2019 Toyota RAV4

The 8-speed automatic on my 2019 RAV4 (2.5L 4 Cyl) has been shifting super rough at lower speeds, to the point to where downshifts can send the revs into redline territory, but the car really doesn't move. No warning lights, passed state inspection, recently serviced. purchaced this car in Janurary with 50k miles on it and noticed it within a few weeks of driving. I am now at 57k and the issue is signifigantly worse than it was before. Will be taking it to Toyota soon. The safety issues arise when I do not know how the car is going to accelerate or respond to throttle input in traffic. I don't trust the car to handle any fast throttle input if I need to move out of the way quickly.

My 2019 Toyota RAV4 Adventure suffered a sudden catastrophic transmission failure while driving on the highway on April 28, 2026, resulting in loss of forward gears and a dangerous situation. On April 28, 2026, while traveling in [XXX] , my 2019 Toyota RAV4 Adventure (159,173 miles) experienced a sudden transmission failure with no prior warning symptoms. The vehicle began slipping, made a whining noise, would not properly upshift or hold speed (became stuck in 3rd gear), and eventually lost all forward propulsion, creating a safety hazard on the road. I had the vehicle towed to Zanesville Toyota in [XXX] . Their diagnosis (copy of repair order attached) revealed severe internal damage including: Torque converter clutch actuator stuck off Multiple pressure control solenoids stuck Transmission slipping and complete loss of all forward gears Fluid full but contaminated with metal debris and clutch material Whining noise The dealer quoted approximately $15,000 for a full transmission + torque converter replacement and denied goodwill assistance. This appears to be part of a known issue with the 8-speed automatic transmission (UB80) in 2019+ Toyota RAV4 models. I am concerned this is a safety defect that can cause sudden loss of power while driving, increasing the risk of a crash. I have attached the Zanesville Toyota repair order dated 04/30/2026 documenting the failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

At 92,000 miles my transmission went out and Toyota told me I need a brand new one. It goes in for routine services. It’s available for inspection. For the last few years I addressed the issues of jerky shift motion and it was blown off every time. It is only 7 years old. It stalled out in a busy intersection and wouldn’t move forward or backwards. There were no warning lamps before it went out.

Safety issue: The vehicle experiences intermittent loss of acceleration and transmission “slip/rev” events, especially when cold, from a stop, or at low speed. At times, the vehicle revs as if in neutral, then re-engages. The driver sometimes must press the accelerator fully to gain speed. In one instance, the vehicle was driven slowly for several miles, pulled over, shut off, restarted, and the function temporarily improved. When it started: Symptoms began immediately after a routine service visit at a Toyota dealership ([XXX]). First noted deceleration going uphill with recovery. Next day, multiple warning indicators/messages appeared and vehicle was towed to the same dealership. Dealer response: Dealership advised transmission replacement based on diagnostic codes and quoted approximately $10,000, stating fluid check was not necessary. Second opinion: Independent shop found transmission fluid level extremely low (reported approx. 1/4 full). They refilled fluid; initially vehicle drove normally, but intermittent slipping/revving continued after pickup (worse when cold/low speed). No external leaks observed by second shop at that time. Current status: Vehicle continues to show intermittent loss of acceleration/slipping behavior, creating a safety risk in traffic. No current check engine light, but symptoms persist. Codes/records available: Codes: P07457F, P28167F, P088A7F, P27137F, C137BA2, C1241, C1280, U1117, B2227. Location: New York. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Toyota Rav4. The contact stated while driving 70 MPH, the vehicle experienced a loss of motive power. No warning light was illuminated. The contact managed to push the vehicle over to the shoulder of the road, and the vehicle was towed to the residence. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

The contact owns a 2019 Toyota Rav4. The contact stated that while her daughter was driving at an undisclosed speed, the vehicle stalled. The contact was unsure if the vehicle could be coasted to the side of the road. Several unknown warning lights were illuminated. The vehicle was towed to a collision center. The vehicle was then towed to the dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 116,248.

My 2019 Toyota RAV4 Hybrid (VIN: [XXX] ) suffered sudden engine failure due to coolant intrusion. On Nov 20, 2025, Johnstons Toyota in Harriman, NY (RO#XXX) diagnosed the issue and recorded DTCs P26CA31 and P26CB, which indicate failure of the coolant flow control/bypass valve. The dealer confirmed heavy white smoke from the exhaust with a strong coolant smell and advised the engine had failed, recommending a replacement. This vehicle is part of the early 2019 Japan-built batch widely known for premature electric water pump and coolant-flow system failures. Internal impeller swelling, seal leakage, and bearing seizure can cause coolant pressure spikes and ultimately head-gasket failure with coolant entering the cylinders. This defect has been reported by thousands of RAV4 Hybrid owners (2019–2021). Toyota has addressed it quietly through internal TSBs such as XXX and XXX but no public recall has been issued. The safety risk is severe: the engine began emitting thick white smoke and ran roughly, risking sudden power loss, overheating, or engine seizure while driving. A stall at highway speed could easily cause a collision. Toyota USA opened Case #XXX but declined assistance despite the defect being well documented. This failure was sudden, with no warning lights prior to the incident. Given the widespread nature of this defect and its clear safety implications, I request that NHTSA open a formal investigation into the electric water pump/coolant system failures in 2019–2021 Toyota RAV4 Hybrids and consider requiring a safety recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

There is a known TSB out for 2019 toyota rav4 and some select other years. The issue is a slow speed transmission issue. It is due to a programming issue. At slow speeds, if you try to go from the brake pedal to the gas pedal too quickly, there is a serious lag before power is delivered to the wheels. Which is very dangerous when making specific turns. An example is what happened to my wife and myself the other day. We were in a median turning lane, cars were coming, as we were coming to almost a stop, my wife went to apply the gas. There was a serious lag before power was delivered and it almost resulted in a T bone collision. My wife went to apply gas, there was no power for several seconds, which caused her to panic and hit the brakes again. In that process, the power was finally delivered to the wheels and caused the car to pull about halfway into the oncoming traffic before it stopped from her applying the brakes. She then hard to quickly reverse to avoid the collision. The TSB calls for a flash of the TCM and a relearn procedure to be done. Which I am having done today due to the severity of the incident we had. This could have 100% caused a serious or fatal accident. The two dealerships I spoke with severely down played it as an issue. This deserves a investigation and a recall to be sent out. I was never advised of the TSB or anything.