Suspension. Review the 101 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 83 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

57 crash reports3 fire reports23 injury reports

Suspension complaints

101 reports

Clear category filter

86,000 miles · Aug 22, 2025

Suspension

Read full complaint

The contact owns a 2010 Toyota Rav4. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 13V383000 (Suspension) in 2015. The contact stated that in 2015 while driving at an undisclosed speed, the low tire pressure warning light illuminated. The contact took the vehicle to a tire dealer, and it was determined that the rear tires were worn and needed to be replaced. The contact replaced all four tires. The vehicle was repaired. The contact stated that in 2020 the low tire pressure and the traction control warning light illuminated. The contact had taken the vehicle to another tire dealer who diagnosed the vehicle and determined that the rear tires were worn and needed to be replaced. The contact was advised that the rear tires could not be aligned because of the rear suspension arms, that was causing the quick wear of the tires. The vehicle was repaired. The vehicle was taken to a tire dealer in 2024 and observed that the low tire pressure and traction control warning lights were illuminated. The contact stated that the vehicle was shaking while driving at various speeds prior to the warning lights being illuminated. The contact was informed that the rear tires could not be aligned due to a failure with the rear suspension arms. The vehicle was repaired. The manufacturer was informed of the failure and advised the contact to take the vehicle to a dealer. The contact took the vehicle to a local dealer who aligned the front wheels, but the rear tires could not be aligned. The contact informed the dealer about NHTSA Campaign Number: 13V383000 (Suspension) and was informed that the recall had been completed. The failure mileage was approximately 86,000.

NHTSA ODI #11682455

Mileage unknown · Mar 24, 2025

EngineSuspension

Read full complaint

Engine oil is burning with out discharging from the engine. Can find no leak anywhere in the engine compartment. Constantly adding oil to the car as the oil indicator isn’t working either. The engine compression is spot on to manufacturers specifications. If the engine runs out of oil it could lead to a crash. Suspension: Loud popping in the rear drivers side when first moving. Don’t know if it is tie rod or something else. Don’t need whatever is causing the pop to break as that could lead to a crash.

NHTSA ODI #11650156

Mileage unknown · Sep 11, 2024

SuspensionCrash

Read full complaint

NHTSa CAMPAIGN ID 16v596000 AUG 12, 2016 Recalls supercedes 13V-383 vehicles inspected but did not have both arms replaced. Vehicles need to have both arms replaced. Recall done on vehicle (RAV4 2010) were COJ - 1/9/2013 Stevens Creek Toyota CSJ - 9/21/2014 Capitola Toyota Control Arm were not replaced at these times. My car is currently being serviced at IQ Autoworks in Campbell CA. I've been told the control arm needs replacement. Quoted $1700 to replace one control arm.

NHTSA ODI #11614083

Mileage unknown · Apr 22, 2023

SuspensionUnknown Or Other

I just purchased a used 2010 toyota rav 4 base fwd and when making left or right turn I hear loud clunking noises and when backing up I hear squeaking noises plus I see liquid under car near middle. I also noticed when I add washer fluid and check level couple days later without using it ,,it is not visible ...and can't find pin…

Read full complaint

NHTSA ODI #11518415

97,900 miles · Dec 1, 2021

Engine And Engine CoolingPower TrainSuspension

Read full complaint

The contact owns a 2010 Toyota RAV4. The contact stated that while driving at an undisclosed speed, the vehicle made abnormal sounds. The vehicle was taken to the dealer, but the dealer could not duplicate the failure. The vehicle was taken to another dealer, Nashville Toyota North (2400 Gallatin Pike N, Madison, TN 37115), and diagnosed that the rear differential coupling was leaking oil, the rear driver's side axle bearing was faulty, and the radiator was leaking. The rear differential coupling, rear driver's side axle bearing, and radiator needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and informed the contact that the vehicle was past the nine-year extended warranty coverage. The failure mileage was 97,900.

NHTSA ODI #11442313

Mileage unknown · Jul 17, 2021

EngineSuspension

Read full complaint

This car was bought for a new driver and we have had 2 separate occasions when she has gotten somewhere and the car wont start. All the warning lights come on, but will not do anything when you push the button. We can jump it and it will start. This is not safe for a young person that could get stranded at random somewhere, and is now afraid to take it somewhere. We have checked the connections and the battery has been checked and is fine. The other complaint is the rear suspension recall. The tires were rotated and now it has a vibration, I was told that because of the recall it cannot be aligned unless things are replaced because of the terrible fix job on the recall. If something is recalled it should be fixed correctly and not be a bandaid job. There should not be a cost associated with a cheap fix that caused more problems. We purchased this vehicle because of reputation, if they are not supporting their product, then it will go and no other toyota products will be purchased.

NHTSA ODI #11425256

125,000 miles · Apr 23, 2021

Service BrakesSuspensionCrash

Read full complaint

TL* THE CONTACT OWNS A 2010 TOYOTA RAV-4. THE CONTACT STATED WHILE DRIVING AT 40 MPH AND APPROACHING AN EXIT RAMP OFF THE HIGHWAY, THE CONTACT STATED THEY WERE DEPRESSING ON THE BRAKE PEDAL BUT THE VEHICLE DID NOT SLOW DOWN AND CONTINUED TO ACCELERATE WHICH CAUSED THE VEHICLE TO HIT A FENCE. THE VEHICLE CAME TO A STOP AND THE CONTACT SHIFTED TO PARK, THE CONTACT WAS ABLE TO RESTART, AND CONTINUED TO DRIVE THE VEHICLE TO THEIR RESIDENCE. THE AIR BAGS DID NOT DEPLOY AND NO WARNING LIGHT ILLUMINATED. THERE WERE NO INJURED REPORTED. NO POLICE REPORT WAS FILED. THE CONTACT HAD THE VEHICLE TOWED TO LOCAL DEALER AUTOMAX CAR SALES (9541 NW 27TH AVE, MIAMI, FL 33147 PHONE: (305) 835-2222) WHO STATED THEY REPAIRED AND REPLACED THE BRAKES AND CONTROL ARMS ON THE VEHICLE HOWEVER THE FAILURE PERSISTED WITH SCREECHING NOISE COMING FROM THE BRAKES. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.

NHTSA ODI #11413539

Mileage unknown · Mar 12, 2020

Suspension

Read full complaint

REGARDING NHTSA CAMPAIGN: 13V383000 FOR 2006-2011 TOYOTA RAV4 THE ACCEPTED REPAIR PROCEDURE FOR THE ABOVE REFERENCED NHTSA CAMPAIGN IS FLAWED. ON MY VEHICLE, THE EFFECT OF PERMANENTLY DISABLING THE REAR TOE ADJUSTMENT HAS GREATLY INCREASED MAINTENANCE AND OPERATING COSTS AND HAS POTENTIALLY DEGRADED THE SAFETY OF ALL VEHICLES OF THIS TYPE. I HAVE EXPERIENCED GREATLY ACCELERATED WEAR OF THE RUBBER SUSPENSION COMPONENTS AND TIRES RESULTING IN THE REQUIREMENT OF A COMPLETE REAR SUSPENSION REBUILD. MY CONCERN IS THAT OTHER VEHICLES OF THIS TYPE THAT ARE NOT MAINTAINED TO STANDARDS DUE TO COST, OR HAVE HAD THE RECALL REVERSED TO MITIGATE THE FINANCIAL IMPACT, AS I HAVE DONE, ARE OPERATING IN A POTENTIALLY DANGEROUS CONDITION. IN EFFECT THIS CAMPAIGN HAS CREATED A COST BARRIER TO PROPER MAINTENANCE OF CRITICAL SAFETY SYSTEMS. I HAVE SPOKEN WITH TOYOTA CORPORATE, AND THEY HAVE NO INTEREST IN INVESTIGATING, REVISITING OR OFFERING OTHER SOLUTIONS TO THIS ISSUE AS THE RECALL REPAIR PROCEDURE WAS QUOTE "APPROVED BY THE GOVERNMENT".

