NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
9 reportsClear category filter98,500 miles · Dec 9, 2018
Structure
ON DECEMBER 8TH, 2018, I WAS DRIVING EASTBOUND ON INTERSTATE 10 IN PHOENIX, AZ AT APPROXIMATELY MILEPOST 141 AROUND 5:45 PM. SUDDENLY, I HEARD A LARGE, *BANG* WHICH SOUNDED LIKE A GUNSHOT. I IMMEDIATELY CHECKED MYSELF FOR INJURIES AND FELT THE CAR TO DETERMINE IF A TIRE WAS BLOWN. I WAS INTACT, AND THE TIRES SEEMED OK AS WELL…
Read full complaint
ON DECEMBER 8TH, 2018, I WAS DRIVING EASTBOUND ON INTERSTATE 10 IN PHOENIX, AZ AT APPROXIMATELY MILEPOST 141 AROUND 5:45 PM. SUDDENLY, I HEARD A LARGE, *BANG* WHICH SOUNDED LIKE A GUNSHOT. I IMMEDIATELY CHECKED MYSELF FOR INJURIES AND FELT THE CAR TO DETERMINE IF A TIRE WAS BLOWN. I WAS INTACT, AND THE TIRES SEEMED OK AS WELL, BUT I HEARD THE NOISE OF AIR ESCAPING FROM THE VEHICLE. AFTER TURNING SOUTH ON I-17, I EXITED ON THE FIRST STREET, EXIT 199, JEFFERSON ST. I TURNED LEFT AND LOOKED FOR A SAFE PLACE TO PULL OVER. IT ISN'T A GOOD NEIGHBORHOOD, SO I SLOWED DOWN AND CONTINUED TO LOOK AROUND THE VEHICLE AS I TRIED TO FIND THE PLACE WHERE THE AIR WAS ESCAPING. FINALLY, I CRACKED OPEN THE SLIDING DOOR AT THE TOP OF MY SUNROOF, AND I NOTICED SHARDS OF GLASS. I IMMEDIATELY CLOSED IT AND WAS RELIEVED IT HAD NOT BEEN OPEN WHEN THIS INCIDENT HAPPENED. I DECIDED I MUST GET HOME IMMEDIATELY, PROCEEDED BACK TO THE FREEWAY, AND DROVE HOME. WHEN I ARRIVED, I NOTICED THE SUNROOF WAS SHATTERED - ONE MAIN HORIZONTAL SHATTER AT THE CENTER AND TWO MORE VERTICAL SHATTERS AT EACH END. I CHECKED THE INTERIOR OF THE VEHICLE FOR A PROJECTILE AND FOUND NOTHING. AFTER RESEARCHING FURTHER, IT WAS CLEAR THAT THE GLASS HAD BROKEN SIMPLY DUE TO POOR DESIGN. I IMMEDIATELY FILED A CLAIM WITH MY INSURANCE COMPANY, FARMERS. THE CLAIM NUMBER IS 910380. I HAVE ALSO CONTACTED TOYOTA TO GET A RESPONSE, BUT I HAVE NOT HEARD BACK. I AM FORTUNATE THAT THE SUNROOF WAS NOT EXPOSED. THERE IS A PAPER-THIN SLIDING DOOR THAT BLOCKS THE SUN. EVEN THOUGH THE SUN HAD SET, I HAD LEFT IT CLOSED, AND IT PROTECTED ME FROM THE SHARDS OF GLASS. THIS IS CLEARLY A DEFECT THAT TOYOTA NEEDS TO ADDRESS. IT IS DECEMBER IN ARIZONA, AND THE TEMPERATURE WAS 69 DEGREES WHEN I LEFT TO RETURN HOME YESTERDAY. IT'S NOT A HEAT ISSUE. IT'S LIKELY A GLASS DEFECT. I LOOK FORWARD TO OBTAINING MORE INFORMATION.
NHTSA ODI #11157205
163,000 miles · Aug 28, 2017
Structure
THE LOWER WINDOW ON THE REAR HATCH SHATTERED WITHOUT WARNING.
