2001 Toyota Sienna

TL* THE CONTACT OWNS A 2001 TOYOTA SIENNA. THE CONTACT STATED THAT THE VEHICLE EMITTED A STRONG GASOLINE FUEL ODOR WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THE CONTACT WAS ADVISED THAT THE ODOR WAS DUE TO A FAULTY FUEL CANISTER AND CAP. THE DEALER REPLACED THE FUEL CANISTER AND CAP BUT THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE FAILURE WAS LOCATED AT THE FUEL PIPE ASSEMBLY LINES. THE FUEL PIPE ASSEMBLY LINES WERE REPLACED TWICE TO CORRECT THE FAILURE. THE MANUFACTURER DENIED ASSISTANCE WITH THE REPAIR, DUE THE VEHICLE MILEAGE. THE FAILURE MILEAGE WAS 102,542 AND THE CURRENT MILEAGE WAS 103,515.

TL*THE CONTACT OWNS A 2001 TOYOTA SIENNA. WHEN THE CONTACT ATTEMPTS TO ADD FUEL TO THE VEHICLE, THE GAS PUMP WOULD CLICK AS IF THE TANK WAS FULL. HOWEVER, THE VEHICLE'S FUEL GAUGE INDICATED THAT THE TANK WAS EMPTY. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY CHANGED THE CHARCOAL FILTER. THE FAILURE CONTINUED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT REPAIR SHOP WHO WAS ABLE TO REPAIR THE FAILURE. THE SHOP REPLACED THE FUEL ROLLOVER VALVE. THE CONTACT STATED THAT SIX MONTHS LATER, THE FAILURE RECURRED. THE CURRENT AND FAILURE MILEAGES WERE 61,000.

AT 54,525 MILES, THE CHECK ENGINE LIGHT CAME ON. IT WAS DIAGNOSED AS "REPLACE AIR/FUEL SENSOR B1 S1." FAILURE CAUSED EXCESSIVE DAMAGE BECAUSE THE SENSOR FUSED INTO THE REAR EXHAUST MANIFOLD. DIAGNOSTIC TESTING $ 49.00 SENSOR REPLACEMENT PART 227.52 " " LABOR 150.00 REAR EXHAUST MANIFOLD 154.21 REAR EXHAUST MANIFOLD GASKET 29.27 REPAIR WAS NOT DONE AT A TOYOTA DEALERSHIP. I AM REPORTING THIS SO THAT TOYOTA WILL CHANGE THE DESIGN. FAILED PART SHOULD NOT DAMAGE SURROUNDING STRUCTURES. SUGGEST RECALL ON THIS PART IF TOYOTA CONTINUES TO USE THIS DESIGN. *NM

2001 TOYOTA SIENNA LE, PURCHASED NEW, STARTED HAVING PROBLEMS. "CHECK ENGINE" LIGHT CAME ON WHEN VEHICLE HAD APPROXIMATELY 25,000 PLUS/MINUS MILES. UNDER WARRANTY, TOYOTA DEALERSHIP REPLACED THE OXYGEN SENSOR WITHOUT A CHARGE. HOWEVER, DURING THIS PROCESS, THE "BEEP" SIGNAL YOU HEAR WHEN LOCKING-UNLOCKING THE VEHICLE WITH REMOTE KEY WAS DISAPPEARED. THIS IS ALSO FIXED UNDER WARRANTY. THE "CHECK ENGINE" LIGHT CAME ON AGAIN WHEN THE VEHICLE HAD ABOUT 35,000 MILES. TOYOTA DEALERSHIP SAID IT IS DUE TO A DIRTY VACUUM HOSE, THEY CLEANED IT WITH A CHARGE LITTLE OVER $100.00. THE NEXT DAY THE "CHECK ENGINE" LIGHT CAME ON AGAIN, THIS TIME THE TOYOTA DEALERSHIP SAID THEY NEED TO REPLACE THE CHARCOAL CANISTER (PARTS FREE, BUT WE HAVE TO PAY LABOR--ABOUT $100.00). THIS THING CAUSES EXTREME MENTAL DISTRESS, TIME, MONEY, SECURITY ETC.*JB

I FLLLED THE FUEL TANK ON 26 NOV 2003, AND DROVE THE VEHICLE 13 MILES. IT REMAINED PARKED IN THE DRIVEWAY, WHICH SLOPES TOWARD THE REAR AT ABOUT 20 DEGREES, UNTIL 28 NOV 2003 AT 12:30 PM. THERE WAS AT THAT TIME RAW GASOLINE DRIPPING IN TEASPOON TO TABLESPOON QUANTITIES FROM A LINE IN FRONT OF THE FUEL TANK TO THE DRIVEWAY, WITH A PUDDLE ABOUT 18 BY 28 INCHES. I DROVE THE VEHICLE ABOUT 1 MILE WITH THE ENGINE RUNNING SMOOTHLY, AFTER WHICH FOR ABOUT 4 MILES THE ENGINE HESITATED AND SURGED AT SPEEDS OVER 35 MPH. THE REMAINDER OF THE 10 MILE TRIP, THE ENGINE RAN SMOOTHLY AGAIN. LATER THAT DAY, THE SERVICE REP CALLED TO TELL ME THEY HAD COMPLETED DIAGNOSTIC TESTING WHICH SHOWED A DEFECTIVE CHARCOAL CANISTER, WHICH NEEDED TO BE REPLACED FOR $552.76, AT 62,612 MILES. THE REPAIR REPORT STATES THAT THE CHARCOAL CANISTER WAS SATURATED WITH RAW FUEL. THIS IS AN OBVIOUS SAFETY HAZARD.*AK