NHTSA ODI #11317769

Mileage unknown · Nov 4, 2019

Suspension

2010 TOYOTA RAV4. CONSUMER WRITES IN REGARD TO WARRANTY ENHANCEMENT PROGRAM AND FEELS THE COMPANY AND DEALERSHIP SHOULD COVER WARRANTY WORK. *AS *JS

NHTSA ODI #11277895

79,000 miles · Oct 20, 2019

Suspension

REAR SUSPENSION FIX OF PREVIOUS RECALL WILL NOT ALLOW REAR ALIGNMENT OF VEHICLE BECAUSE OF THE EPOXY ENCASEMENT. THIS IS NOT ACCEPTABLE. JUST SPENT 800.00 ON TIRES AND ALIGNMENT ONLY TO FIND OUT THE REAR IS OUT OF ALIGNMENT AND CAN'T BE ALIGNED DUE TO TOYOTA'S FIX (EPOXY ENCASEMENT).

NHTSA ODI #11269582

Official recalls

16V596000 · Suspension:rear

Aug 12, 2016

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.

Consequence & remedy

Consequence: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

Remedy: Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.

16V396000 · Seats:front Assembly:seat Heater/cooler

Jun 2, 2016

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Consequence & remedy

Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

16V096000 · Seat Belts:rear/other

Feb 19, 2016

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.

Consequence & remedy

Consequence: A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.

Remedy: Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.

15V689000 · Visibility:power Window Devices And Controls

Oct 22, 2015

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Consequence & remedy

Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

15V577000 · Visibility/wiper

Sep 18, 2015

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2009-2012 RAV4 vehicles manufactured October 27, 2008, to December 19, 2012 and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the affected vehicles, water may drip onto the joint that connects the wiper linkage to the wiper motor.

Consequence & remedy

Consequence: Over time, the dripping water may cause corrosion and wear at the joint, potentially resulting in the separation of the wiper linkage. Once this occurs, the wipers would not function, reducing driver visibility and increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will replace the water diverter channel. In addition, a new wiper linkage with a wiper motor crank arm will be installed. The wiper linkage will have a protective cover over the wiper linkage joint to minimize water splash and a retainer ring to prevent the wiper arm from separating from the wiper motor. The recall began on November 7, 2016. Owners may contact Toyota's customer service number at 1-800-331-4331.

14V743000 · Seats:front Assembly:seat Heater/cooler

Nov 19, 2014

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Consequence & remedy

Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

13V383000 · Suspension:rear

Aug 28, 2013

Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.

Consequence & remedy

Consequence: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.

13V123000 · Equipment:other:labels

Apr 9, 2013

Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.

Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

13V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats

Jan 16, 2013

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Consequence & remedy

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Additional source detail variants (2)

Air Bags:frontal:sensor/control MODULE-INACTIVE

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Seats

12V373000 · Suspension:rear

Aug 2, 2012

Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.

Consequence & remedy

Consequence: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.

11V113000 · Vehicle Speed Control:accelerator Pedal

Feb 24, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

10V035000 · Equipment:other:labels

Feb 3, 2010

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

10V036000 · Equipment:other:labels

Feb 3, 2010

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

10V017000 · Vehicle Speed Control:accelerator Pedal

Jan 21, 2010

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.

Consequence & remedy

Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ10003 · Unintended And Uncontrolled Acceleration

Opened Feb 16, 2010 · Closed Mar 1, 2011

Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Additional source detail variants (6)

Electrical System:software

Vehicle Speed Control:accelerator Pedal

Go deeper into Toyota RAV4 problems

Toyota RAV4 transmission problems →Toyota RAV4 electrical problems →