NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
307 reportsClear category filter45,701 miles · May 29, 2012
Air Bags
THE AIR BAG LIGHT WARNING OF MY 2006 SIENNA (ONLY 45,000 MILES) STARTED BLINKING AND DIDN'T STOP. ACCORDING TO DEALER WHO RUN A DIAGNOSTIC (OPEN CIRCUIT B0111 OPEN SQUIB) THE CIRCUIT WIRING HARNESS NEEDED TO BE REPLACED. TOTAL COST OVER $2,000. I USED MY INSURANCE AND HAD IT FIXED. THE CAR STAYED IN THE DEALER FOR A WHOLE MONTH …
Read full complaint
THE AIR BAG LIGHT WARNING OF MY 2006 SIENNA (ONLY 45,000 MILES) STARTED BLINKING AND DIDN'T STOP. ACCORDING TO DEALER WHO RUN A DIAGNOSTIC (OPEN CIRCUIT B0111 OPEN SQUIB) THE CIRCUIT WIRING HARNESS NEEDED TO BE REPLACED. TOTAL COST OVER $2,000. I USED MY INSURANCE AND HAD IT FIXED. THE CAR STAYED IN THE DEALER FOR A WHOLE MONTH SINCE ACCORDING TO THEM THE PART WAS BEING ORDERED DIRECTLY FROM TOYOTA AND IT WAS COMING FROM JAPAN. THE PROBLEM RECURRED THE VERY NEXT DAY AFTER I TOOK THE CAR FROM THE DEALER AFTER FIXED. TOOK IT BACK TO THE DEALER AND WAS INFORMED THAT ACCORDING TO TOYOTA SERVICE BULLETIN A KIT NEEDS TO BE INSTALLED AT THE HARNESS LOCATED UNDER THE FRONT PASSENGER SEAT AND THAT THE FRONT PASSENGER AIR BAG NEEDS TO BE REPLACED. THE TOTAL COST WILL BE ANOTHER $1,000. I WAS ADVISED TO CONTACT TOYOTA CUSTOMER SERVICE TO LEARN WHAT TOYOTA COULD DO SINCE THIS IS A SAFETY ISSUE CAUSED BY A FAULTY ELECTRICAL COMPONENT FROM MANUFACTURING. I DON'T BELIEVE MY INSURANCE WILL COVER FOR THIS EXTRA COST. CHECKING ONLINE I NOTICED THAT HUNDREDS OF OTHER 2006 SIENNAS ARE HAVING THE SAME ISSUE. I BELIEVE TOYOTA SHOULD ISSUE A RECALL ON THIS PARTICULAR MODEL AND FIX IT. I WAS A HAPPY AND SATISFIED TOYOTA CUSTOMER UNTIL NOW AND DEPENDING ON THE OUTCOME OF MY CALL TO TOYOTA I MIGHT NOT CONSIDER TOYOTA IN MY NEXT CAR PURCHASE, UNFORTUNATELY. *TR
NHTSA ODI #10459844
59,500 miles · May 22, 2012
Air Bags
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE PARKED, THE AIR BAG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC. THE TECHNICIAN STATED THE AIR BAG AND AIR BAG HARNESS ON THE FRONT PASSENGER SIDE WOULD HAVE TO BE REPLACED BUT THE PART WAS NOT AVAILABLE FOR REPAIR. THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE PARKED, THE AIR BAG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC. THE TECHNICIAN STATED THE AIR BAG AND AIR BAG HARNESS ON THE FRONT PASSENGER SIDE WOULD HAVE TO BE REPLACED BUT THE PART WAS NOT AVAILABLE FOR REPAIR. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 59,500.
NHTSA ODI #10459254
37,771 miles · May 3, 2012
Air Bags
AIRBAG LITE IS ON. CODE B0111 OPEN SIDE SQUIB P/S TSC 0252-08 APPIES. R&R SIDE AIRBAG ASSEMBLY AS PER TSB 0252-08. RECHECKED SYSTEM WORKING AS DESIGNED. THE ENTIRE AIRBAG SYSTEM DOES NOT FUNCTION WHEN THE AIRBAG LITE IS ON. TOTAL AIRBAG SYSTEM FAILURE. REPAIRED AND WORKING AFTER REPAIR. *TR
NHTSA ODI #10457353
83,000 miles · Apr 30, 2012
Air Bags
THE DRIVER SIDE AIRBAG LIGHT HAS TURNED ON. *JS
NHTSA ODI #10456967
76,926 miles · Apr 23, 2012
Air Bags
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE AIR BAG SYSTEM SHORTED OUT AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND WOULD GET BACK IN TOUCH WITH THE CONTACT AT A LATER DATE. TH…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE AIR BAG SYSTEM SHORTED OUT AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND WOULD GET BACK IN TOUCH WITH THE CONTACT AT A LATER DATE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 76,926.
