NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
13 reportsClear category filterMileage unknown · Aug 4, 2014
Service BrakesService Brakes, Hydraulic
TL* THE CONTACT OWNS A 1998 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE BRAKES WERE APPLIED AND THERE WAS AN ABNORMAL NOISE. IN ADDITION, THE VEHICLE WAS DIFFICULT TO COME TO A STOP. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE FRONT DRIVER'S SIDE ROTOR WAS REPLACED. THE CONTACT STATED THAT THE …
Read full complaint
TL* THE CONTACT OWNS A 1998 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE BRAKES WERE APPLIED AND THERE WAS AN ABNORMAL NOISE. IN ADDITION, THE VEHICLE WAS DIFFICULT TO COME TO A STOP. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE FRONT DRIVER'S SIDE ROTOR WAS REPLACED. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN ANY RECALLS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE MILEAGE WAS UNAVAILABLE.
NHTSA ODI #10618588
120,000 miles · Apr 13, 2011
Service Brakes, Hydraulic
THE BRAKES FAILED TO WORK TWICE AND THE VEHICLE LURCHED FORWARD INSTEAD INTO DRIVE. THIS WAS AT LOW SPEED WHEN ATTEMPTING TO COME TO A COMPLETE STOP AT A RED LIGHT. WHEN THE FIRST BRAKING ATTEMPT FAILED, THE BRAKE WAS PUMPED A SECOND TIME AND IT FAILED TO STOP AND ACCELERATED INSTEAD. FIRM PRESSURE WAS APPLIED TO THE BRAKE …
Read full complaint
THE BRAKES FAILED TO WORK TWICE AND THE VEHICLE LURCHED FORWARD INSTEAD INTO DRIVE. THIS WAS AT LOW SPEED WHEN ATTEMPTING TO COME TO A COMPLETE STOP AT A RED LIGHT. WHEN THE FIRST BRAKING ATTEMPT FAILED, THE BRAKE WAS PUMPED A SECOND TIME AND IT FAILED TO STOP AND ACCELERATED INSTEAD. FIRM PRESSURE WAS APPLIED TO THE BRAKE PEDAL A THIRD TIME AND THIS DID PROMPT THE VEHICLE TO STOP BUT IT WAS CLOSE TO REAR-ENDING ANOTHER CAR ALREADY STOPPED AT THE LIGHT. *TR
NHTSA ODI #10395749
Mileage unknown · Sep 27, 2002
Service Brakes, Hydraulic
TS
NHTSA ODI #767830
Mileage unknown · Sep 28, 2001
Service Brakes, HydraulicUnknown Or OtherVehicle Speed ControlCrash
ENGINE LIGHT CAME 0N. CONSUMER APPLIED BRAKES, AND VEHICLE WENT FORWARD AND JUMPED CURB. CONSUMER'S VEHICLE HIT ANOTHER VEHICLE, AND LIGHT WENT OFF. NEXT DAY, DEALER CHECKED SYSTEM'S COMPUTER AND A SENSOR KICKED UP THE IDLER. SENSOR WILL HAVE TO BE REPLACED. CONSUMER WAS UNAWARE OF THE CAUSE, AND IF IT WAS AN INTERMITTE…
Read full complaint
ENGINE LIGHT CAME 0N. CONSUMER APPLIED BRAKES, AND VEHICLE WENT FORWARD AND JUMPED CURB. CONSUMER'S VEHICLE HIT ANOTHER VEHICLE, AND LIGHT WENT OFF. NEXT DAY, DEALER CHECKED SYSTEM'S COMPUTER AND A SENSOR KICKED UP THE IDLER. SENSOR WILL HAVE TO BE REPLACED. CONSUMER WAS UNAWARE OF THE CAUSE, AND IF IT WAS AN INTERMITTENT PROBLEM.*AK
NHTSA ODI #897021
Mileage unknown · Feb 20, 2001
Service Brakes, HydraulicVehicle Speed Control
WHEN APPLYING BRAKES PEDAL GOES TO FLOOR ,CAUSING EXTENDED STOPPING DISTANCE. ALSO, VEHICLE CONTINUES TO ACCELERATE AFTER BRAKES ARE APPLIED. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #880767
Mileage unknown · Jan 8, 2001
Service Brakes, HydraulicSuspension
REPLACED BRAKES 4 TIMES SINCE PURCHASE, PADS TWICE A YEAR, REPLACED ROTORS TWICE. BRAKES ARE ALWAYS SQEAKING. CURENTLY, STRUTS ARE LEAKING. *AK *SLC
NHTSA ODI #877601
Mileage unknown · Sep 5, 2000
Service Brakes, Hydraulic
WHILE PASSING A TRUCK BRAKES LOCKED UP. DEALER WAS CONTACTED . PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #869551
Mileage unknown · Sep 5, 2000
Service Brakes, HydraulicVehicle Speed Control
NO SUMMARY
NHTSA ODI #730266
Mileage unknown · Feb 1, 1999
Service Brakes, Hydraulic
BRAKES FAILED.
NHTSA ODI #609341
Mileage unknown · Feb 1, 1999
Service Brakes, Hydraulic
BRAKES SQUEAK. *YC
NHTSA ODI #607292
Official recalls
4Jan 22, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 1998-2000 RAV4, 1998-1999 RAV4 EV and Celica and 1997-1998 Supra vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant, and increases the risk of serious injury or death.
Remedy: Toyota will notify owners, and owners will have the option to self-inspect, or have a dealer inspect the steering wheel on their vehicle to determine if their vehicle may be equipped with an affected inflator. Potentially affected steering wheel serial numbers will be inspected by a dealer. Based on the inspection, dealers will replace the front driver air bag inflator with an alternate one, as necessary. These repairs will be performed free of charge. The recall began August 28, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall is 20TB01 and 20TA01.
Aug 9, 2000
VEHICLE DESCRIPTION: SPORT UTILITY ELECTRIC VEHICLES. IF THE SUBJECT VEHICLES ARE REPEATEDLY PARKED BY PLACING THE SHIFT LEVER INTO THE "P" POSITION WITHOUT APPLYING THE PARKING BRAKE, THE PARKING LOCK ROD, A COMPONENT OF THE TRANSMISSION PARKING LOCK SYSTEM, COULD BREAK.
Consequence & remedy
Consequence: THIS CONDITION CAN RENDER THE SYSTEM INOPERATIVE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PARKING LOCK ROD.
Aug 9, 2000
VEHICLE DESCRIPTION: SPORT UTILITY ELECTRIC VEHICLES. THE FRONT DISC BRAKE ROTOR, WHEN EQUIPPED WITH STEEL WHEELS, CAN DEVELOP STRESS FRACTURES IF THE LUG NUTS ARE TIGHTENED WITH EXCESSIVE TORQUE.
Consequence & remedy
Consequence: THE DISC ROTOR COULD BREAK (WHERE IT MOUNTS TO THE WHEEL), RESULTING IN A LOSS OF BRAKING ACTION ON THAT WHEEL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DISC BRAKE ROTORS. IF THE VEHICLE IS EQUIPPED WITH STEEL WHEELS, TOYOTA WILL REPLACE THE FRONT DISC BRAKE ROTORS AND STEEL WHEELS WITH NEW DISC BRAKE ROTORS AND NEW ALUMINUM WHEELS. IN ADDITION A CAUTION LABEL THAT READS, "USE NEW GENUINE TOYOTA ALUMINUM WHEELS." WILL BE AFFIXED. VEHICLES ALREADY EQUIPPED WITH ALUMINUM WHEELS WILL ONLY REQUIRE CAUTION LABEL INSTALLATION.
Oct 19, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES, MINI VANS AND PASSENGER VEHICLES EQUIPPED WITH A THEFT DETERRENT SYSTEMS (TDS) SUPPLIED BY AUDIOVOX CORPORATION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS INTO THE VEHICLE'S IGNITION SWITCH AND THE VEHICLE'S IGNITION SWITCH WIRING HARNESS PLUGS INTO THE ALARM HARNESS TO COMPLETE THE CIRCUIT. A PERCENTAGE OF THE FEMALE TERMINALS USED IN THE ALARM CONNECTOR WERE FOUND TO BE DEFECTIVE, CAUSING AN 'OPEN CIRCUIT' CONDITION WHEN MATED TO THE MALE IGNITION SWITCH TERMINALS.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE INTERMITTENT PERFORMANCE OF THE VEHICLE'S ELECTRICAL COMPONENTS SUCH AS THE DASH WARNING LIGHTS AND/OR HVAC FAN SPEED CONTROLS. ALSO, THE VEHICLE MAY NOT RUN SMOOTHLY AND COULD STALL.
Remedy: DEALERS WILL INSPECT THE DATE CODE LABEL ON THE SECURITY SYSTEM HARNESS AND ANY DISPLAYING THE MANUFACTURING/FINAL DATE CODE WILL BE REPLACED WITH NEWLY PRODUCED HARNESSES. THE DATE CODES ARE: RAV4 - 6/24/98, 6/25/98, 6/26/98; SIENNA - 6/25/98, 6/26/98; AND AVALON - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, AND 9/3/98.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration