IllustrationEngine maintenance light turned on. Found out the engine coolant bypass valve needed to be replaced. Many other reported cases for make and model of this car.
2019 Toyota RAV4
Owner reports · Recalls · Investigations
More warning signs than most RAV4 years
Owner complaints for the 2019 Toyota RAV4 are substantially higher than the model-year median of 258.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all RAV4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2570–25K
2525–50K
1550–75K
575–100K
7100–150K
0150K+
309 reports with mileage · 568 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 205 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports2 fire reports16 injury reports
What owners actually said
877 reportsThe contact owns a 2019 Toyota Rav4. The contact stated that while the vehicle was parked, the two brackets that connect the rear automatic door cracked three-quarters of the way horizontally. The contact stated that the door was jiggled in place to remain closed. The vehicle was taken to a body shop where it was determined that…
Read full complaint
The contact owns a 2019 Toyota Rav4. The contact stated that while the vehicle was parked, the two brackets that connect the rear automatic door cracked three-quarters of the way horizontally. The contact stated that the door was jiggled in place to remain closed. The vehicle was taken to a body shop where it was determined that both rear hinges needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 68,000.
The back hatch was misaligned and over time became unusable. Upon inspection from the body shop the hinge the keeps the hatch attached to the vehicle at the top had pulled lose- the power hatch had essentially pulled away from the frame causing the misalignment. The manager at the body shop did some investigation and found that …
Read full complaint
The back hatch was misaligned and over time became unusable. Upon inspection from the body shop the hinge the keeps the hatch attached to the vehicle at the top had pulled lose- the power hatch had essentially pulled away from the frame causing the misalignment. The manager at the body shop did some investigation and found that this was an issue that resulted in a recall for the same RAV 4 for the 2013-2017 models but had yet to be applied to our model year. After contacting the toyota dealership it was confirmed that this has been an issue that they are seeing- in fact, after paying for the repairs (since toyota refused to do so)- the body shop manager said she has had another customer with the same problem in the last 48 hours. This is absolutely not related to any accident of any kind- there wasn't one- this is clearly a manufacturer's problem.
The DCM failed. On 2/11/2024, a speaker was no longer working. On 2/15/2024, it was confirmed that the vehicle's microphone was not working. The vehicle was taken to a Toyota dealership on 2/16/2024. They confirmed that the speaker/microphone were not working. They identified a Toyota Service Bulletin for this issue, requiring D…
Read full complaint
The DCM failed. On 2/11/2024, a speaker was no longer working. On 2/15/2024, it was confirmed that the vehicle's microphone was not working. The vehicle was taken to a Toyota dealership on 2/16/2024. They confirmed that the speaker/microphone were not working. They identified a Toyota Service Bulletin for this issue, requiring DCM replacement at the cost of the consumer. Since there is a Toyota Service Bulletin, it seems that this is a known issue. Safety is at risk as the vehicle is no longer hands-free for communication. There were no warning signs of this failure.
Coolant bypass valve
Engine cooling issues can cause the engine to overheat and cause a vehicle stall. The vehicle displays "Engine Maintenance Required Visit Your Dealer" when the AC is turned on, and has been confirmed by Arlington Toyota (Jacksonville, FL) dealer as a known issue to the coolant bypass valve with potential safety risks at 2:22pm E…
Read full complaint
Engine cooling issues can cause the engine to overheat and cause a vehicle stall. The vehicle displays "Engine Maintenance Required Visit Your Dealer" when the AC is turned on, and has been confirmed by Arlington Toyota (Jacksonville, FL) dealer as a known issue to the coolant bypass valve with potential safety risks at 2:22pm Eastern on [XXX]. The service department stated that this is common, and the valve is either stuck open or closed, and should be replaced as soon as possible to avoid failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
When it rains, I have a puddle of water in the footboard of my backseats in the car.
The vehicle was totaled due to a front end collision. The air bags did not deploy, the seat belt did not lock and the emergency alert when in an accident did not work. The driver was trapped in vehicle and unable to get door open, the vehicle was going about 40-45 mph at the time of the collision and the driver was flung forward…
Read full complaint
The vehicle was totaled due to a front end collision. The air bags did not deploy, the seat belt did not lock and the emergency alert when in an accident did not work. The driver was trapped in vehicle and unable to get door open, the vehicle was going about 40-45 mph at the time of the collision and the driver was flung forward causing whiplash and a concussion.
Coolant bypass valve is faulty. Everyone is having this issue, please please recall!
Major insurance companies have been refusing to insure my car because my car was affected by the natural disasters before I purchased the car. This information was fraudulently withheld by the dealership at the time of my purchase. Thus, I would like to have full refunds equal to my purchase price and repair costs.
Official recalls
720V682000 · Fuel System, Gasoline:delivery:fuel Pump
Nov 4, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.
20V373000 · Steering:electric Power Assist System
Jun 24, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and 2020 RAV4 Hybrid vehicles equipped with electric power steering (EPS). Water may enter through the steering gear box cover and cause a loss of electric power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist could increase steering effort at low vehicle speeds, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the power steering gear box, free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB11 / 20TA11.
20V286000 · Suspension:front:control Arm:lower Arm
May 20, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.
Consequence & remedy
Consequence: If a suspension control arm breaks, it can result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace both front lower suspension arms, free of charge. This recall began August 10, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's interim numbers for this recall are 20TB08 / 20TA08.
20V064000 · Engine And Engine Cooling
Feb 6, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.
Consequence & remedy
Consequence: A coolant leak can cause the engine to overheat and cause a vehicle stall in conventional gasoline vehicles, increasing the risk of a crash. Additionally, for all involved vehicles, the engine may get damaged mechanically, possibly resulting in an engine oil leak, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect and replace the engine including the engine block, as necessary, free of charge. The recall began April 3, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus at 1-800-255-3987. Toyota's number for this recall is 20TA04. Lexus' number for this recall is 20LA02.
19V576000 · Back Over Prevention: Sensing System: Camera
Aug 6, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 RAV4 and RAV4 Hybrid vehicles. Due to a damaged electrical connector, the back-up camera may not activate when the vehicle is in reverse. As such, these vehicles fail to comply to Federal Motor Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: If the backup camera system does not activate and the driver does not check his/her surroundings while reversing, there is an increased risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the back-up camera system and replace the audio display unit, if necessary, free of charge. The recall began September 27, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is K0N.
19V503000 · Equipment:other:labels
Jun 28, 2019
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
19V244000 · Equipment:other:labels
Mar 27, 2019
Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: If the driver cannot read the label, they may unknowingly overload the vehicle, increasing the risk of a crash.
Remedy: GST will notify owners, and dealers will provide corrected load carrying capacity modification labels, free of charge. The recall began May 24, 2019. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 19R1.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.