IllustrationDT: THE CONTACT STATED THE DRIVER'S SIDE SEAT SHIFTED FORWARD AND BACKWARDS. ALSO, ENGINE CHECK LIGHT APPEARED. TOOK VEHICLE TO DEALER, WHO REPLACED GAS RECIRCULATION VALVE (EGR VALVE). *AK
1997 Toyota RAV4
Owner reports · Recalls · Investigations
Fewer warning signs than most model years
Owner complaints for the 1997 Toyota RAV4 are lower than the model-year median of 258.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all RAV4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 14 of 54 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports2 fire reports6 injury reports
Engine And Engine Cooling complaints
10 reportsMY RAV 4 - 57348 MILES. IT STARTED MAKING A TAPPING SOUND IN THE ENGINE AND IT HAS MAKES A METAL ON METAL VIBRATION UPON ACCELERATION AND ESPECIALLY WHEN I MAKE A GRADUAL LEFT TURN AND DECELERATE. I BROUGHT IT INTO THE DEALER. THEY SAY IT MAY BE THAT THE LIFTERS ARE A BIT WORN AND THAT THIS WILL NOT HARM ANYTHING. THIS IS ODD…
Read full complaint
MY RAV 4 - 57348 MILES. IT STARTED MAKING A TAPPING SOUND IN THE ENGINE AND IT HAS MAKES A METAL ON METAL VIBRATION UPON ACCELERATION AND ESPECIALLY WHEN I MAKE A GRADUAL LEFT TURN AND DECELERATE. I BROUGHT IT INTO THE DEALER. THEY SAY IT MAY BE THAT THE LIFTERS ARE A BIT WORN AND THAT THIS WILL NOT HARM ANYTHING. THIS IS ODD BECAUSE A NEW ENGINE WAS PLACED IN THE CAR AT 49,000 + MILES. THEY COULD NOT IDENTIFY WHAT THE VIBRATION NOISE WAS AND SAID THAT IT IS POSSIBLY A ROCK IN THE BRAKE SYSTEM. I KNOW WHAT THAT SOUNDS LIKE AND STRONGLY DISAGREE WITH THEIR ANALYSIS. THE NOISE IS DEFINITELY COMING FROM THE ENGINE. *NLM
MY RAV HAS HAD 2 ENGINE REPLACEMENTS THE FIRST AT 16,000 MILES AND THE SECOND AT 49,000 MILES. THE FIRST ONE HAPPENED WHEN IT STALLED OUT GOING THROUGH AN EXTREMELY LARGE PUDDLE OF WATER ON THE ACCESS ROAD AND THE SECOND FOR NO APPARENT REASON. *NLM
WHILE VEHICLE WAS AT IDLE AND WITH NO WARNING THE VEHICLE WILL STALL, CAUSING CONSUMER TO PULL OVER. DEALER WILL BE NOTIFIED. *AK
PROBLEM OF STALLING AND VEHICLE ACCELERATION ONGOING SINCE JUNE..NOW AUGUST AND BACK TO DEALER AGAIN AS THIS IS VERY DANGEROUS IN TRAFFIC ESPECIALLY WITH CHILDREN IN VEHICLE..
THE CAR HAS A STALLING PROBLEM. I HAVE TAKEN BACK TO THE DEALERSHIP TWICE FOR THIS PROBLEM. THE CAR INITIALLY JUST HAD A STARTING PROBLEM WHERE IT WILL START AND STALLS IMMEDIATELY. THE LAST TIME I TOOK IT TO THE DEALERSHIP THEY TOLD ME IT THE STARTER AND I HAD IT REPLACED, BUT IT IS STILL DOING THE SAME THING. IT DOES NOT MA…
Read full complaint
THE CAR HAS A STALLING PROBLEM. I HAVE TAKEN BACK TO THE DEALERSHIP TWICE FOR THIS PROBLEM. THE CAR INITIALLY JUST HAD A STARTING PROBLEM WHERE IT WILL START AND STALLS IMMEDIATELY. THE LAST TIME I TOOK IT TO THE DEALERSHIP THEY TOLD ME IT THE STARTER AND I HAD IT REPLACED, BUT IT IS STILL DOING THE SAME THING. IT DOES NOT MATTER IF THE CAR IS COLD OR WARM. I COULD JUST PULL INTO A GAS STATION AND IT WON'T START. IF I WAIT ABOUT TEN MINUTES, IT WILL START AGAIN. BUT, I HAVE NO IDEA WHEN THIS WILL HAPPEN. YESTERDAY, DRIVING ON THE HIGHWAY GOING ABOUT 60MPH THE CAR JUST STALLED. I WAS LUCKY ENOUGH TO BE ABLE TO DRIFT TO THE SHOULDER. I WAITED ABOUT TEN MINUTES AND IT STARTED AGAIN. THERE IS NO RHYME OF REASON TO THIS, THERE IS NO WARNING OF ANY KIND.
POSSIBLE ENGINE FAILURE CAUSED THE VEHICLE TO CRANK BUT NOT START.
ENGINE FAILED CAUSING VEHICLE NOT TO START.
WHILE DRIVING VEHICLE ON FREEWAY ABOUT 80 MPH HAD ATTEMPTED TO CHANGE LANES WHEN VEHICLE SUDDENLY STALLED OR DIED OUT FOR NO REASON IN HEAVY TRAFFIC; EVERYTHING WENT OUT. *AK
VEHICLE STALLS IN RAINY WEATHER.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.