NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
69 reportsClear category filterMileage unknown · Apr 26, 2024
Electrical SystemFire
While driving, front of car ignited. Seems related to unresolved recall: Nov 01,2023 Manufacturer Recall Number23TB13 NHTSA Recall Number23V734 Recall StatusRecall Incomplete, remedy not yet available Summary Some replacement 12-volt batteries of the size specified for the subject vehicles have smaller top dimensions than others…
Read full complaint
While driving, front of car ignited. Seems related to unresolved recall: Nov 01,2023 Manufacturer Recall Number23TB13 NHTSA Recall Number23V734 Recall StatusRecall Incomplete, remedy not yet available Summary Some replacement 12-volt batteries of the size specified for the subject vehicles have smaller top dimensions than others. If a small-top battery is used for replacement and the hold-down clamp is not tightened correctly, the battery could move when the vehicle is driven with forceful turns. Safety Risk The movement could cause the positive battery terminal to contact the hold-down clamp and short circuit, increasing the risk of a fire. Remedy Toyota is currently preparing the remedy. When the remedy is available, Toyota dealers will replace the battery hold down clamp, battery tray, and positive terminal cover with improved ones FREE OF CHARGE. At this time, Toyota estimates the remedy will be available in the middle of 2024 but this is subject to change. Until the remedy is available, owners who have not had the free inspection performed under Consumer Advisory 21TG01 should be encouraged to do so.
NHTSA ODI #11585470
Mileage unknown · Feb 5, 2024
Electrical SystemEngine
2014 Toyota Rav 4 EV with 30,898 miles, the vehicle has full power but no start. towed vehicle to Toyota Dealership for dianostic it was checked with a scan tool and found code U0293, this set the code for lost communication with the EV control system. A special cable was bought to communicate with the vehicle root cause of prob…
Read full complaint
2014 Toyota Rav 4 EV with 30,898 miles, the vehicle has full power but no start. towed vehicle to Toyota Dealership for dianostic it was checked with a scan tool and found code U0293, this set the code for lost communication with the EV control system. A special cable was bought to communicate with the vehicle root cause of problem is Traction Motor bad need replaced and service plug at top of battery has blown fuse need replaced. Solution is engine replacement.
NHTSA ODI #11570102
Mileage unknown · Dec 28, 2023
Electrical SystemExterior LightingVisibility/wiper
2014 Toyota RAV4 perfectly good headlight bulb stops working on low beam selection, severely limiting visibility for night-time driving. Looks like everyone on the internet is having the same problem.
NHTSA ODI #11562386
Mileage unknown · Sep 20, 2023
Electrical SystemSteeringFire
My daughter was exiting the the freeway on off ramp and turning right. The car lost electrical power without any warnings on dash or notification. When she tried to turn the steering wheel she was unable to due to loss of power steering. She ended up crossing a median and was able to turn the wheel enough to pull into the suici…
Read full complaint
My daughter was exiting the the freeway on off ramp and turning right. The car lost electrical power without any warnings on dash or notification. When she tried to turn the steering wheel she was unable to due to loss of power steering. She ended up crossing a median and was able to turn the wheel enough to pull into the suicide lane. She noticed the hood was smoking so she shut off the car and exited the vehicle. Soon the car engine area was in flames. Fire department put out the fire and police made and incident report. The car is unusable.
NHTSA ODI #11545735
Mileage unknown · Aug 4, 2023
Electrical SystemEngineFire
Parked my vehicle 2014 Rav4 at work, went to my office and security called that my Toyota rav4 burst into flames. All caught on video. Sprinklers went off and fire department called. Fire started under the hood. Entire Engine compartment burned. Vehicle totaled.
NHTSA ODI #11536539
Mileage unknown · May 24, 2023
Electrical System
The multimedia screen has been stuck in a powering up/loading cycle but would not able to complete the loading cycle, so none of the multimedia functions (radio, DVD Player, Bluetooth, GPS, etc.) would be able to function. This happened to me in early 2023. Over the past months, I have searched similar issues and possible fixe…
Read full complaint
The multimedia screen has been stuck in a powering up/loading cycle but would not able to complete the loading cycle, so none of the multimedia functions (radio, DVD Player, Bluetooth, GPS, etc.) would be able to function. This happened to me in early 2023. Over the past months, I have searched similar issues and possible fixes on the internet, but seems no easy fixes, while reported dealer repair estimates for $800+. A Google search shows many similar problems with RAV4 from their 2013 model year on. One Youtube viedeo "Rav4 radio stuck in boot loop" has had 10,000 views as of today, May 23, 2023.
NHTSA ODI #11523582
Mileage unknown · Oct 31, 2022
Electrical SystemSteeringUnknown Or Other
As I drive the multimedia system reboots on its own. Also as I was exiting the freeway coming off a curvy ramp, the car shut down as I was driving and the steering wheel locked for a second and then it came back to life. As this happened the dashboard lit up as if it was in accessory mode. Luckily there was not a lot of traffic …
Read full complaint
As I drive the multimedia system reboots on its own. Also as I was exiting the freeway coming off a curvy ramp, the car shut down as I was driving and the steering wheel locked for a second and then it came back to life. As this happened the dashboard lit up as if it was in accessory mode. Luckily there was not a lot of traffic on the ramp. Also about 5 months ago i had it repaired at the dealer because of a torque converter extended recall
NHTSA ODI #11491642
87,000 miles · Sep 14, 2022
Electrical SystemFire
The contact owns a 2014 Toyota Rav4. The contact stated that while her husband was driving at an undetermined speed, an unknown vehicle crashed into the driver's side front quarter panel. There were no warning indicator lights illuminated. The vehicle was taken to an independent body shop. The vehicle was taken to another indepe…
Read full complaint
The contact owns a 2014 Toyota Rav4. The contact stated that while her husband was driving at an undetermined speed, an unknown vehicle crashed into the driver's side front quarter panel. There were no warning indicator lights illuminated. The vehicle was taken to an independent body shop. The vehicle was taken to another independent mechanic for tires who stated the battery was losing power and surging and not working efficiently. While at the mechanic's, they noticed smoke underneath the hood and the vehicle caught fire. The battery bar compartment was burnt. They were able to extinguish the fire. There were no reported injuries or police reports filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact had previously affixed a group 35 sticker on the battery. The manufacturer was not contacted. The approximate failure mileage was 87,000.
NHTSA ODI #11484459
Mileage unknown · Aug 18, 2022
Electrical SystemService BrakesSteeringFire
Steering and brakes quit working while driving. Able to safely get off road. Took to Toyota Service Department. Per invoice "improperly installed battery caused everything to melt" battery installed by AAA in March 2020. Size 35 battery. Extensive damage.
NHTSA ODI #11479937
Mileage unknown · Apr 6, 2022
Electrical SystemUnknown Or OtherFire
Our 2014 Rav4 LE with 37k miles caught on fire while parked in a shopping plaza parking lot. The fire department says I was lucky that I wasn't driving the car or I wasn't in the car with children, pets, or elderly parents or we could have died. If my car was parked next to others this fire could have spread and been absolutely …
Read full complaint
Our 2014 Rav4 LE with 37k miles caught on fire while parked in a shopping plaza parking lot. The fire department says I was lucky that I wasn't driving the car or I wasn't in the car with children, pets, or elderly parents or we could have died. If my car was parked next to others this fire could have spread and been absolutely catastrophic. We've had our car fully inspected once within the last 6 months, and a limited inspection during an oil change within the last 3 months. I believe the fire started with the battery, we think we were affected by this... https://www.consumerreports.org/car-safety/toyota-rav4-under-investigation-due-to-battery-fire-concerns-a8630737173/ Our battery was inspected recently during an oil change and it was fine. The car has very low miles. Prior to parking the car I noticed a sulfuric rotten egg smell which I thought was coming from one of the nearby restaurants in this plaza. I turned the engine off, rolled up the windows, and put the in-car ventilation on at which point I noticed the smell coming from the vents. I rolled the windows down and was going to pop the hood to investigate but I decided to wait a few minutes for the car to cool down. There were no check engine lights or attention lights on the dashboard. As I got out of the car to walk to the plaza I noticed a small amount of steam coming from between the cracks of the hood. About 45 seconds later when I walked to a nearby storefront I noticed a flame coming from between the windshield and hood. I promptly called 911 and the Skokie fire department arrived on the scene about 5 minutes later. They put out the car fire in about 3 - 4 minutes, but the car was a complete loss.
NHTSA ODI #11459901
Official recalls
4Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Mar 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Jan 16, 2015
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence & remedy
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Additional source detail variants (2)
Trailer Hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Exterior Lighting
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Dec 30, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
Consequence & remedy
Consequence: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration