The car lost all power to the wheels without warning. Fortunately the car was stopped at a red light but still had to be pushed out of the way in traffic with the help of strangers. The car was inspected by a Toyota service specialist who said that the splines had sheared off of the rotor and the entire motor would need to be …
Read full complaint
The car lost all power to the wheels without warning. Fortunately the car was stopped at a red light but still had to be pushed out of the way in traffic with the help of strangers. The car was inspected by a Toyota service specialist who said that the splines had sheared off of the rotor and the entire motor would need to be replaced. There were no warnings (no lamps, no messages, no sounds) prior to the failure.
NHTSA ODI #11467056
Mileage unknown · Aug 28, 2021
Fuel/propulsion System
Unknown. Vehicle is having problems with fuel system. Vehicle intermittently runs rough like engine is not getting enough gas.
NHTSA ODI #11430823
88,000 miles · Jan 23, 2020
Fuel/propulsion SystemService BrakesCrash
IN A PAVED PARKING LOT I ATTEMPTED TO PARK BY APPLYING THE BRAKES BUT THE CAR SURGED FORWARD. IT ONLY STOPPED BY GOING OVER A CURB AND HITTING A TREE AT THE PERIMETER OF THE PARKING SPACE.
NHTSA ODI #11301372
53,000 miles · Dec 1, 2019
Fuel/propulsion SystemPower TrainVehicle Speed Control
3 WEEKS AFTER THE 50,000 MILE SERVICE, ON OCTOBER 22 2019, I WAS DRIVING 35 MPH ON SOQUEL AVENUE, WHEN THE CAR BECAME UNRESPONSIVE, I LOST ALL POWER AND CONTROL OF THE VEHICLE, AND "CHECK EV SYSTEM" CAME ONTO THE INSTRUMENT CLUSTER. I WAS ABLE TO COAST TO THE SIDE OF THE ROAD INTO A BUS STOP, TURNED THE CAR OFF, AND HAD THE CAR …
Read full complaint
3 WEEKS AFTER THE 50,000 MILE SERVICE, ON OCTOBER 22 2019, I WAS DRIVING 35 MPH ON SOQUEL AVENUE, WHEN THE CAR BECAME UNRESPONSIVE, I LOST ALL POWER AND CONTROL OF THE VEHICLE, AND "CHECK EV SYSTEM" CAME ONTO THE INSTRUMENT CLUSTER. I WAS ABLE TO COAST TO THE SIDE OF THE ROAD INTO A BUS STOP, TURNED THE CAR OFF, AND HAD THE CAR TOWED INTO THE DEALERSHIP. THE DEALERSHIP WAS UNABLE TO REPLICATE THE SYMPTOM AND INFORMED ME THAT IT WAS DUE TO THE 12V BATTERY. THEY REPLACED IT AND ASSURED ME THE ISSUE WOULD NOT HAPPEN AGAIN. ON NOV 11, 2019, THE ISSUE HAPPENED AGAIN WHILE I WAS ON THE HIGHWAY THIS TIME. I HAD THE CAR TOWED IN AGAIN TO TOYOTA, WHO INFORMED ME THAT "SOME RAV4 EVS HAVE BEEN IN THE SHOP FOR MONTHS, UNABLE TO BE DIAGNOSED". I RESEARCHED THE SYMPTOM ONLINE AND FOUND THAT IT RELATED TO A 2015 RECALL THAT RELATED TO THE ELECTRIC TRACTION MOTOR. TOYOTA'S DESCRIPTION OF THE F01 RECALL: IN THE INVOLVED RAV4 EV'S, COMPONENTS IN THE ELECTRIC VEHICLE TRACTION MOTOR ASSEMBLY, WHICH IS PART OF THE PROPULSION SYSTEM, MAY CAUSE THE VEHICLE TO SHIFT TO 'NEUTRAL' DUE TO A SOFTWARE ISSUE. THIS CONDITION WILL ALSO TRIGGER A 'CHECK EV SYSTEM' WARNING MESSAGE ON THE INSTRUMENT PANEL AND TURN ON A MALFUNCTION INDICATOR LAMP. IF THE VEHICLE SHIFTS TO 'NEUTRAL', THIS WILL RESULT IN A COMPLETE LOSS OF DRIVE POWER, WHICH CAN INCREASE THE RISK OF A CRASH. I INFORMED THE DEALERSHIP THAT MY SYMPTOMS MATCHED UP WITH RECALL EXACTLY, AND THEN WAS TOLD THAT IT HAD NOTHING TO DO WITH THIS AS THIS RECALL HAD BEEN PERFORMED ON APRIL 18 2016 WHEN I HAD MY CAR IN. UPON FURTHER QUESTIONING, I WAS ALSO TOLD THAT SOME OF THE RAV4 EVS HAD HAD THEIR MOTORS REPLACED AS PART OF THIS RECALL, IN ADDITION TO THE SOFTWARE CHANGE, BUT MINE HAD NOT. TOYOTA FAILED TO RECOGNIZE THIS FLAW NOT ONCE BUT TWICE AND I AM SEEKING COMPENSATION FOR FAILURE TO PROPERLY RECOGNIZE AND ADDRESS A KNOWN ISSUE.
NHTSA ODI #11283129
Mileage unknown · May 7, 2018
Fuel/propulsion System
MY O2 SENSORS CONTINUE TO GO OUT CAUSING MULTIPLE DASH LIGHTS TO COME ON ALONG WITH GAS CONSUMPTION IF NOT REPLACED IMMEDIATELY! I HAD THE CAR FOR 2 DAYS WHEN THIS HAPPENED, NOW AGAIN. THIS IS RIDICULOUS
NHTSA ODI #11092193
77,113 miles · Jan 3, 2018
EngineFuel/propulsion System
MY 2012 RAV4 MAIN EVAP CANISTER WENT BAD AT ONLY 77,113 MILES. IT ALMOST COSTED ME $1550 TO GET THIS PART REPLACED, BUT THANKFULLY WAS ABLE TO CONVINCE THE DEALERSHIP TO GET ME A DEAL ON THE REPAIR. THERE IS NO REASON FOR THIS PART TO GO BAD SO QUICKLY. I DO NOT TOP OFF MY GAS AND I HAVE HAD IT IN FOR ROUTINE MAINTENANCE AT THE…
Read full complaint
MY 2012 RAV4 MAIN EVAP CANISTER WENT BAD AT ONLY 77,113 MILES. IT ALMOST COSTED ME $1550 TO GET THIS PART REPLACED, BUT THANKFULLY WAS ABLE TO CONVINCE THE DEALERSHIP TO GET ME A DEAL ON THE REPAIR. THERE IS NO REASON FOR THIS PART TO GO BAD SO QUICKLY. I DO NOT TOP OFF MY GAS AND I HAVE HAD IT IN FOR ROUTINE MAINTENANCE AT THE DEALERSHIP SINCE IT WAS PURCHASED. TO MAKE THE SITUATION WORSE, WHEN THE CHECK ENGINE LIGHT COMES ON, THE 4WD AND TRACTION CONTROL UNITS TURN OFF, MAKING MY CAR HARD TO CONTROL IN THE SNOW. I WAS TOLD BY TUFFY THIS IS A COMMON THING AND THAT WAS A PREVIOUS RECALL FOR OLDER VEHICLES. THE CODE WAS ON FOR A FEW WEEKS, DIDN'T CLEAR. I HAD IT DIAGNOSED AT TUFFY AND THE DEALERSHIP, SAME DIAGNOSIS. I HAVE ALSO HAD A PROBLEM WITH THE TRANSMISSION JERKING WHEN I PUT THE CAR INTO DRIVE, EVEN IN WARM WEATHER, WHEN IT'S THE FIRST DRIVE OF THE DAY. THIS HAS BEEN OCCURRING SINCE I PURCHASED THE VEHICLE WITH 40K ON IT.
NHTSA ODI #11058280
19,000 miles · Sep 17, 2015
EngineFuel/propulsion SystemUnknown Or Other
THIS HAS HAPPENED ABOUT THREE TIMES. WHEN I AM STOPPING THE CAR WITH MY FOOT ON THE BRAKE THE ENGINE SUDDENLY REVS UP AND I HAVE TO REALLY EXERT PRESSURE ON THE BRAKE TO PREVENT THE CAR FROM LURCHING AHEAD. AFTER A FEW SECONDS OF BRAKING, THE ENGINE STOPS REVVING.
