2001 Toyota RAV4

I HAVE A TOYOTA RAV 4 4WD 2001 MODEL. AT 47,000 MILES I HAD AN ENGINE REPLACEMENT DONE BY LYNCH TOYOTA UNDER WARRANTY. 25,000 MILES LATER VEHICLE WAS DIAGNOSED WITH A CRACKED FLEX PLATE. REPAIR WAS DONE BY AAMCO AND IN THEIR WRITTEN REPORT THEY STATE THAT DUE TO AN ALIGNMENT DOWEL THAT WAS CUT OFF WHEN LYNCH REPLACED THE ENGINE, THE ENGINE BECAME MISALIGNED AND THE FLEX PLATE CRACKED. IN ADDITION THE TORQUE CONVERTER ALSO HAD TO BE REPLACED. THE REPORTS WERE HANDED TO LYNCH AND THEIR SERVICE MANAGER DOES NOT ACCEPT RESPONSIBILITY FOR THIS AND REPORTED THAT THE CRACKED FLEX PLATE WAS MORE THAN LIKELY DUE TO POOR MATERIALS. I STILL HAVE THE FLEX PLATE AND WOULD LIKE TO KNOW IF THERE IS A WAY TO HAVE IT CHECKED TO FIND OUT IF INDEED IT WAS MADE FROM POOR MATERIALS. AAMCO DON'T APPEAR TO BELIEVE THIS TO BE THE CASE. *TR

I HAVE NOT HAD AN ACCIDENT OR INJURIES TO WHAT MY COMPLAINT IS ABOUT. I PERSONALLY THINK THIS IS A SAFETY ISSUE. I DRIVE A 2001 TOYOTA RAV4 AND RECENTLY STARTED HAVING SHIFTING ISSUES. I STARTED TO RESEARCH THIS ISSUE AND CAME ACROSS THIS WEBSITE CALLED CARCOMPLAINTS.COM AND FOUND MANY OTHERS WITH THE SAME ISSUE. TOYOTA IS AWARE OF THE PROBLEMS BECAUSE THEY CAME OUT WITH A TSB IN 2006. WHEN YOU COME TO A COMPLETE STOP AND THEN GO TO DRIVE THE CAR FORWARD THE VEHICLE DOESN'T SHIFT PROPERLY THEREFORE COULD BE A SAFETY ISSUE WITH NOT BEING ABLE TO MOVE OUT OF THE WAY OF ON COMING TRAFFIC. PLEASE VISIT THIS WEBSITE AND SEE THE AMOUNT OF PEOPLE HAVING THE SAME ISSUES AND I LIKE MANY OTHERS FEEL THERE IS A DEFECTIVE ECM IN THESE VEHICLES SENDING FAULTY SIGNALS TO THE TRANSMISSION CAUSING THE VEHICLE TO NOT SHIFT PROPERLY AND COULD POTENTIALLY CAUSE ACCIDENTS. THE OTHER PROBLEM IS THAT THIS IS NOT HAPPENING ALL THE TIME, ITS SPORADIC AND EVEN THE DEALER IS HAVING DIFFICULTY DUPLICATING THE PROBLEM. I HOPE MORE PEOPLE MAKE COMPLAINTS AND I WOULD BE INTERESTED IN SEEING HOW MANY HAVE. THANKS! *TR

TRANSMISSION SLIPPING ON 2001 TOYOTA RAV4. SERVICE BULLETIN ISSUED REQUIRING REPLACEMENT OF COMPUTER TO FIX THIS PROBLEM. BULLETIN EXTENDED WARRANTY TO 80,000. CONSUMER NEVER NOTIFIED OF THIS PROBLEM. COMPUTER WENT BAD AT 87,000 MILES. TOYOTA AND CONSUMER CURRENTLY GOING ROUND AND ROUND OVER WHETHER TOYOTA OR CONSUMER MUST PAY FOR COMPUTER REPLACEMENT. CONSUMER ALSO TOLD THAT TRANSMISSION MAY NOW NEED TO BE REPLACED. TOYOTA HAS RECEIVED NUMEROUS COMPLAINTS ABOUT THIS PROBLEM FROM RAV4 OWNERS AND IN MANY CASES THE SHIFT PROBLEMS RELATED TO THE COMPUTER FAILURE HAS RESULTED IN DAMAGE TO TRANSMISSION WHICH TOYOTA WILL NOT PAY FOR. *TR

