NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
307 reportsClear category filter62,000 miles · Oct 22, 2010
Air Bags
MY AIRBAG LIGHT BEGAN BLINKING ON SUNDAY, 10/17/10. MY VEHICLE IS A 2006 TOYOTA SIENNA. I TOOK IT TO A LOCAL MECHANIC ON 10/20/10 AND WAS TOLD THE CENTER SQUIB NEEDED REPLACED ...UPON REPLACING ON 10/22, WAS TOLD THAT ANOTHER ERROR CODE WAS DISPLAYED INDICATING AIRBAG REPLACEMENT NEEDED BY A TOYOTA DEALER. MY CAR HAS JUST WENT O…
Read full complaint
MY AIRBAG LIGHT BEGAN BLINKING ON SUNDAY, 10/17/10. MY VEHICLE IS A 2006 TOYOTA SIENNA. I TOOK IT TO A LOCAL MECHANIC ON 10/20/10 AND WAS TOLD THE CENTER SQUIB NEEDED REPLACED ...UPON REPLACING ON 10/22, WAS TOLD THAT ANOTHER ERROR CODE WAS DISPLAYED INDICATING AIRBAG REPLACEMENT NEEDED BY A TOYOTA DEALER. MY CAR HAS JUST WENT OVER THE WARRANTY PERIOD AT 62,000 MILES. I AM UNHAPPY THAT NOT EVEN 4 YEARS AFTER BUYING THIS VEHICLE IN DECEMBER 06, I AM FACED WITH REPAIR COSTS THAT ARE LARGE FOR A MAJOR SAFETY PROBLEM THAT HAS BEEN RECURRING FROM WHAT I HAVE READ ONLINE WITH OTHERS DRIVING AN 06 SIENNA. AND AS A MOTHER OF 3, I AM UNABLE TO USE MY VEHICLE SAFELY UNTIL THIS PROBLEM IS FIXED. I SEE A SERVICE BULLETIN FOR THIS BUT NO RECALL..WHICH IT SEEMS THERE SHOULD BE FOR SUCH A MAJOR SAFETY PROBLEM. *TR
NHTSA ODI #10361756
105,450 miles · Oct 21, 2010
Air Bags
THE AIRBAG LIGHT ON MY 2006 TOYOTA SIENNA WENT OFF. WHEN THE VAN WAS LESS THAN 6,000 MILES OVER MY WARRANTY. THE DEALER SAYS THERE IS A SHORT IN THE WIRING HARNESS OF THE AIRBAG UNDER THE DRIVER'S SEAT. THIS DISARMS ALL THE AIRBAGS. I HAVE BEEN WAITING 5 WEEKS FOR THE REPLACEMENT PART. THE REPAIR COSTS $3200.00, BUT THE DEAL…
Read full complaint
THE AIRBAG LIGHT ON MY 2006 TOYOTA SIENNA WENT OFF. WHEN THE VAN WAS LESS THAN 6,000 MILES OVER MY WARRANTY. THE DEALER SAYS THERE IS A SHORT IN THE WIRING HARNESS OF THE AIRBAG UNDER THE DRIVER'S SEAT. THIS DISARMS ALL THE AIRBAGS. I HAVE BEEN WAITING 5 WEEKS FOR THE REPLACEMENT PART. THE REPAIR COSTS $3200.00, BUT THE DEALER DISCOUNTED IT TO $1,900.00. THEY SAY THE WAIT IS BECAUSE THERE IS SUCH A DEMAND FOR THE WIRING HARNESS! MANY DRIVERS ARE DRIVING WITHOUT THEIR AIRBAGS! THIS SEEMS TO ME SHOULD BE A RECALL, AS IT IS A SAFETY ISSUE AND AN UNDUE EXPENSE TO OWNERS. *TR
NHTSA ODI #10361553
76,000 miles · Sep 21, 2010
Air Bags
THE SRS INDICATOR LIGHT BEGAN FLASHING ON MY 2006 TOYOTA SIENNA ON 09/20/10. THE OWNER'S MANUAL STATES IF THIS OCCURS, TO TAKE THE VEHICLE TO THE DEALERSHIP IMMEDIATELY. I WAS RECENTLY ADVISED BY COBB COUNTY TOYOTA THAT MY AIRBAG IS DEFECTIVE AND NEEDS TO BE REPLACED FOR $2400. SINCE MY 2006 SIENNA HAS 76K MILES ON IT, TOYOTA…
Read full complaint
THE SRS INDICATOR LIGHT BEGAN FLASHING ON MY 2006 TOYOTA SIENNA ON 09/20/10. THE OWNER'S MANUAL STATES IF THIS OCCURS, TO TAKE THE VEHICLE TO THE DEALERSHIP IMMEDIATELY. I WAS RECENTLY ADVISED BY COBB COUNTY TOYOTA THAT MY AIRBAG IS DEFECTIVE AND NEEDS TO BE REPLACED FOR $2400. SINCE MY 2006 SIENNA HAS 76K MILES ON IT, TOYOTA WOULDN'T COVER IT UNDER THE WARRANTY. I ASKED HOW AN UNUSED AIRBAG COULD BE DEFECTIVE, I WAS TOLD THAT IT IS AN ELECTRICAL COMPONENT. THAT WAS THE COMPLETE ANSWER. SO, I CHECKED ONLINE. AND, SURE ENOUGH, HUNDREDS OF PEOPLE ALL OVER THE COUNTRY ARE FACING THE SAME PROBLEM WITH THEIR 2006 SIENNA. AND, NO ONE HAS BEEN ABLE TO EXPLAIN THE REASON. I CALLED THE TOYOTA CORPORATE OFFICE AND THE (NO) CUSTOMER SERVICE REP SAID THAT ALL SHE COULD DO WAS DOCUMENT MY CONCERN. NO MANAGER COULD CALL OR ASSIST ME. NO ONE COULD SEND ME A LETTER STATING WHY AN UNUSED AIRBAG IS SUDDENLY DEFECTIVE AFTER ONLY 4 YEARS. *TR
NHTSA ODI #10356751
85,062 miles · Sep 15, 2010
Air Bags
I HAVE A 2006 TOYOTA SIENNA THAT HAS AN AIRBAG LIGHT THAT COMES ON. THIS VEHICLE HAS 85, 062 MILES AND WHEELER TOYOTA IN GRANTS PASS, OR SAID THAT A TECH BULLETIN # 0162-10 REQUIRES TO REPLACE RIGHT SIDE FOLD FLAT AIR BAG ASSY. AND REPLACE RIGHT SIDE FLOOR WIRE HARNESS ASSY. APPROX. $2238.36 FOR REPAIRS. THEY STATED THAT THE…
Read full complaint
I HAVE A 2006 TOYOTA SIENNA THAT HAS AN AIRBAG LIGHT THAT COMES ON. THIS VEHICLE HAS 85, 062 MILES AND WHEELER TOYOTA IN GRANTS PASS, OR SAID THAT A TECH BULLETIN # 0162-10 REQUIRES TO REPLACE RIGHT SIDE FOLD FLAT AIR BAG ASSY. AND REPLACE RIGHT SIDE FLOOR WIRE HARNESS ASSY. APPROX. $2238.36 FOR REPAIRS. THEY STATED THAT THE WARRANTY EXPIRED AT 60,000 MILES. SHOULDN'T THIS BE COVERED UNDER A RECALL? *TR
NHTSA ODI #10355659
9,000 miles · Sep 1, 2010
Air Bags
TL*THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT BOTH THE DRIVER SIDE AND PASSENGER SIDE AIR BAGS WERE INOPERATIVE AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE C…
Read full complaint
TL*THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT BOTH THE DRIVER SIDE AND PASSENGER SIDE AIR BAGS WERE INOPERATIVE AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THERE WAS NO DOCUMENTATION ON HER EXPERIENCING THE PROBLEM AND HER VEHICLE WAS OUTSIDE THE WARRANTY. THE CURRENT MILEAGE WAS APPROXIMATELY 73,800. THE FAILURE MILEAGE WAS APPROXIMATELY 9,000.
