Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
970–25K
2125–50K
1650–75K
475–100K
4100–150K
2150K+
144 reports with mileage · 187 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 129 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
31 crash reports32 fire reports13 injury reports
What owners actually said
331 reports
Mileage unknown · Oct 27, 2025
Unknown Or OtherFire
I had just gotten off my vehicle, we were at a shopping center specifically Marshall’s, the employee announced a blue Toyota, I went outside and my car was in flames, the Fire Department said it was an electrical fire. I had never received a letter of a recall let alone Toyota calling me to tell my car was defective. Not only un…
Read full complaint
I had just gotten off my vehicle, we were at a shopping center specifically Marshall’s, the employee announced a blue Toyota, I went outside and my car was in flames, the Fire Department said it was an electrical fire. I had never received a letter of a recall let alone Toyota calling me to tell my car was defective. Not only until after my vehicle was damaged I received a call from them which made it suspicious.
NHTSA ODI #11695777
Mileage unknown · Oct 7, 2025
Electrical System
My vehicle has a recall for the battery. I took my car into Toyota in San Juan Capistrano. Car was purchased and owner’s manual states this vehicle uses a size 35 battery. When I returned to pick up my vehicle the service technician told me that “Toyota will only honor the recall on vehicles with a size 36 battery, and in order …
Read full complaint
My vehicle has a recall for the battery. I took my car into Toyota in San Juan Capistrano. Car was purchased and owner’s manual states this vehicle uses a size 35 battery. When I returned to pick up my vehicle the service technician told me that “Toyota will only honor the recall on vehicles with a size 36 battery, and in order for them to rectify the recall was for me to purchase a size 36 battery. There is no mention of that on our recall notice nor is there anything stating that on the NTSA website. What can i do to get this fix this issue. I believe this problem is also the reason we have had to replace our battery 3 times since 2021and also the cause of other malfunctions in our vehicle
NHTSA ODI #11691988
Mileage unknown · Oct 3, 2025
Unknown Or Other
I purchased my 2018 Toyota RAV4 Limited Hybrid in June 2018. The automatic liftgate has been a consistent issue with this vehicle since January 2024. It either fails to close completely or takes an unusually long time to shut. I followed the official Toyota dealership videos and performed the recommended recalibration steps, but…
Read full complaint
I purchased my 2018 Toyota RAV4 Limited Hybrid in June 2018. The automatic liftgate has been a consistent issue with this vehicle since January 2024. It either fails to close completely or takes an unusually long time to shut. I followed the official Toyota dealership videos and performed the recommended recalibration steps, but the problem remains unresolved. This is not just a matter of convenience. It presents a safety concern, particularly when loading items at night. Living in the Pacific Northwest, where it gets dark around 5 p.m., makes this even more concerning. I’m aware there is existing litigation related to this issue.
NHTSA ODI #11691142
64,000 miles · Sep 26, 2025
Electrical System
The contact owns a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM). The dealer was contacted; however, the contact was informed that parts were unavailable to repair the vehicle. The vehicle was not repaired. The manufacturer was contacted about parts availability. The…
Read full complaint
The contact owns a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM). The dealer was contacted; however, the contact was informed that parts were unavailable to repair the vehicle. The vehicle was not repaired. The manufacturer was contacted about parts availability. The contact stated that while attempting to start the vehicle, the vehicle failed to start due to a severed wiring harness. There was no warning light illuminated. The vehicle was not repaired. The approximate failure mileage was 64,000.
NHTSA ODI #11689952
Mileage unknown · Sep 15, 2025
Electrical System
After receiving a recall notice from Toyota for the battery mount I scheduled my appointment on June 24, 2025. After spending $916.31 on maintenance products all of a sudden the dealership did not have the battery mount for my vehicle. Is this legal? Why would a dealership schedule a repair and not have the product to comple…
Read full complaint
After receiving a recall notice from Toyota for the battery mount I scheduled my appointment on June 24, 2025. After spending $916.31 on maintenance products all of a sudden the dealership did not have the battery mount for my vehicle. Is this legal? Why would a dealership schedule a repair and not have the product to complete the recall? I was informed that I would be called when they had the part available and I still have not heard from the Toyota dealership. Are three months later considered a timely matter to correct the problem?