TL*- THE CONTACT STATED THAT WHILE DRIVING THE 2001 TOYOTA RAV 4 AT 65 MPH (WITH 80000 FAILURE MILEAGE THE VEHICLE BEGAN TO MAKE A CLINKING NOISE. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND TURNED THE VEHICLE OFF. THE VEHICLE WOULD NOT RESTART. THE VEHICLE WAS TOWED TO A MECHANIC, WHO STATED THAT THERE WAS A SLUDGE BUILD UP, AND THE TRANSMISSION HAD TO BE REPLACED. *AK

2001 RAV4 MANUAL TRANSMISSION - THE GEAR SHIFT STARTED MOVING BACK AND FORTH IN THE 5TH GEAR POSITION WHEN PRESSURE WAS APPLIED/RELEASED FROM THE GAS PEDAL. WENT TO BALISE TOYOTA IN WEST SPRINGFIELD, MA AND WAS TOLD THAT THIS WAS NORMAL BEHAVIOR (EVEN THOUGH I HAD THE CAR FOR 5 YEARS AND IT JUST STARTED HAPPENING. ABOUT A WEEK LATER, THE CAR STARTED "POPPING" OUT OF 5TH GEAR. BALISE THEN ADMITTED THAT THIS WAS NOT NORMAL AND "REPAIRED" THE PROBLEM (THERE WAS A SERVICE BULLETIN FROM TOYOTA OUT ABOUT THE PROBLEM). WHEN I GOT THE CAR BACK, THE GEARSHIFT DID NOT MOVE WHEN IN 5TH GEAR. IT IS NOW DECEMBER AND THE GEARSHIFT IS ONCE AGAIN MOVING BACK AND FORTH IN 5TH GEAR AND BALISE TOYOTA IS TELLING ME IT IS NORMAL AND THEY REFUSE TO FIX THE PROBLEM WHILE THE CAR IS STILL UNDER THE EXTENDED WARRANTY. THERE ARE OTHER PEOPLE ON THE INTERNET WHO HAVE REPORTED THIS SAME PROBLEM. TOYOTA SHOULD HAVE A RECALL TO FIX THE PROBLEM AS HAVING A CAR DROP OUT OF GEAR IS A SAFETY HAZARD, ESPECIALLY AT HIGHWAY SPEEDS WHEN IT WOULD BE MOST APT TO HAPPEN. *NM

VEHICLE EXHIBITS INTERMITTENT HESITATION UPON ACCELERATION FROM STOP OR LOW SPEED.HESITATION HAS OCCURRED SINCE SHORTLY AFTER VEHICLE PURCHASE DATE, WITH INCREASED FREQUENCY DURING LAST 60-90 DAYS. HESITATION OCCURS BOTH WITH AIR CONDITIONONG ON AND OFF, AND WITH 4-SPEED AUTOMATIC TRANSMISSION OVERDIVE ON AND OFF. 2-3 OCCURRENCES PER WEEK ARE CURRENTLY EXPERIENCED. MOST FREQUENT WHEN VEHICLE IS MAKING SLOW TURN (BOTH RIGHT AND LEFT) AND LASTS 5-10 SECONDS EVEN IF ACCELERATOR IS NEARLY FULLY DEPRESSED. HESITATION HAS ALSO OCCURRED WHEN MOVING STRAIGHT AHEAD FROM STOP OR FROM LOW SPEED (5-10 MPH) STOP AND GO TRAFFIC. DEALER HAS BEEN NOTIFIED AND COULD NOT REPLICATE PROBLEM OR OFFER A SOLUTION, HOWEVER VEHICLE WAS DRIVEN FOR ONLY A SHORT TIME BY DEALER'S SERVICE TECHNICIANS. DEALER INDICATES NO REPORT OF SIMILIAR PROBLEMS EITHER AT THIS DEALERSHIP OR TO TOYOTA USA ALTHOUGH I KNOW OF OTHER 2001 RAV4 OWNERS WHO HAVE REPORTED A HESITATION PROBLEM TO THEIR DEALERS AND HAVE NOT HAD THE PROBLEM RESOLVED. WHILE THIS PROBLEM IS INTERMITTENT, THIS IS,IN SOME WAYS, WORSE THAN IF IT HAPPENED EVERY TIME BECAUSE THERE IS NO WAY TO PEDICT THE EVENT AND COMPENSATE FOR IT.*AK