2022 Toyota RAV4

While driving at highway speeds, the moonroof suddenly and spontaneously exploded without being struck by any visible road debris or external objects. After safely pulling over and shutting the vehicle off to assess the damage, the car now refuses to start or crank. The electrical system and interior/dashboard lights still power on normally, but the ignition will not engage to drive the vehicle.

The car is Rav4 2022 fuel: gas. Dashboard showing Headlight System malfunction, Pre-Collision System malfunction and RSA System Malfunction. The alarm beep and sign of malfunction keep popping up on dashboard. I took it to Toyota dealership to be inspected and they notified me that "The Front Recognition camera Watchdog/Safety MCU Failure." This front camera is connecting to headlight system, Pre-Collision system and RSA system that causing them to be malfunction while I am driving. With all those system malfunction in the car, I am driving with a huge risk. I am certain that not only I have those problems but some owner of RAV4 2022 or perhaps other year that has the same microcomputer for Front Recognition camera for Safety have the same failure that would trickle down to safety of others on the road. The car is only 4 years old. The Microcomputer in the front camera should have been functioning with no problem, unless the factory didn't calibrate well or install malfunction microcomputer for the car. The dealership estimated the price to change the microcomputer $ 2000 and labor $ 400 something. Toyota should have recall and reimburse this service to customers since these problems are factory problems.

The sunroof shattered while I was driving. There were no other vehicles around me or on the street. I heard a loud bang and glass rained down on me. The glass is pitched upward like it exploded from the inside. There is no other damage to my car. I had no warning other than the loud bang. When I am not out, my car is in a garage it never sits outside.

Driving up a slope of about 20-30 degrees gradient of a straight lane going into a private parking lot. Braked and decided to make a 3-point turn to get back out. There was no traffic in the lane. Put gear on reverse while on the slope with the vehicle pointing in the up direction of the slope. Vehicle suddenly surge backwards, accelerating. Vehicle sped down the slope and crossed a street. Could not stop. Vehicle was stopped only after placing gear into park from reverse, and after jumping curb across the street. Fortunately, there were no cross traffic in either direction on the street, otherwise vehicle could have been T-boned. Tire wall on the rear passenger side busted. AAA was called to replace tire with spare. There were no warnings on the dashboard or any symptoms anywhere else, although the vehicle had all the safety features.. The next morning, vehicle was taken to Toyota of Carlsbad. Left there for diagnosis and tires change. Vehicle is left with Toyota of Carlsbad until this issue is answered/solved. Told by service manager of Toyota of Carlsbad to call Toyota USA at [XXX] to report incident by customer, and request Toyota USA to send expert from Toyota to diagnose issue. Called the [XXX] , and given a Report Ref #XXX for further action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The Panoramic Sunroof Shattered on its Own out of nowhere. It just made loud noise. we thought it was tire, but car did not make move, looking above we saw the panoramic section of sunroof shattered. I went to dealer, they said there is a point of contact (means something has hit the roof) and they told me i have to file with insurance company. Insurance company is asking a million questions. It seems they are both passing it to each other. TO my opinion it is manufacturing flaw. very unsafe!

At the car wash while slowly pulling (1mph) into a parking space to vacuum the vehicle the car unexpectedly accelerated. The brakes failed and the car continued to accelerate until forced into park and turning off the vehicle. During the acceleration there was a grinding noise. This acceleration caused the car to hit the front curb and cement pilings with poles supporting the roof and vacuum. There were no warnings or lights being presented. If not for the curb and being off the road anyone in the car would at the very least been injured and possibly hitting another auto. The dealer is claiming no none issues as described. The auto was towed to the body shop to inspect and repair. We were told by the body repair shop the front suspension failed. The auto was great prior to this incident. Afraid to drive for fear of a repeat especially due to others on the internet claiming the same issue has happened and often continued to have a repeat acceleration incident. No one has found resolution from Toyota. Approximately $7,000.00 worth of damage and our insurance has now gone up.

After driving for 35 minutes (in the rain), I pulled up to work and let someone out. While car was sitting there in park, it bucked in the back, I then put it into park and almost immediately, it shut off with this on the display "Engine Off, Steering Power Low, Do Not Drive". My lights and windshield wipers remained on. I tried to turn it back and and it shut off again. I waited a few minutes, turned it on and went to pull out onto main road and the car shut off again with the same message. Thankfully I was turning onto the main road so close to shoulder and able to keep my car pretty close to side of the road. I called the Toyota dealer who told me not to drive it and it would need to be towed. I towed it to the closest dealer and when they checked the codes (the next day), they said there were no codes and they could not replicate the problem. As a note, the rain was off and on, nothing that was worse than anything I have driven in previously. I drive main roads and did not go through any large puddles or anything similar. This is a major safety issue and I am terrified that it could happen while driving on a highway where I may not have time to get out of the way of other traffic (car literally stopped with no option of continuing to coast). I am also shocked that there were NO codes triggered as there was obviously some event and that the car is only one month outside of warranty.

I am filing this urgent complaint regarding a life-threatening defect in my 2022 Toyota RAV4 SUV that gravely endangers my family and the public. This is a desperate plea for intervention. For over a year, my vehicle has repeatedly displayed a terrifying, unreadable red alert and piercing buzzer, occurring 3-4 times without warning and not real collision threat. These incidents are terrifying precursors to catastrophic failure. The Toyota dealership dismissed my concerns, stating they "cannot do anything" without replicating the intermittent problem. This dangerous negligence compounds my frustration, especially after prior unaddressed issues like radio malfunctions and door water infiltration. Crucially, the dealer's own CAR DTC logs confirmed C14FE14: "steering angle sensor supply voltage circuit short to ground or open." This documented electrical failure directly impacts the steering system. Toyota's own webpage [XXX] ) also details similar warnings, confirming my fear of brake system activation. My paramount fear is a false Pre-Collision System activation. Imagine driving at high speed when the brakes violently engage or steering falters due to this electrical short. The unthinkable consequences could be a devastating collision, causing severe injury or death to my family and others. This is a documented defect, met with manufacturer and dealer refusal to act. I cannot feel secure driving this car, nor can I responsibly sell this ticking time bomb to another family. I implore the NHTSA to launch an immediate, comprehensive investigation into this critical safety defect. This is a public safety matter demanding urgent attention. Force Toyota to rectify this profound flaw before lives are lost. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)