2019 Toyota RAV4

TL* THE CONTACT OWNS A 2019 TOYOTA RAV4. WHEN THE FUEL TANK WAS FILLED UP, IT REGISTERED 3/4 FULL INSTEAD OF COMPLETELY FULL. THE VEHICLE WAS TAKEN TO BIG TWO TOYOTA OF CHANDLER (480-302-4651, LOCATED AT 1250 S GILBERT RD, CHANDLER, AZ 85286), BUT THE FAILURE COULD NOT BE DUPLICATED. THE TECHNICIAN STATED THAT IT COULD BE A DESIGN FLAW WITH THE FUEL TANK. THE FAILURE WAS NOT REMEDIED. THE MANUFACTURER STATED THAT THE FAILURE WAS A KNOWN ISSUE AND A CLAIM MANAGER WOULD CALL THE CONTACT. THE CONTACT WAS NOT CALLED BACK. THE FAILURE MILEAGE WAS APPROXIMATELY 200.

BRAND NEW VEHICLE HAD ONLY BEEN DRIVEN 20 MILES AWAY FROM THE DEALERSHIP, AT LOW SPEED, IN A PARKING LOT, ALARMS BEGAN GOING OFF INDICATING NUMEROUS SYSTEM MALFUNCTIONS INCLUDING; LOW BRAKE POWER, ANTILOCK BRAKE SYSTEM MALFUNCTION, VEHICLE STABILITY CONTROL SYSTEM MALFUNCTION, SECONDARY COLLISION BRAKE SYSTEM MALFUNCTION, ELECTRONICALLY CONTROLLED BRAKE SYSTEM MALFUNCTION, PRE-COLLISION SYSTEM MALFUNCTION, ULTRASONIC DETECTING & RANGING SYSTEM MALFUNCTION.

WHEN ATTEMPTS ARE MADE TO PUT FUEL IN THE VEHICLE THE PUMP STOPS AT 3/4 FILL. THIS DOES NOT MEAN THERE IS 3/4 THE QUANTITY THE GAS TANK HOLDS. IT IS EASY TO RUN OUT OF FUEL SINCE THE GAS GAUGE READING IS INACCURATE. IT TAKES MULTIPLE STARTING THE PUMP TO PUT MORE GAS IN BUT IT IS UNCLEAR HOW MUCH IT REALLY TAKES TO BE FULL. THIS IS DANGEROUS SINCE RUNNING OUT OF FUEL WHILE DRIVING CAN LEAD TO AN ACCIDENT. THIS HAPPENS WHEN THE CAR IS STATIONARY IN FRONT OF THE GAS PUMP.

TL* THE CONTACT OWNS A 2019 TOYOTA RAV4. THE CONTACT STATED THAT THERE WAS AN OBSTRUCTION REFLECTING OFF THE DASHBOARD ONTO THE DRIVER'S SIDE REARVIEW MIRROR. CHEROKEE COUNTY TOYOTA (301 LIBERTY BLVD, CANTON, GA 30114, (770) 704-9525) WAS CONTACTED AND SUGGESTED THAT THE CONTACT TRY TO GET USED TO THE REFLECTION ISSUE. THE DEALER TRIED TO GET THE CONTACT TO SWITCH TO A CAMRY, BUT SHE REFUSED. THE MANUFACTURER WAS CONTACTED AND PROVIDED A CASE NUMBER AND A CASE MANAGER. THE MANUFACTURER PROMISED A CALL BACK AND SCHEDULED AN APPOINTMENT, BUT IT WAS NOT KEPT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 48. *JS

MY 2019 TOYOTA RAV4 HYBRID LIMITED BUILT IN JAPAN HAS A FUEL FILL UP ISSUE THAT PEVENTS THE CAR FROM BEING FULLY FUELED UNDER NORMAL CIRCUMSTANCES. THE GAS PUMP WILL SHUT OFF 1-2 GALLONS BEFORE THE TANK IS ACTUALLY FULL, MEANING THAT IN ORDER TO GET A FULL TANK, THE USER HAS TO FORCE FUEL INTO THE TANK. THIS PRESENTS TWO PROBLEMS: 1) THIS IS A CONCERN BECAUSE THERE IS SOME SORT OF PRESSURE ISSUE INSIDE THE GAS TANK THAT'S PREVENING PROPER FILLING WHICH COULD RESULT IN GAS SPEWING OUT OF THE FILLER HOLE AND PRESENTING AN ENVIRONMENTAL/SAFETY/FIRE HAZZARD. 2) WITH A GAS TANK THAT'S LISTED AT 14.5 GALLONS THAT ADVERTISES A RANGE OF 600+ MILES ON A TANK OF GAS, YOU EFFECTIVELY HAVE A USEABLE FUEL QUANTITY AND RANGE WELL BELOW WHAT TOYOTA ADVERTISES MEANING THEY ARE ENGAGING IN FALSE ADVERTISING. MY DEALER IS AWARE OF THIS ISSUE SINCE OTHER OWNERS ARE EXPERIENCING THE SAME OR SIMILAR ISSUES, BUT SO FAR, TOYOTA IS UNABLE TO ADDRESS THIS FUEL FILLING ISSUE.

THE FUEL TANK IS EITHER UNABLE TO FILL TO THE RATED CAPACITY OR IS OUT OF CALIBRATION. THIS CAUSES THE STATION PUMP TO STOP PROVIDING FUEL BEFORE THE TANK IS FULL. IN ORDER TO OBTAIN ANYWHERE NEAR A FULL TANK OF GAS YOU MUST IGNORE THE PUMPS AUTOMATIC SHUTOFF AND GUESS AS TO WHEN TO STOP. THIS IS CLEARLY A SAFETY ISSUE AS NOT KNOWING WHEN TO STOP CAN CAUSE FUEL TO SPILL FROM THE VEHICLE. THIS HAS BEEN HAPPENING SINCE THE FIRST FILL UP OF THE VEHICLE IN APRIL OF 2019 AND CONTINUES TO THIS DAY (SEPTEMBER 2019). TOYOTA HAS REPLACED THE FUEL SENDING UNIT BUT THE ISSUE STILL PERSISTS. THEY HAVE NOT ISSUED ANY SERVICE BULLETINS OR WARNINGS REGARDING THIS ISSUE BUT CLAIM IT IS WIDESPREAD FOR THE 2019 RAV4 HYBRID. THEY ALSO CLAIM NO MORE REPAIR ATTEMPTS WILL BE MADE AS THEY DO NOT KNOW WHAT THE ISSUE IS OR HOW TO FIX IT.

DRIVER END OF LOWER DASH BOARD TRIM REFLECTS ON THE DRIVER SIDE VIEW MIRROR. REFLECTION INTERFERES WITH VISIBILITY. REFLECTION GOES AWAY WHEN THE WINDOW IS FULLY LOWERED. TOYOTO CUST SERVICE CLAIMS PROBLEM IS A DESIGN DEFECT AND THERE IS NO FIX FOR IT RIGHT NOW. DANGEROUS TO DRIVE THE VEHICLE WITHOUT COVERING THE DRIVERS END OF THE DASH.