NHTSA ODI #10456204
28,000 miles · Mar 29, 2012
Air BagsStructure
WE PURCHASED THE VAN USED IN 2009 WITH 12000 MILES ON IT AND MADE OUR PURCHASE DECISION BASED ON THE REPUTATION FOR QUALITY AND SAFETY THAT TOYOTA HAD AT THE TIME. IN JULY 2009 THE SRS WARNING LIGHT BEGAN TO ILLUMINATE. ACCORDING TO THE DEALER THE AIR BAG WIRING HARNESS AND SYSTEM WAS KNOWN TO HAVE ISSUES. LUCKILY THE DEALER CON…
Read full complaint
WE PURCHASED THE VAN USED IN 2009 WITH 12000 MILES ON IT AND MADE OUR PURCHASE DECISION BASED ON THE REPUTATION FOR QUALITY AND SAFETY THAT TOYOTA HAD AT THE TIME. IN JULY 2009 THE SRS WARNING LIGHT BEGAN TO ILLUMINATE. ACCORDING TO THE DEALER THE AIR BAG WIRING HARNESS AND SYSTEM WAS KNOWN TO HAVE ISSUES. LUCKILY THE DEALER CONVINCED TOYOTA USA TO COVER THE REPAIR. IN NOVEMBER 2011 THE LIGHT AGAIN CAME ON AND DID ITS BLINKING THING. CURRENTLY WE HAVE A LITTLE OVER 48000 MILES ON THE VAN AND THE DEALER SAID THAT BECAUSE WE ARE PAST WARRANTY THAT IT WON'T BE COVERED. A PRIVATE MECHANIC TESTED THE SYSTEM AND DETERMINED THE AIRBAGS ARE NOT FUNCTIONING AND THAT TOYOTA HAS PUBLISHED A BULLETIN ACKNOWLEDGING THE ISSUE BUT REFUSES TO REPAIR THIS SAFETY CONCERN. WHEN THE LIGHT IS BLINKING OR ON, THE AIRBAGS WILL NOT DEPLOY, PUTTING EVERYONE INSIDE AT RISK. A VAN WITH 48000 MILES SHOULD NOT HAVE TO HAVE THE AIRBAGS REPLACED TWICE. LOOKING AT ONLINE FORUMS THERE SEEMS TO BE HUNDREDS IF NOT THOUSANDS OF OTHER SIENNA OWNERS EXPERIENCING THE SAME PROBLEMS AND YET TOYOTA STILL REFUSES TO RECALL THE PRODUCT OR OFFER A REASONABLE REPAIR. I AM AFRAID THAT IT WILL TAKE A TRAFFIC COLLISION RESULTING IN A DEATH OR MULTIPLE DEATHS TO PUSH TOYOTA TO FIX THIS SYSTEMIC PROBLEM. A SECOND CONCERN WHICH SEEMS TO BE PROBLEMATIC WITH OUR VAN AS WELL AS OTHERS IS THE WELDS WITHIN THE DRIVER DOOR BREAKING. THE VEHICLE HAS NOT BEEN IN AN ACCIDENT NOR ANY OTHER MAJOR INCIDENT TO CAUSE THEM TO BREAK. ACCORDING TO THE PRIVATE MECHANIC, IT IS A MANUFACTURING ISSUE AND THAT THE WELD SHOULD BE ONE OF THE STRONGEST PARTS OF THE VEHICLE AND SHOULDN'T BREAK. *JS
NHTSA ODI #10453513
145,654 miles · Mar 25, 2012
Air Bags
PULLED CODE B0111 OPEN SIDE SQUIB (RH) CIRCUIT MUST REPLACE PASSENGER SIDE FLOOR HARNESS AND PASSENGER SIDE AIR BAG ASSEMBLY. *TR
NHTSA ODI #10452921
90,000 miles · Mar 15, 2012
Air Bags
I OWN A 2006 TOYOTA SIENNA WHICH STARTED DISPLAYING AN AIRBAG WARNING LIGHT AT ABOUT 90,000 MILES. I HAD AN INDEPENDENT AIRBAG TECHNICIAN RUN DIAGNOSTICS. HE FOUND A HISTORY OF INCREASED RESISTANCE IN THE CONNECTOR UNDER THE DRIVERS SEAT. HE STATED THAT HE HAD SEEN THIS IN THE DRIVER AND FRONT PASSENGER CONNECTIONS OF MANY 20…
Read full complaint
I OWN A 2006 TOYOTA SIENNA WHICH STARTED DISPLAYING AN AIRBAG WARNING LIGHT AT ABOUT 90,000 MILES. I HAD AN INDEPENDENT AIRBAG TECHNICIAN RUN DIAGNOSTICS. HE FOUND A HISTORY OF INCREASED RESISTANCE IN THE CONNECTOR UNDER THE DRIVERS SEAT. HE STATED THAT HE HAD SEEN THIS IN THE DRIVER AND FRONT PASSENGER CONNECTIONS OF MANY 2006 SIENNAS. I FOUND ONLINE THAT THIS IS A WIDESPREAD PROBLEM OF A CRITICAL SAFETY SYSTEM FOR WHICH TOYOTA IS NOT TAKING RESPONSIBILITY. OWNERS ARE PAYING THOUSANDS OF DOLLARS FOR REPAIRS ONLY TO HAVE IT FAIL AGAIN WHICH SUGGESTS THAT TOYOTA HAS NO IDEA AS TO THE ROOT OF THE PROBLEM. HOPEFULLY, I HAVE SOLVED MY PROBLEM BY APPLYING PENETROX (AN ANTI CORROSIVE ZINC PASTE FOR ELECTRICAL CONNECTIONS) TO THE CONNECTORS UNDER BOTH FRONT SEATS AND CONNECTING AND DISCONNECTING EACH ABOUT 25 TIMES TO CLEAN THE CONTACTS. THE FIX HAS LASTED 2 MONTHS SO FAR. *TR
NHTSA ODI #10451771
44,000 miles · Mar 13, 2012
Air Bags
