED 04/21/10
NHTSA ODI #10317971
Official recalls
11Oct 18, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.
Consequence & remedy
Consequence: If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Consequence & remedy
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 25, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.
Consequence & remedy
Consequence: THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Remedy: TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 3, 2008
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.
Consequence & remedy
Consequence: IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.
Remedy: DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA08024 · Steering Intermediate Shaft Binding
Opened Oct 28, 2008 · Closed Jul 16, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Additional source detail variants (3)
Steering:column
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
EA06020 · Unexpected Closing Of Power Liftgate
Opened Dec 1, 2006 · Closed Jun 25, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hatchback/liftgate:lock; Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:hinge And Attachments; Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Additional source detail variants (4)
Latches/locks/linkages:hatchback/liftgate:lock
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:hinge And Attachments
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Illustration