NHTSA ODI #10353277
96,000 miles · Aug 30, 2010
Air Bags
TL*THE CONTACT OWNS 2006 TOYOTA SIENNA. THE FRONT PASSENGER AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DIAGNOSIS LOCATED FAILURE CODE B0111, THE AIR BAG WIRING HARNESS. THE DEALER STATED THAT THE ENTIRE AIR BAG SYSTEM NEEDED TO BE REPLACED. MANUFACTURERS REPORT 1008162109 WAS FILED. THE MANUFACTURER OFF…
Read full complaint
TL*THE CONTACT OWNS 2006 TOYOTA SIENNA. THE FRONT PASSENGER AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DIAGNOSIS LOCATED FAILURE CODE B0111, THE AIR BAG WIRING HARNESS. THE DEALER STATED THAT THE ENTIRE AIR BAG SYSTEM NEEDED TO BE REPLACED. MANUFACTURERS REPORT 1008162109 WAS FILED. THE MANUFACTURER OFFERED TO PAY SOME OF THE REPAIR COST. THE CONTACT FEELS THE MANUFACTURER SHOULD PAY THE ENTIRE REPAIR COST. THE VEHICLE WASN'T REPAIRED. THE VIN INFORMATION WASN'T AVAILABLE. THE FAILURE MILEAGE WAS 90,010 AND THE CURRENT MILEAGE WAS 96,000.
NHTSA ODI #10352836
61,500 miles · Aug 28, 2010
Air Bags
2006 TOYOTA SIENNA VAN AIRBAG LIGHT STAYS ON FULL TIME OR SOMETIMES WHEN CAR IS STARTED THE AIRBAG LIGHT FLASHES ON AND OFF. *TR
NHTSA ODI #10352487
30,000 miles · Aug 25, 2010
Air Bags
AIR BAG LIGHT HAS BEEN ON AND OFF FOR THE ENTIRE TIME I HAVE OWNED MY 2006 TOYOTA SIENNA. IT HAS BEEN TAKEN TO THE DEALER FIVE TIMES AND THEY HAVE FINALLY RECOMMENDED A REPLACEMENT AFTER 90,000 BUT WON'T COVER IT EVEN THOUGH THE INITIAL PROBLEM OCCURRED IN MY VEHICLE AND MANY OTHERS THAT I HAVE READ ABOUT, BEFORE THE INITIAL WA…
Read full complaint
AIR BAG LIGHT HAS BEEN ON AND OFF FOR THE ENTIRE TIME I HAVE OWNED MY 2006 TOYOTA SIENNA. IT HAS BEEN TAKEN TO THE DEALER FIVE TIMES AND THEY HAVE FINALLY RECOMMENDED A REPLACEMENT AFTER 90,000 BUT WON'T COVER IT EVEN THOUGH THE INITIAL PROBLEM OCCURRED IN MY VEHICLE AND MANY OTHERS THAT I HAVE READ ABOUT, BEFORE THE INITIAL WARRANTY PERIOD WAS OVER. *TR
NHTSA ODI #10351694
29,899 miles · Aug 17, 2010
Air Bags
AROUND JUNE OF 2010, AFTER STARTING MY 2006 TOYOTA SIENNA, I NOTICED THE AIRBAG SENSOR LIGHT WAS BLINKING, I TURNED THE VAN OFF AND RESTARTED, THE LIGHT KEPT BLINKING. THIS CONTINUE WHILE DRIVING AND AFTER A FEW DAYS, IT STOPPED. AGAIN IN JULY OF 2010, SAME PROBLEM FOR ALMOST 9 OR 10 DAYS EVERYTIME I DROVE. THEN IT STOPPED.…
Read full complaint
AROUND JUNE OF 2010, AFTER STARTING MY 2006 TOYOTA SIENNA, I NOTICED THE AIRBAG SENSOR LIGHT WAS BLINKING, I TURNED THE VAN OFF AND RESTARTED, THE LIGHT KEPT BLINKING. THIS CONTINUE WHILE DRIVING AND AFTER A FEW DAYS, IT STOPPED. AGAIN IN JULY OF 2010, SAME PROBLEM FOR ALMOST 9 OR 10 DAYS EVERYTIME I DROVE. THEN IT STOPPED. TWO DAYS AGO, AUGUST 15, THE AIRBAG SENSOR LIGHT CAME ON AGAIN AND IS STILL BLINKING EVERYTIME I GET IN AND DRIVE. *TR
NHTSA ODI #10350075
48,000 miles · Jul 17, 2010
Air BagsPower TrainCrash
TOPIC: TOYOTA ACCELERATION PROBLEM: ON JULY 4TH AT 10:00 AM, AS MY 2006 SIENNA TOYOTA WAS EMERGING FROM THE DRYER-END OF WELL KNOWN CARWASH, THE SIGNAL AT THE TERMINAL POINT INDICATED THAT I WAS TO MOVE MY CAR OUT OF THE STRUCTURE. I SHIFTED OUT OF NEUTRAL INTO DRIVE. AT THE INSTANT I PUT THE CAR INTO DRIVE, MY VEHICLE ACCELE…
Read full complaint