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT WAS DRIVING 45 TO 50 MPH WHEN THE AIR BAG SRS WARNING LIGHT ILLUMINATED REPEATEDLY. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED THAT THE SQUID MODULE AND HARNESS FOR PASSENGER AIR BAGS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAI…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT WAS DRIVING 45 TO 50 MPH WHEN THE AIR BAG SRS WARNING LIGHT ILLUMINATED REPEATEDLY. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED THAT THE SQUID MODULE AND HARNESS FOR PASSENGER AIR BAGS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 44,000. THE VIN WAS UNKNOWN.
NHTSA ODI #10451385
56,000 miles · Mar 6, 2012
Air Bags
PURCHASED VEHICLE USED IN AUGUST 2011 WITH APPROXIMATELY 52,000 MILES. UPON STARTING VEHICLE IN LATE DECEMBER 2011 (APPROXIMATELY 56,000), AIR BAG WARNING LIGHT BEGAN TO BLINK. THE NEXT DAY, THE LIGHT DID NOT BLINK AND APPEARED UNLIT (NORMAL). THE THIRD DAY, THE LIGHT BEGAN TO BLINK AGAIN AND HAS NOT STOPPED. THERE WAS NO UN…
Read full complaint
PURCHASED VEHICLE USED IN AUGUST 2011 WITH APPROXIMATELY 52,000 MILES. UPON STARTING VEHICLE IN LATE DECEMBER 2011 (APPROXIMATELY 56,000), AIR BAG WARNING LIGHT BEGAN TO BLINK. THE NEXT DAY, THE LIGHT DID NOT BLINK AND APPEARED UNLIT (NORMAL). THE THIRD DAY, THE LIGHT BEGAN TO BLINK AGAIN AND HAS NOT STOPPED. THERE WAS NO UNUSUAL BUMPING OR IMPACT THAT COULD HAVE CAUSED THE LIGHT TO ILLUMINATE. I TOOK THE VEHICLE TO THE DEALER FOR DIAGNOSIS. DEALER TOLD ME THAT THE AIRBAG WIRES HAD BEEN "TAMPERED WITH" - APPARENTLY BY THE PREVIOUS OWNER (VEHICLE HAS PRIOR SALVAGE TITLE, BUT HAS BEEN REPAIRED, INSPECTED, AND APPROVED FOR SERVICE AGAIN). THE DEAL QUOTED $2,500 - $3,000 TO REPLACE FAULTY WIRING HARNESS. I DECLINED THE SERVICE IN THE IMMEDIATE, TO CONSIDER THE SAFETY AND COST REPERCUSSIONS. ALTHOUGH I DECLINED SERVICE, THE AIR BAG LIGHT CEASED BLINKING - EVEN THOUGH THE VEHICLE WAS NOT REPAIRED. ADDITIONAL RESEARCH HAS REVEALED HUNDREDS, IF NOT THOUSANDS OF 2006 TOYOTA SIENNA OWNERS WHO HAVE HAD A NEARLY IDENTICAL EXPERIENCE. THERE ARE TSBS RELATED TO THIS ISSUE. A RECALL SEEMS NECESSARY FOR THIS IMPORTANT SAFETY ISSUE RELATED TO AN APPARENT FAULTY AIR BAG WIRING SYSTEM. *TR
NHTSA ODI #10450456
Official recalls
11Oct 18, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.
Consequence & remedy
Consequence: If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Consequence & remedy
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 25, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.
Consequence & remedy
Consequence: THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Remedy: TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 3, 2008
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.
Consequence & remedy
Consequence: IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.
Remedy: DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA08024 · Steering Intermediate Shaft Binding
Opened Oct 28, 2008 · Closed Jul 16, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Additional source detail variants (3)
Steering:column
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
EA06020 · Unexpected Closing Of Power Liftgate
Opened Dec 1, 2006 · Closed Jun 25, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hatchback/liftgate:lock; Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:hinge And Attachments; Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Additional source detail variants (4)
Latches/locks/linkages:hatchback/liftgate:lock
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:hinge And Attachments
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Illustration