IllustrationGAS TANK IS SUPPOSEDLY 14 GALLONS BUT VEHICLE WILL NOT TAKE MORE THAN 9 GALLONS.
2019 Toyota RAV4
Owner reports · Recalls · Investigations
More warning signs than most RAV4 years
Owner complaints for the 2019 Toyota RAV4 are substantially higher than the model-year median of 258.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all RAV4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2570–25K
2525–50K
1550–75K
575–100K
7100–150K
0150K+
309 reports with mileage · 568 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 205 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports2 fire reports16 injury reports
Fuel/propulsion System complaints
255 reportsBOUGHT NEW FROM DEALER IN 10/19. 14.5 GAL FUEL TANK WILL NOT ACCEPT MORE THAN 9.8 GALLONS EVEN AFTER ~20 MILES AFTER IT SHOWS 0 MILES OF RANGE. THIS LEAVES 3-4 GALLONS (>120 MILES OF RANGE) UNAVAILABLE!! NOT AS ADVERTISED. TOYOTA IS AWARE, BUT DOING NOTHING!!!
I HAVE BEEN UNABLE TO FILL THE GAS TANK FULL FOR THE ENTIRE DURATION OF OWNERSHIP. THE PUMP CUTS OFF ABOUT 3 GALLONS SHORT. THE PROBLEM IS GETTING PROGRESSIVELY WORSE AND TOPPING UP DOESN'T HELP EITHER. THE DEALERSHIP WAS UNABLE TO HELP SAYING TOYOTA IS AWARE OF THE PROBLEM BUT THEY DO NOT HAVE ANY SOLUTION FOR IT.
COULD NOT FILL THE GAS TANK FULLY. IT TAKES ONLY 9.834 GAL OF FUEL INSTEAD OF 14.5 GAL. THIS IS WIDELY REPORTED PROBLEM, BUT TOYOTA SEEMS NOT TO ISSUE ANY RECALL.
PURCHASED A NEW 2019 TOYOTA RAV4 HYBRID AWD XLE ON 10/24/19. FUEL CAPACITY APPEARS TO BE ABOUT 11 GALLONS, AS OPPOSED TO THE 14.5 GALLONS ADVERTISED. I HAVE RUN THE CAR DOWN TO BELOW 10MILES OF RANGE MULTIPLE TIMES AND GET THE SAME RESULT. THIS 25% UNDERSTATEMENT OF FUEL CAPACITY TRANSLATES INTO ROUGHLY 100 MILES LESS OF TOTA…
Read full complaint
PURCHASED A NEW 2019 TOYOTA RAV4 HYBRID AWD XLE ON 10/24/19. FUEL CAPACITY APPEARS TO BE ABOUT 11 GALLONS, AS OPPOSED TO THE 14.5 GALLONS ADVERTISED. I HAVE RUN THE CAR DOWN TO BELOW 10MILES OF RANGE MULTIPLE TIMES AND GET THE SAME RESULT. THIS 25% UNDERSTATEMENT OF FUEL CAPACITY TRANSLATES INTO ROUGHLY 100 MILES LESS OF TOTAL RANGE THAN THE ADVERTISED 537-595 MILES OF RANGE. SEE ATTACHED PICS.
TANK WAS ADVERTISED AS HAVING A CAPACITY FOR 14.5 GALLONS. I AM NOT ABLE TO FULLY FILL THE TANK, ONLY PUTTING IN 9 TO 10 GALLONS MAXIMUM. TOYOTA HAS STATED THAT THEY ARE AWARE OF THIS PROBLEM AND THERE IS NO FIX. I AM UNABLE TO GET THE MILEAGE RANGE I WAS PROMISED UPON PURCHASE.
THE GAS TANK IS QUOTED AS HAVING 14.5 GALLON CAPACITY AND I AM ONLY TO FILL UP 10 GALLONS.
FUEL TANK ONLY HOLDS 10 GALLONS, TANK SHOULD HOLD 14 GALLONS. REDUCES DRIVING RANGE AND TIME TO FUEL UP - WHICH WAS THE MAIN REASON WE BOUGHT THIS CAR. WHEN DROVE CAR OFF DEALERSHIP LOT, DRIVING RANGE WAS 440 - DROVE 6 HOURS WITHOUT HAVING TO FILL UP. DRIVING RANGE WAS NEVER MORE THAN 340 AFTER THAT AND HAD TO FUEL UP ABOUT EVER…
Read full complaint
FUEL TANK ONLY HOLDS 10 GALLONS, TANK SHOULD HOLD 14 GALLONS. REDUCES DRIVING RANGE AND TIME TO FUEL UP - WHICH WAS THE MAIN REASON WE BOUGHT THIS CAR. WHEN DROVE CAR OFF DEALERSHIP LOT, DRIVING RANGE WAS 440 - DROVE 6 HOURS WITHOUT HAVING TO FILL UP. DRIVING RANGE WAS NEVER MORE THAN 340 AFTER THAT AND HAD TO FUEL UP ABOUT EVERY 3 HOURS. REPORTED TO TOYOTA CORPORATE.
THE GAS TANK DOES NOT FILL ALL THE WAY, SO I HAVE HAVING TO GO BACK AND PUMP MORE GAS INTO THE TANK. THIS SOMETIMES CAN LEAD TO OVERFLOW AND THE GAS LEAKING TO THE GROUND AND CAN BE HAZARDS.
UNABLE TO COMPLETELY FILL THE FUEL TANK. STOPS ABUT 4 GALLONS SHORT. HAPPENS ON EVERY FILL. I HAVE TO TRICKLE FILL IT TO GET CLOSE TO A FULL TANK. HAPPENS AT EACH FILL UP
Official recalls
720V682000 · Fuel System, Gasoline:delivery:fuel Pump
Nov 4, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.
20V373000 · Steering:electric Power Assist System
Jun 24, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and 2020 RAV4 Hybrid vehicles equipped with electric power steering (EPS). Water may enter through the steering gear box cover and cause a loss of electric power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist could increase steering effort at low vehicle speeds, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the power steering gear box, free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB11 / 20TA11.
20V286000 · Suspension:front:control Arm:lower Arm
May 20, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.
Consequence & remedy
Consequence: If a suspension control arm breaks, it can result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace both front lower suspension arms, free of charge. This recall began August 10, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's interim numbers for this recall are 20TB08 / 20TA08.
20V064000 · Engine And Engine Cooling
Feb 6, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.
Consequence & remedy
Consequence: A coolant leak can cause the engine to overheat and cause a vehicle stall in conventional gasoline vehicles, increasing the risk of a crash. Additionally, for all involved vehicles, the engine may get damaged mechanically, possibly resulting in an engine oil leak, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect and replace the engine including the engine block, as necessary, free of charge. The recall began April 3, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus at 1-800-255-3987. Toyota's number for this recall is 20TA04. Lexus' number for this recall is 20LA02.
19V576000 · Back Over Prevention: Sensing System: Camera
Aug 6, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 RAV4 and RAV4 Hybrid vehicles. Due to a damaged electrical connector, the back-up camera may not activate when the vehicle is in reverse. As such, these vehicles fail to comply to Federal Motor Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: If the backup camera system does not activate and the driver does not check his/her surroundings while reversing, there is an increased risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the back-up camera system and replace the audio display unit, if necessary, free of charge. The recall began September 27, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is K0N.
19V503000 · Equipment:other:labels
Jun 28, 2019
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
19V244000 · Equipment:other:labels
Mar 27, 2019
Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: If the driver cannot read the label, they may unknowingly overload the vehicle, increasing the risk of a crash.
Remedy: GST will notify owners, and dealers will provide corrected load carrying capacity modification labels, free of charge. The recall began May 24, 2019. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 19R1.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.