NHTSA ODI #11020167
Mileage unknown · Feb 27, 2017
Structure
TL* THE CONTACT OWNS A 2011 TOYOTA PRIUS. THE CONTACT STATED THAT THE SOY BASED PLASTIC CABIN ENTRYWAYS WERE MISSING THE SCREENS. THE FAILURE ALLOWED RODENTS AND MICE TO ENTER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10957374
69,255 miles · Jul 10, 2015
Structure
TL* THE CONTACT OWNS A 2011 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 65 MPH, A SCRAPING TYPE NOISE WAS HEARD UNDER THE VEHICLE AND A BUMP WAS FELT. THE CONTACT DISCOVERED THAT THE FRONT DRIVER SIDE WHEEL WELL DISLODGED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE.…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 65 MPH, A SCRAPING TYPE NOISE WAS HEARD UNDER THE VEHICLE AND A BUMP WAS FELT. THE CONTACT DISCOVERED THAT THE FRONT DRIVER SIDE WHEEL WELL DISLODGED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 69,255. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10733102
62,000 miles · Apr 23, 2015
Structure
TL* THE CONTACT OWNS A 2011 TOYOTA PRIUS. WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN ABNORMAL NOISE OF MICE IN THE DASHBOARD. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MICE ENTERED THE VEHICLE THROUGH THE REAR UNDERCARRIAGE VENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA PRIUS. WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN ABNORMAL NOISE OF MICE IN THE DASHBOARD. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MICE ENTERED THE VEHICLE THROUGH THE REAR UNDERCARRIAGE VENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.
NHTSA ODI #10712423
32,000 miles · Sep 19, 2014
Service BrakesStructureCrash
THE PRIUS FAILED TO STOP WHEN BRAKES WERE APPLIED; INSTEAD THE CAR DID A LURCH WHEN THE BRAKES WERE APPLIED AND THEN ACCELERATED FORWARD CAUSING A 4 CAR COLLISION; LUCKILY NO ONE WAS INJURED. MADE TOYOTA AWARE OF THE PROBLEM, WHEN THEY INVESTIGATED THEY OF COURSE FOUND NOTHING WRONG WITH THE VEHICLE'S BRAKE SYSTEM. *TR
NHTSA ODI #10637465
29,100 miles · Jun 16, 2014
Service BrakesStructureCrash
WHILE PULLING INTO A PARKING SLOT IN A PARKING LOT, WHICH WAS ON A SLOPE, I APPLIED THE FOOT BRAKE WITHOUT ANY RESPONSE WHATSOEVER. THE VEHICLE GAINED ENOUGH SPEED TO JUMP THE SMALL STOP-CURB AND HIT A CONCRETE WALL NEXT TO IT. THE DAMAGE TO THE FRONT OF THE CAR WAS JUST OVER $4000. I THOUGHT I HAD MISSED THE PEDAL. ON JUNE …
Read full complaint
WHILE PULLING INTO A PARKING SLOT IN A PARKING LOT, WHICH WAS ON A SLOPE, I APPLIED THE FOOT BRAKE WITHOUT ANY RESPONSE WHATSOEVER. THE VEHICLE GAINED ENOUGH SPEED TO JUMP THE SMALL STOP-CURB AND HIT A CONCRETE WALL NEXT TO IT. THE DAMAGE TO THE FRONT OF THE CAR WAS JUST OVER $4000. I THOUGHT I HAD MISSED THE PEDAL. ON JUNE 12TH AND 15TH, I HAD TWO MORE INCIDENTS OF THE BRAKE PEDAL GOING ALL THE WAY TO THE FLOOR WHILE EITHER AT SLOW SPEED OR STOPPED. MY DEALER SAYS IT WAS A PROBLEM ON THE 2010, BUT HE HAS NOT SEEN IT ON A 2011. MY WIFE NOW REFUSES TO DRIVE THE CAR. *TR
