← New search

2004 Toyota RAV4

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2004 Toyota RAV4 do not stand out strongly from the model-year median of 258.5.

About this comparison →

When problems were reported

Mileage at the reported incident

91 reports with mileage · 63 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Vehicle Speed Control. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

16 crash reports4 fire reports11 injury reports

Unknown Or Other complaints

6 reports
Clear category filter
Mileage unknown · Oct 29, 2024
Power TrainService BrakesUnknown Or Other

I was driving on a highway, there was a red light and I pressed on the brakes. The car kept going forward, the brakes became resistant to any pressure and the car continued to roll forward. There were no warning lights when the car was started or during the incident. I kept trying to brake the car, but the car kept moving forwar…

Read full complaint

I was driving on a highway, there was a red light and I pressed on the brakes. The car kept going forward, the brakes became resistant to any pressure and the car continued to roll forward. There were no warning lights when the car was started or during the incident. I kept trying to brake the car, but the car kept moving forward and was about to hit the car in front of me. The cars around me started honking, trying to move out of the way; Luckily the light turned red and the car in front of me was able to move out of the way. I could not press on the gas or the break, I decided to turn the ignition off and the car was able to turn off. I re-started the car and then was able to go again. Had this been on the highway and I was moving at a faster speed, I probably wouldn't be typing this right now and would be in the ER with potentially others. This is the second time an issue like this happened. The first time the car was in reverse and it wouldn't brake and I almost slammed into the car behind me. The brakes and gas were not responsive. I took it to a mechanic right away, got new brakes, rotors, engine and transmission was checked. A couple months later this happened again.

NHTSA ODI #11622621

Mileage unknown · Aug 21, 2024
Electrical SystemPower TrainUnknown Or Other

10 days ago transmission on 2004 Rav started to act funny. Slow/jerky to engage in lower gears. Check engine lights came on. Checked out by mechanic who said it looked like a transmission problem and should have it looked at by transmission specialist who said it was not safe to drive as is since it could simply die at any t…

Read full complaint

10 days ago transmission on 2004 Rav started to act funny. Slow/jerky to engage in lower gears. Check engine lights came on. Checked out by mechanic who said it looked like a transmission problem and should have it looked at by transmission specialist who said it was not safe to drive as is since it could simply die at any time, and it needed a new transmission. When replacing trans, the trans man found the ECM had to be replaced. He said this often happened with 2003 thru 2005 RAV4s. On looking through your site, discovered others had similar issues with their 2004 Ravs. I also found out that the electronic control module for these vehicles is defective and must be repaired to correct the transmission issues. What did Toyota have to say when you looked into this, or do you not think it’s a safety issue?

NHTSA ODI #11610035

136,000 miles · Sep 19, 2016
Unknown Or Other

THE DRIVER'S SIDE VISOR WILL NOT STAY UP. COMES DOWN AND BLOCKS VIEW.

NHTSA ODI #10908054

155,000 miles · Jul 9, 2016
Unknown Or Other

WHEN ACCELERATING FROM STOPPED POSITION THE CAR HESITATES, MOVES VERY SLOWLY, THEN WITH ADDED PRESSURE ON GAS PEDAL JERKS AS IT SHIFTS INTO SECOND GEAR, AFTER THAT IT SEEMS TO RUN FINE. CHECK ENGINE LIGHT AND VSC TRAC LIGHTS ARE ON. THIS IS VERY DANGEROUS WHEN ENTERING A BUSY ROAD OR IN HEAVY TRAFFIC.

NHTSA ODI #10883741

56,000 miles · Apr 10, 2010
Unknown Or OtherFire

2004 TOYOTA RAV4 L - DRIVING ABOUT 25 MPH, NO DASH WARNING LIGHTS ON, SMOKE STARTED COMING INTO CABIN, WITHIN LESS THAN A MINUTE FIRE SHOOTING OUT FROM UNDER HOOD. TOTALLY ENGULFED IN FLAMES IN LESS THAN 3 MINUTES. REGULAR SERVICE DONE AT TOYOTA DEALER. *TR

NHTSA ODI #10324813

Mileage unknown · Apr 8, 2005
Unknown Or Other

CONSUMER WAS SHOCKED AS HE EXITED THE 2004 TOYOTA RAV4.*MR THE CONSUMER IS CONCERNED THAT THIS COULD CAUSE A FIRE IF IT OCCURS AT A GAS STATION. *NM

NHTSA ODI #10117656

Official recalls

2

19V741000 · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

Oct 17, 2019

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

Additional source detail variants (2)

Air Bags:frontal:passenger Side:inflator Module

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

Air Bags:frontal:driver Side:inflator Module

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

15V284000 · Air Bags:frontal:driver Side:inflator Module

May 13, 2015

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2005 Toyota RAV4 vehicles manufactured May 13, 2003, to October 25, 2005. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify owners, and dealers will replace the driver's frontal air bag, free of charge. Owners were mailed an interim notice June 17, 2015. The recall began on August 21, 2015. Owners may contact Toyota customer service at 1-800-331-4331.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.

Go deeper into Toyota RAV4 problems