TOPIC: TOYOTA ACCELERATION PROBLEM: ON JULY 4TH AT 10:00 AM, AS MY 2006 SIENNA TOYOTA WAS EMERGING FROM THE DRYER-END OF WELL KNOWN CARWASH, THE SIGNAL AT THE TERMINAL POINT INDICATED THAT I WAS TO MOVE MY CAR OUT OF THE STRUCTURE. I SHIFTED OUT OF NEUTRAL INTO DRIVE. AT THE INSTANT I PUT THE CAR INTO DRIVE, MY VEHICLE ACCELERATED OUT OF THE CAR WASH STRUCTURE, MISSING ABOUT 12 VEHICLES AND DRIVERS IN THE PARKED AREA DRYING THEIR CARS. THE POLICE AND WITNESS SAID I REACH 60 MPH WHEN I HIT AN EMBANKMENT, DIRECTLY ACROSS FROM THE EXIT TO THE CARWASH PROPERTY AT THE EXIT POINT, THE EMBANKMENT WAS ACROSS THE BUSY STREET LEADING OUT OF THE CARWASH AREA. I TURNED SLIGHTLY TO THE LEFT, IN A VAIN HOPE TO SLOW MY VEHICLE DOWN; TEARING OFF THE FRONT RIGHT SIDE AND WHEEL, THE VEHICLE CONTINUED ON, SLIDING DOWN ONTO A BUSY ROAD. IN TRYING TO AVOID A BUSY INTERSECTION, I PULLED UP OVER THE EMBANKMENT AT A LOWER GRADE ON TO A FLAT GRASSY AREA WHERE I COULD TAKE MY RIGHT HAND OFF THE WHEEL AND PULL THE GEAR SHIFT INTO NEUTRAL AND TURN OFF IGNITION. THANK GOD NO ONE WAS HURT. THE VEHICLE WAS INSPECTED BY TOYOTA SUBCONTRACTORS AND IS BEING REPAIRED TO BE RETURNED TO US. IT WILL BE IMPOSSIBLE FOR ME TO ALLOW MY FAMILY OR ANYONE FOR THAT MATTER TO DRIVE THAT CAR IN THE FUTURE, THE CAR IS WORTH MORE TO US THAN TO OTHERS. THE TONE OF THE INSPECTORS AND OTHER CONTACTS WITH THE TOYOTA COMPANY WAS ONE OF SKEPTICISM. I DID NOT HAVE FLOOR MATS IN THE CAR AND I KNOW THE DIFFERENCE AND LOCATION OF MY BRAKE, CONTRARY TO THEIR SUGGESTIONS. I THINK IT IS INTERESTING THAT THE CUSTOMER SERVICE AND INSPECTORS CONTINUE TO TREAT THEIR LOYAL CAR OWNERS WITH SUCH DISDAIN AND DISBELIEF AS IF WE ARE ALL LIARS. IT IS STRANGE THAT THE COMPLAINTS ARE ONLY COMING FROM TOYOTA OWNERS, BUT AS ONE REPORTER NOTED TOYOTA DRIVERS ARE AN AGING GROUP AND IT HAS NOT HAPPENED TO SCION DRIVERS. I HOPE THAT THIS PROBLEM IS TAKEN SERIOUSLY BY TOYOTA. *TR
NHTSA ODI #10343770
Official recalls
11Oct 18, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.
Consequence & remedy
Consequence: If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Consequence & remedy
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 25, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.
Consequence & remedy
Consequence: THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Remedy: TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 3, 2008
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.
Consequence & remedy
Consequence: IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.
Remedy: DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA08024 · Steering Intermediate Shaft Binding
Opened Oct 28, 2008 · Closed Jul 16, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Additional source detail variants (3)
Steering:column
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
EA06020 · Unexpected Closing Of Power Liftgate
Opened Dec 1, 2006 · Closed Jun 25, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hatchback/liftgate:lock; Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:hinge And Attachments; Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Additional source detail variants (4)
Latches/locks/linkages:hatchback/liftgate:lock
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:hinge And Attachments
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Illustration