2019 Toyota RAV4

Engine stalled on a highway going 65 mph in cruise control. I had 1/4 full fuel tank. just before the engine stopped working I read information on my dashboard I have to stop the car in .5 miles, than .3 miles and engine stalled within seconds. I was able to pull over with dead engine. I shut down the car using key (I have a mechanical key for ignition) and car started with a message 'hybrid system malfunction. output power reduced . visit your dealer." I visited local mechanic who read the codes and instructed its a faulty fuel pump. I filled the car with more gas and drove couple of miles with reduced power. I left the car for 36 hours and it started to run ok by itself. dealer replaced fuel pump and now it works fine. The day of incident I was able to smell gas around engine bay before incident. I was able to smell strong gas smell after incident after I filled more gas in the vehicle most likely from engine bay fresh air intake. My assumption is this is due to bad fuel/air ratio and the result was unburned fuel. The week before the incident engine felt it kicked in roughly on its start up (my car is a hybrid). I had a fuel pump recall performed 4 months before but the fuel pump failed based on codes p319300 p008700 p107a2a . dealer replaced fuel pump (2nd time) and car works well and much smoother than before.

I bought my vehicle new in August 2019, it currently has approximately 30,500 miles. A few months ago I noticed a water stain by the roof, right on the A pillar on the passenger side. I took it to Toyota and they determined it was from the sunroof, according to them one of the drains was clogged with leaves and dirt (prior to this I had NEVER opened/used the sunroof, not sure if leaves are able to get in there without ever opening the roof). They cleaned the water stain and sent me on my way, without checking for water damage. After doing some research online found out this was happening to quite a few frustrated people and seemed to happen in the 2019-2021 RAV4 vehicles, most people were told it was the sunroof but further research revealed the possibility that it was the roof rail that contained bad seals. The water is now pooling on both A pillars right where the airbags are housed. I feel there is a good possibility those airbags will not deploy properly in case of an accident. In addition, multiple customers have complaint of this issues causing electrical problems as well.

The contact owns a 2019 Toyota RAV4. The contact stated that there was an unknown blinking red light on the instrument cluster. The contact received notification of NHTSA campaign number: 20V682000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The contact called the local dealer and it was confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. Parts distribution disconnect. The approximate failure mileage was 25,000.

The Panoramic Sunroof spontaneously exploded while driving on the freeway. There was no impact point and the glass is bowed outward. When it exploded it was a very load pop and pressure feeling that made everyone's ears ring. About 2 seconds later small glass particles and glass dust fell down on the driver and passenger. This was reported to insurance company and taken to independent service center for estimate and repair. There were no warning lights or prior issues. The sun roof was in perfect working order and the vehicle has less than 25,000 miles on it. Driving context - 10:30 PM, light rain, outside temp was 38degrees, inside car temp set at 72 with heater on, sunshade was back, radio off, very little traffic on freeway with no road disturbances.

The contact owns a 2019 Toyota RAV4. The contact stated while driving approximately 50 MPH, the vehicle inadvertently stalled. The contact stated that an error electrical system warning message was displayed. The contact pulled over and had the vehicle towed to a local dealer where it was awaiting diagnostic testing. The manufacturer was not informed of the failure. The failure mileage was approximately 34,000. The VIN was not available.

The roof rack rails have begun leaking due to failed weather sealants around them. Water is seeping through when it rains, getting water on the airbags, headliner, and moves along the top frame. I’m scared the electrical components will become damaged. Issue began happening right around 45,000 miles when I noticed. I have only owned vehicle for 2.5 years.

The issue is the stock roof rack that comes with the vehicles. The clips that clip on to the body of the car have gaskets that deteriorate. Water leaks in through those holes and into the headliner of the car. The front SRS airbags are compromised and potentially rendered useless. The wiring that attaches to the airbags is also compromised because the water will eventually corrode it.

Around 2:30 pm on Thursday, December 2, 2021, my wife and I were on our way to the gym for a workout. I was pulling my auto out of my garage. It was in reverse when it stopped half way and did not finish backing out. I put it in drive and then in reverse and I was able to back out. Once out of my driveway, I backed out into the street in reverse. From reverse, I put my car in Drive to start driving on the street. At this point, the car spun out of control and I could not control its movements. The car turned around on the street and drove into my yard. It ran through the yard, spun around through some hedges, onto my driveway and continued back into the yard. At this time it hit a tree in the yard, went back on the road, turned into my driveway before coming to a stop. We got out and inspected the damage. The entire front bumper and the assembly was hanging from the body of the car. The damage was extensive. Thankfully, no one was on the road and the only damage was to my car and my yard. shrubs and tree. This car is a Limited Edition with cameras and braking functions that stop the car if an object comes in its way. The car kept accelerating and did not brake to avoid collision. Note: We bought this 2019 RAV4 in March 2019. It was brand new, full loaded with many safety features. In October of 2019, we heard sounds coming from the front of the car. We took it to Toyota dealership to have it diagnosed. They determined that the Electromagnetic Clutch Assembly needed to be replaced. The car had 7100 miles on the Odometer.

After a recall repair order was issued, the repairs were made and now accelerating under load or uphill, the vehicle will accelerate and then bogs down or chokes (the vehicle then loses speed and no longer accelates). The issue has occurred several times while accelerating to freeway speeds on freeway on-ramps (it’s a safety hazard). 1st attempt to repair by the dealer was made on 11/22/2021. 2nd attempt by the same dealership is pending for today 12/08/2021 at 1:30pm.