Air Bags. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

16 crash reports4 fire reports11 injury reports

Structure complaints

4 reports

Clear category filter

132,570 miles · Jul 17, 2014

Structure

Read full complaint

THIS 10 YEAR OLD CAR HAD BEEN GARAGED ITS ENTIRE LIFE. IT WAS DRIVEN 4 OR 5 TIMES A WEEK IN NORTHERN NEW HAMPSHIRE. THE FRONT CROSS MEMBER WHICH SUPPORTS THE ENGINE AND THE TRANSMISSION AND HOLDS THE WHEELS ON RUSTED TO THE POINT WHERE THERE WERE LARGE HOLES IN THE FRAME. TOYOTA OF BUTTE MONTANA AND TOYOTA OF WENATCHEE WASHINGTON BOTH REQUIRED THAT I SIGN A STATEMENT THAT I UNDERSTOOD THE CAR WAS UNSAFE TO DRIVE BECAUSE THE FRAME MEMBER WAS TOO RUSTED. TOYOTA OF WENATCHEE DID NOT WANT ANYONE EVEN STANDING UNDER IT. TOYOTA OF WENATCHEE OFFERED $1000 TOWARDS $2900 IN REPAIRS BUT REQUIRED THAT ALL THE REPAIRS BE DONE THROUGH THEM. I HAD THE CROSS MEMBER REPLACED AND THE OTHER REPAIRS DONE ELSEWHERE FOR $1200. TOYOTA CORPORATE REFUSED ANY ASSISTANCE AND SEES NO NEED OF A RECALL. I BELIEVE THERE SHOULD BE A RECALL OF THESE VEHICLES IN HIGH SALT AREAS (LIKE NORTHERN NEW HAMPSHIRE). I HAVE PICTURES OF THE CROSS MEMBER. *TR

NHTSA ODI #10611304

80,764 miles · Jun 18, 2013

StructureVehicle Speed ControlCrash

Read full complaint

I ENTERED MY CAR IN THE HOME GARAGE WHILE COASTING AND THE CAR SUDDENLY ACCELERATED AS I APPROACHED ABOUT 5 FEET WITHIN MY PARKING SPOT. AFTER THE CAR SUDDENLY ACCELERATED, IT WAS A MATTER OF SECONDS BEFORE THE CAR CRASHED INTO A FLOOR CABINET AND REFRIGERATOR THAT RESTS AGAINST OUR GARAGE WALL STOPPING THE CAR'S FORWARD MOVEMENT AND ALLOWING ME PUT THE CAR IN THE DRIVE GEAR AND TURN OFF THE ENGINE. THE AIR BAGS DID NOT DEPLOY AND FORTUNATELY I WAS NOT INJURED. THE CRASH CAUSED EXTENSIVE DAMAGES TO THE FRONT OF THE CAR, BOTH FRONT SIDE FENDERS, DRIVER AND PASSENGER DOORS, THE GARAGE WALL, FLOOR CABINET AND REFRIGERATOR. THERE MAY BE ADDITIONAL INTERNAL DAMAGE UNDER THE HOOD BUT AT THIS POINT THAT HAS NOT BEEN DETERMINED. THE CAR DAMAGES ARE SO EXTENSIVE THAT IT MAY BE A TOTAL LOSS. OBVIOUSLY, I'M VERY DISAPPOINTED BY THIS INCIDENT AND WILL NOT TRUST THE CAR IN THE FUTURE. I PROMPTLY REPORTED THIS TO MY INSURANCE CO. AND FILED AN INCIDENT WITH TOYOTA AND REQUESTED THAT THEY PERFORM A ROOT CAUSE ANALYSIS. *TR

NHTSA ODI #10520467

1,000 miles · May 7, 2013

Power TrainStructureCrash

Read full complaint

I WAS STARTING TO MAKE A K-TURN IN A PARKING LOT. I PUT ON THE BRAKES TO SHIFT INTO REVERSE. I MOVED BACK IN REVERSE A LITTLE BIT. THEN I STOPPED THE CAR AND PUT IT IN DRIVE, WHEN THE CAR SUDDENLY LURCHED FORWARD OUT OF MY CONTROL CRASHING INTO A GARBAGE DUMPSTER, FRIGHTENING ME AND DAMAGING MY VEHICLE SEVERELY. I AM CERTAIN I DID NOT GIVE THE CAR ANY GAS TO MAKE IT GO FORWARD AND CAUSE THAT ACCIDENT. I FEEL VERY FORTUNATE THAT I SUFFERED ONLY MINOR ACHES AND PAINS AS I WAS 75 AT THE TIME. I STILL OWN THE RAV4 AND HAVE HAD NO OTHER ACCIDENTS OR PROBLEMS SINCE THAT TIME. NOW THAT I SEE THERE ARE RECALLS ON LATER YEAR VEHICLES, I WONDER ABOUT THE SAFETY OF THE 2004 RAV4. I HOPE NHTSA CAN HELP ME. *TR

NHTSA ODI #10510953

1,900 miles · Jan 24, 2004

Structure

NEW 2004 RAV4 SUFFERS COWL RATTLE WHEN TEMPERATURE IS BELOW 25F AND THE COWL AREA IS DRY. THIS SEEMS TO BE A NEW PROBLEM FOR THE 2004 RAV4 FOR THE DEALER HAS NO CLUE HOW TO FIX IT. PLEASE INVESTIGATE. *LA

NHTSA ODI #10054810

Official recalls

19V741000 · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

Oct 17, 2019

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

Additional source detail variants (2)

Air Bags:frontal:passenger Side:inflator Module

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

Air Bags:frontal:driver Side:inflator Module

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

15V284000 · Air Bags:frontal:driver Side:inflator Module

May 13, 2015

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2005 Toyota RAV4 vehicles manufactured May 13, 2003, to October 25, 2005. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify owners, and dealers will replace the driver's frontal air bag, free of charge. Owners were mailed an interim notice June 17, 2015. The recall began on August 21, 2015. Owners may contact Toyota customer service at 1-800-331-4331.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.

Go deeper into Toyota RAV4 problems

Toyota RAV4 transmission problems →Toyota RAV4 electrical problems →