NHTSA ODI #11687306
Mileage unknown · Sep 11, 2025
Unknown Or Other
On September 3, 2025, I was driving down the I-10 in Biloxi, MS, at 6:45 a.m. It was around 75-80 degrees and the sun was just barely coming up. All of the sudden the glass in my sunroof completely shattered. There were no cars around me and it was an open portion of the road, so no rocks were flung up by nearby vehicles. Luckil…
Read full complaint
On September 3, 2025, I was driving down the I-10 in Biloxi, MS, at 6:45 a.m. It was around 75-80 degrees and the sun was just barely coming up. All of the sudden the glass in my sunroof completely shattered. There were no cars around me and it was an open portion of the road, so no rocks were flung up by nearby vehicles. Luckily, my kids were not with me, because a majority of the glass ended up in my backseat, ranging from huge chunks of about 3-4 inches in diameter to smaller shards being everywhere. I cut myself several times while trying to clean it up, so I can only imagine what it could have done to my kids! Luckily, I was able to keep my cool and not swerve off the road, as it was quite startling.
NHTSA ODI #11686505
134,000 miles · Sep 5, 2025
Electrical SystemPower TrainCrashInjury
The contact owns a 2018 Toyota Rav4. The contact stated that upon entering her carport in an attempt to park(P), the vehicle surged forward without warning. The vehicle blew through the carport's back wall and crashed into her neighbor's fence before coming to an independent stop. The air bags did not deploy upon impact. The con…
Read full complaint
The contact owns a 2018 Toyota Rav4. The contact stated that upon entering her carport in an attempt to park(P), the vehicle surged forward without warning. The vehicle blew through the carport's back wall and crashed into her neighbor's fence before coming to an independent stop. The air bags did not deploy upon impact. The contact did not seek medical attention but did sustain soreness in her neck, shoulders, and back. The carport's back wall, a bicycle, the neighbor's fence, and the hammock were all destroyed as a result of the accident. A police report was filed. The dealer was notified of the failure and immediately referred the contact to the manufacturer. The manufacturer was notified of the failure, and a case was filed. The manufacturer informed the contact that an engineer could be sent to a nearby dealer or independent mechanic to perform an investigation into the defect. The vehicle had yet to be serviced or diagnosed for the failure. The vehicle was not repaired. The failure mileage was approximately 134,000
NHTSA ODI #11685349
Mileage unknown · Aug 31, 2025
Unknown Or Other
The tailgate does not lift all the way. The hinges are intact. I believe its a pistón or sensor problem.
NHTSA ODI #11684195
Mileage unknown · Aug 31, 2025
Visibility/wiperCrash
The passenger side mirror and the collum that holds the windshield on the right side makes a complete blind spot that you can't see anything on that area. If you are turning you can't see even a whole car. The left side mirror and collum that holds the windshield is ok, but not the right one. I got into an accident with the fire…
Read full complaint
The passenger side mirror and the collum that holds the windshield on the right side makes a complete blind spot that you can't see anything on that area. If you are turning you can't see even a whole car. The left side mirror and collum that holds the windshield is ok, but not the right one. I got into an accident with the fire hydrant at a parking lot in town because I could not see it. I was turning right into the street and hit the fire hydrant.
NHTSA ODI #11684154
Mileage unknown · Aug 13, 2025
Electrical System
I received a recall notice from Toyota in 2023 for battery defect that could case short circuit and risk of fire. as of today aug. 13, 2025 they have been unable to repair/replace.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2017-2018 Toyota 4Runner and Tundra, 2018 Toyota Highlander, RAV4 and Lexus GX460 and 2017 Toyota Sienna and Tacoma vehicles. These vehicles may have incorrect load carrying capacity modification labels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect load information label can result in the operator overloading the vehicle and increasing the risk of a crash.
Remedy: Toyota will notify owners and provide them with corrected labels, free of charge. The recall began on January 23, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are H0Z for Toyota vehicles, and HLF for Lexus vehicles.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration