2016 Toyota Prius

Starting in about 2019, the exterior black panel behind the rear right mirror began peeling. Soon, the blue exterior paint on the car began to show damaged spots, lining up with the parts of the car most exposed to the sun: the roof most of all, but the top panel behind the rear window and the top of the trunk showing signs of damage as well. The beginnings of this damage are also appearing on a couple of parts of the side doors, making it clear that the underlying problem applies to all of the blue exterior paint. It seems as if the exterior layer - some sort of sealant or finish - is not holding up properly in the sun. By contrast, our red-painted 2014 Prius, which has been exposed to the same conditions but for a longer period of time - shows none of this damage. The damage is quite extensive and visible, and it's unclear to what extent the protective qualities of the paint are now compromised. The service department at the dealership has inspected the paint, as has a third-party shop, and all agree that there is a serious paint problem. The issue is available for further inspection. The safety issue here is the potential for corrosion of the body due to the compromised paint integrity.

The contact owns a 2016 Toyota Prius. The contact stated while driving at approximately 70 MPH, the steering wheel stopped operating and the vehicle began to shut down. The contact stated that a yellow blinking light and a hybrid system malfunction warning light illuminated the instrument panel. The vehicle was taken to an independent mechanic where it was diagnosed that the hybrid battery was low and there was a failure of the engine wiring harness. The hybrid battery was able to recharge but the dealer stated that the electric wiring harness needed to be replaced. The vehicle was not repaired. A dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 159,141.

Coolant is leaking. There were no indicator that coolant is low. Suddenly while trying to get on the freeway the car would not get up to speed regardless how much pressure was put on the pedals. On the way back home, all of a sudden the engine temperature light flashed on then off twice. The car operated like normal but it was still concerning and we had it checked out. Coolant was leaking but no where to be found? It seems Toyota had previous recalls where coolant was leaking into the engine. I think my model is also affected.

I reported issues with this car in 2018. Clicking sounds under the car which is still happening, peeling paint on exterior and inside door areas, substandard windshield that spread in a very unusual pattern when hit by a small rock. The NHTSA ID Number that was assigned to these complaints is [XXX] . None of these problems have been addressed. There are other owners that have experienced the same problems, apparently their issues have not been addressed. These problems should have been sent by you to the Toyota Corporation, but apparently was not. I have owned many Toyota vehicles and have not experienced these problems. I also own a 2012 Toyota Prius which I drive when I when I am traveling on the interstate, because I feel that the clicking noises on the 2016 Toyota Prius is a safety issue that seems to be coming from the steering section underneath the car. When traveling the speed limit on the on Interstate highways, what would be the outcome if the steering mechanisms underneath the car did not work properly. It is a shame that this safety issue has not been addressed by you, and it is also a shame that I have to drive my older toyota at these times to feel safer when driving. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

We were driving kids to camp and the thermometer light went on. It was blinking for a while, then turned off and then turned steadily on. We weren't sure what to do, so we called our trusty mechanic who said "bring it in right now." We did and it turned out that this was a broken head gasket. Our car is regularly maintained by a trusted Prius mechanic and has less than 78K miles, despite its age. From our mechanic: We found the engine coolant was low in the radiator. We filled the system and pressure-tested, found no external leaks. The thermostat and fans operate normally. We found 54 ppm HCs in the radiator initially, and after a test-drive we re-checked and found 110 ppm HC in the radiator. Combustion chamber gas is getting into the cooling system, typically a symptom of headgasket failure. The cylinder head needs to be removed to evaluate. FYI this is the first headgasket failure we have seen on the 4th gen Prius, but it is the same engine designation as the 3rd gen Prius, which has a pattern problem of headgasket failure. The expectation is that the failure is the same, but we need to open the engine to evaluate. Given the low mileage, it might be worth pushing Toyota for a goodwill warranty even though it is out of the official powertrain warranty period. I called Toyota and they refused to pass along a goodwill warranty.

The contact owns a 2016 Toyota Prius equipped with Cooper Tires, Tire Line: Mastercraft, Tire Size: 195/65/15, DOT Number: (Not Available). The contacted stated that while driving approximately 65 MPH, the vehicle began to violently shake and vibrated. After stopping to inspect the vehicle, it was discovered that the passenger’s side rear tire had experienced sidewall steel belt separation. The cause of the failure was not determined. The local dealer and manufacturer were not notified of the failure. The failure mileage was approximately 20,000.

On September 2022 (at 46K) Dealer did TSB related fix on my 2016 Prius. PFA for service record. They replaced Exhaust Front Pipe, which is suggested work from Toyota PFA for Toyota Technical Bulletin. T-SB-0135-19 At 51,747 on March 1st 2023 around 8 40 am, while we are driving on highway at 70 mph suddenly Check Engine Light, Coolant light, Hybrid related lights were on Vehicle lost the control, speed was dropping luckily we could safely stop the vehicle on the shoulder no Vehicle hit us from behind. Sudden stop of engine while driving on highway at 51K miles is safety issue. Toyota dealer could not provide additional details except Engine is over heating.

Shortly after having my Toyota serviced, I had an engine coolant warning sign appear. I checked and noted the coolant was gone. I bought coolant and filled the coolant tank. A week later, I see the light again. I have seen no leakage at all on the ground. I refilled the coolant and checked again the next morning. Again the tank is empty. I took the car to a local reputable service person and thus far, he sees no leakage outside of the car. This suggests to him a bigger problem, where the coolant is going somewhere it should not. If it is to the engine, I will have to replace that!!