NHTSA ODI #10764501
18,500 miles · Sep 11, 2014
Fuel/propulsion SystemPower Train
ON SEPTEMBER 6, 2014 AT 4:20PM WHILE PULLING FORWARD INTO A PARKING SPACE THE CAR HAD AN UNINTENDED ACCELERATION. THIS IS THE THIRD TIME WITH THE EXACT SAME CIRCUMSTANCES. I PULLED FORWARD INTO A PARKING SPACE AND STOPPED. I PLACED THE CAR INTO REVERSE WITH MY FOOT ON THE BRAKE TO RE-ADJUST THE POSITION OF THE VEHICLE IN THE…
Read full complaint
ON SEPTEMBER 6, 2014 AT 4:20PM WHILE PULLING FORWARD INTO A PARKING SPACE THE CAR HAD AN UNINTENDED ACCELERATION. THIS IS THE THIRD TIME WITH THE EXACT SAME CIRCUMSTANCES. I PULLED FORWARD INTO A PARKING SPACE AND STOPPED. I PLACED THE CAR INTO REVERSE WITH MY FOOT ON THE BRAKE TO RE-ADJUST THE POSITION OF THE VEHICLE IN THE SPACE. BACKED OUT WITHOUT APPLYING FOOT TO ACCELERATOR. I APPLIED THE BRAKED WHEN CAR WAS OUT OF THE SPACE. WITH FOOT ON BRAKE THEN SHIFTED INTO DRIVE AND THE CAR IMMEDIATELY ACCELERATED TO 4,000 RPMS. WITH MY FOOT FIRMLY ON THE BRAKE THE CAR CONTINUED AT 4,000 RPMS FOR THREE SECONDS THEN DROPPED THE RPMS TO 1100. THE WEATHER WAS CLEAR, 84 DEGREES, 77% HUMIDITY, DRY PAVEMENT, NO ALL WEATHER FLOOR MATS. THE CAR HAD RECENTLY HAD AN ECU PROGRAMMING UPDATE AT 17,000 MILES, WHEN AT TOYOTA FOR AN OIL CHANGE. THE PROBLEM STARTED IMMEDIATELY AFTER THE PROGRAMMING UPDATE. I HAVE HAD THE VEHICLE BACK TWICE AND TOYOTA CAN NOT FIND THE ISSUE. *TR
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
Consequence & remedy
Consequence: A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Remedy: Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2009-2012 RAV4 vehicles manufactured October 27, 2008, to December 19, 2012 and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the affected vehicles, water may drip onto the joint that connects the wiper linkage to the wiper motor.
Consequence & remedy
Consequence: Over time, the dripping water may cause corrosion and wear at the joint, potentially resulting in the separation of the wiper linkage. Once this occurs, the wipers would not function, reducing driver visibility and increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the water diverter channel. In addition, a new wiper linkage with a wiper motor crank arm will be installed. The wiper linkage will have a protective cover over the wiper linkage joint to minimize water splash and a retainer ring to prevent the wiper arm from separating from the wiper motor. The recall began on November 7, 2016. Owners may contact Toyota's customer service number at 1-800-331-4331.
Toyota is recalling certain model year 2012 and 2013 Toyota Tacoma and Lexus RX350 vehicles and certain model year 2012 Toyota Rav4 vehicles. In the affected vehicles, the brake system contains a brake actuator that adjusts the fluid pressure of each wheel cylinder. An electrical component within the actuator may experience an increased resistance resulting in the illumination of various warning lights, including those for the Vehicle Stability Control (VSC) system, Antilock Brake System (ABS), and Traction Control system.
Consequence & remedy
Consequence: If this occurs, these systems could become inoperative, reducing the directional control assistance, increasing the risk of a crash.
Remedy: Toyota will notify owners, and Toyota and Lexus dealers will update the software for the Skid Control electronic control unit, free of charge. The recall began on March 28, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Electronic Stability Control (esc)
Toyota is recalling certain model year 2012 and 2013 Toyota Tacoma and Lexus RX350 vehicles and certain model year 2012 Toyota Rav4 vehicles. In the affected vehicles, the brake system contains a brake actuator that adjusts the fluid pressure of each wheel cylinder. An electrical component within the actuator may experience an increased resistance resulting in the illumination of various warning lights, including those for the Vehicle Stability Control (VSC) system, Antilock Brake System (ABS), and Traction Control system.
Consequence: If this occurs, these systems could become inoperative, reducing the directional control assistance, increasing the risk of a crash.
Remedy: Toyota will notify owners, and Toyota and Lexus dealers will update the software for the Skid Control electronic control unit, free of charge. The recall began on March 28, 2014. Owners may contact Toyota at 1-800-331-4331.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Toyota is recalling certain model year 2012 and 2013 Toyota Tacoma and Lexus RX350 vehicles and certain model year 2012 Toyota Rav4 vehicles. In the affected vehicles, the brake system contains a brake actuator that adjusts the fluid pressure of each wheel cylinder. An electrical component within the actuator may experience an increased resistance resulting in the illumination of various warning lights, including those for the Vehicle Stability Control (VSC) system, Antilock Brake System (ABS), and Traction Control system.
Consequence: If this occurs, these systems could become inoperative, reducing the directional control assistance, increasing the risk of a crash.
Remedy: Toyota will notify owners, and Toyota and Lexus dealers will update the software for the Skid Control electronic control unit, free of charge. The recall began on March 28, 2014. Owners may contact Toyota at 1-800-331-4331.
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration