2001 Toyota RAV4

TRANSMISSION SLIPPING ON 2001 TOYOTA RAV4. SERVICE BULLETIN ISSUED REQUIRING REPLACEMENT OF COMPUTER TO FIX THIS PROBLEM. BULLETIN EXTENDED WARRANTY TO 80,000. CONSUMER NEVER NOTIFIED OF THIS PROBLEM. COMPUTER WENT BAD AT 87,000 MILES. TOYOTA AND CONSUMER CURRENTLY GOING ROUND AND ROUND OVER WHETHER TOYOTA OR CONSUMER MUST PAY FOR COMPUTER REPLACEMENT. CONSUMER ALSO TOLD THAT TRANSMISSION MAY NOW NEED TO BE REPLACED. TOYOTA HAS RECEIVED NUMEROUS COMPLAINTS ABOUT THIS PROBLEM FROM RAV4 OWNERS AND IN MANY CASES THE SHIFT PROBLEMS RELATED TO THE COMPUTER FAILURE HAS RESULTED IN DAMAGE TO TRANSMISSION WHICH TOYOTA WILL NOT PAY FOR. *TR

FAILED ECM RESULTS IN THE CAR STARTING IN THE WRONG GEAR AND HESITATING WHEN SWITCHING GEARS. DRIVING THE CAR WITH THIS ECM FAILURE CAUSES VISIBLE DAMAGE TO THE TRANSMISSION WITHIN LESS THAN 100 MILES OF DRIVING AND MAKES THE DRIVER UNABLE TO BE CONFIDENT THAT THEIR CAR WILL SHIFT INTO GEAR WHEN NECESSARY, WHICH IS ESPECIALLY DANGEROUS ON LEFT TURNS IN HIGHLY TRAFFICKED AREAS. ONE DEALERSHIP (COBB COUNTY TOYOTA, KENNESAW, GA) REFUSED TO REPLACE THE ECM EVEN THOUGH A TSB ISSUED BY TOYOTA STATED IT SHOULD BE REPLACED WHEN THESE SYMPTOMS PERSISTED. TOYOTA USA REFUSED TO REPLACE THE TRANSMISSION EVEN THOUGH THE SHIFTING PROBLEMS CAUSED BY THE FAILING COMPUTER WILL ALMOST CERTAINLY DAMAGE THE TRANSMISSION. *CN

MY WIFE DROVE THE 2001 TOYOTA RAV 4 TO WORK THIS MORNING. IT WAS A 5 MILE DRIVE. AFTER PARKING THE CAR A FELLOW EMPLOYEE TOLD HER THE CAR WAS ON FIRE. THE FIRE DEPARTMENT RESPONDED AND PUT THE FIRE OUT. BUT THE CAR WAS A TOTAL LOSS. THE FIRE INSPECTOR LOCATED THE ORIGIN OF THE FIRE, ALONG THE FIREWALL DIRECTLY IN THE MIDDLE OF THE WALL, BUT SAID HE WAS UNABLE TO DETERMINE THE CAUSE. HE SAID NO ACCELERANT WAS USED, AND THAT THE FIRE WAS PROBABLY THE RESULT OF A CRACKED FUEL-LINE OR SOME OTHER FLUID LEAKING ONTO THE ENGINE. WE NOTICED NO FLUIDS LEAKED ONTO THE DRIVEWAY AT HOME. I AM POSTING THIS IN CASE ANY ONE ELSE HAD A SIMILAR SITUATION.*AK

DT*: THE CONTACT STATED WHILE ATTEMPTING TO ENTER THE HIGHWAY, WITH THE ACCELERATOR PEDAL APPLIED THE ENGINE REVVED, BUT DID NOT MOVE FORWARD. THE VEHICLE OPERATED AT A REDUCED SPEED IN A JERKING MOTION. THE VEHICLE WAS SEEN BY A DEALER FOR INSPECTION. THE DEALER DETERMINED THE COMPUTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS ALERTED.

DT: THE CONSUMER STATED THAT THE ENGINE LIGHT KEPT ILLUMINATING IN THE 2001 TOYOTA RAV 4. THE VEHICLE WAS TAKEN TO THE DEALERSHIP THREE TIMES. THE FIRST TIME THEY REPROGRAMMED THE COMPUTER, THE SECOND TIME THEY REPLACED THE OXYGEN SENSORS AND THE THIRD TIME THEY DETERMINED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE CONSUMER PLANNED TO REPLACE THE CATALYTIC CONVERTER IN THE FUTURE. CURRENTLY THE CONTACT WAS DRIVING THE VEHICLE WITH THE ENGINE LIGHT ON. THE VEHICLE WAS NOT DRIVING DIFFERENTLY. THE CONSUMER CONTACTED TOYOTA AND THEY URGED THE CONSUMER TO WORK WITH THE DEALER, AND MAYBE THEY WOULD HELP HER WITH THE COST. *AK (11/21/05) THE CONSUMER WAS AWARE OF OTHER SAME MAKE MODEL AND YEARS THAT HAVE EXPERIENCED THIS SAME PROBLEM. *SC

THE VEHICLE HAS A HESITATION DURING ACCELERATION MAKING IT DIFFICULT TO DETERMINE IF I CAN SAFELY MERGE INTO TRAFFIC. I TOOK THE VEHICLE TO THE DEALER ,AND THEY SAID THAT THEY HAD TO CLEAR THE ONBOARD COMPUTER'S MEMORY, AND THE PROBLEM SHOULD BE CLEARED UP. NOTHING WAS SAID ON HOW OR WHY THIS WOULD FIX THE PROBLEM BUT IT DID NOT. THE DAY AFTER THE CLEARING OF THE MEMORY THE VEHICLE DID THIS AGAIN. I WAS TOLD TO BRING IT INTO THE DEALER AGAIN FOR ANOTHER CLEARING OF MEMORY. WHAT MEASURES CAN I TAKE TO RESOLVE THIS ISSUE? I CANNOT BE EXPECTED TO BRING THIS IN EVERY WEEK. *AK

PREMATURE WEARING OF BRAKE PADS, MAKING VEHICLE HARD TO STOP. *AK THE VEHICLE MAKES NOISE. AT FIRST THE DEALER TURNED PADS, SECOND THE DEALER INSTALLED UPDATED FRONT BRAKE PADS, THEN REPLACED BOTH REAR DRUMS BUT THE PROBLEM REMAINS UNSOLVED. WHILE DRIVING WITH THE A/C FAN ON THERE WAS A VIBRATION IN DASH AREA. THE ROOF RACK SCREW WAS LOOSE AND FELL OUT. THE CENTER SEAT BELT WAS MISSING TRIM PIECE. THE REAR DOOR RATTLES WHILE CLOSING. *YH