NHTSA ODI #10598545
Mileage unknown · Jan 3, 2014
StructureInjury
UNNECESSARY MINOR INJURY PRODUCING DESIGN MY PRIUS, WHICH I LIKE, HAS SEVERAL TIMES GIVEN ME A MINOR BRUISE THAT LASTS FOR A COUPLE OF WEEKS. THE FRONT PASSENGER DOORS, AT THE BOTTOM CORNERS, END IN A SHARP RIGHT ANGLE. IN CONTRAST, MANY OTHER CAR DOORS HAVE A SLIGHTLY ROUNDED BOTTOM CORNER WHICH HAVE NEVER INJURED ME. A…
Read full complaint
UNNECESSARY MINOR INJURY PRODUCING DESIGN MY PRIUS, WHICH I LIKE, HAS SEVERAL TIMES GIVEN ME A MINOR BRUISE THAT LASTS FOR A COUPLE OF WEEKS. THE FRONT PASSENGER DOORS, AT THE BOTTOM CORNERS, END IN A SHARP RIGHT ANGLE. IN CONTRAST, MANY OTHER CAR DOORS HAVE A SLIGHTLY ROUNDED BOTTOM CORNER WHICH HAVE NEVER INJURED ME. AS I AM WALKING AROUND THE PRIUS, LOADING AND UNLOADING FOR EXAMPLE, THAT SHARP CORNER SEEMS TO CATCH MY SHIN AND BRUISE IT. I AM IN MY 70'S AND GUESS THAT THESE MINOR INJURIES ARE MORE LIKELY TO HAPPEN WITH CHILDREN AND SENIORS. IF THIS WAS A NEEDED ELEMENT OF DESIGN, THEN I WOULD NOT CALL THIS TO YOUR ATTENTION. HOWEVER IT SEEMS TO BE PRIMARILY POOR ERGONOMICS ON THE PART OF THE DESIGNER. IF THE INJURY POTENTIAL OF SHARP CORNERS WAS BROUGHT TO THE ATTENTION OF CAR MANUFACTURERS, PERHAPS, WHEN DESIGNS ARE CHANGED, THE SAFER CORNER COULD BE INCORPORATED AT ESSENTIALLY NO COST AND NUMBERS OF FUTURE MINOR INJURIES COULD BE AVOIDED. *TR
NHTSA ODI #10558365
7,400 miles · Oct 28, 2012
Service BrakesStructureCrash
WE PURCHASED A 10 MONTH OLD TOYOTA PRIUS ON MARCH 16ND 2012 WITH ONLY 1367 MILES. THE PRIOR OWNER WHO WAS LEASING THIS CAR RETURNED THE CAR DUE TO MILEAGE INCONSISTENCY..... ON OCT 5TH 2012, I WAS DRIVING ON SUNNY DRY DAY AT 22MPH THE VEHICLE IN FRONT OF ME SLOWED DOWN. I STEPPED ON THE BRAKE TO SLOWDOWN BUT THE CAR DID…
Read full complaint
WE PURCHASED A 10 MONTH OLD TOYOTA PRIUS ON MARCH 16ND 2012 WITH ONLY 1367 MILES. THE PRIOR OWNER WHO WAS LEASING THIS CAR RETURNED THE CAR DUE TO MILEAGE INCONSISTENCY..... ON OCT 5TH 2012, I WAS DRIVING ON SUNNY DRY DAY AT 22MPH THE VEHICLE IN FRONT OF ME SLOWED DOWN. I STEPPED ON THE BRAKE TO SLOWDOWN BUT THE CAR DID NOT STOP. WHEN I STEPPED ON THE BRAKE IT DID NOT RESPOND IMMEDIATELY, I APPLIED COMPLETE PRESSURE TO THE BRAKE HOWEVER THE CAR STILL DID NOT SLOW DOWN ENOUGH AND I HIT THE CAR IN FRONT OF ME. PER THE REPORT FROM TOYOTA THE SPEED WENT DOWN FROM 22MPH TO 5MPH AT THE TIME OF THE IMPACT. I DO NOT AGREE WITH THE TOYOTA REPORT THAT I ONLY STEPPED ON THE BRAKE FOR 2 SECONDS AS IT WAS MUCH MORE... BEFORE THE ACCIDENT THE BRAKE WAS MUCH HARDER AND LESS FORCEFUL PRESSURE MADE THE CAR STOP AFTER THE ACCIDENT THE BRAKE FEELS SOFTER AND MORE PRESSURE IS NEEDED TO MAKE THE BRAKE WORK. THIS IS AN ALMOST BRAND NEW CAR WITH 7K MILES ON IT HOWEVER I DO FEEL SAFE IN THIS CAR ANYMORE AFTER THIS ACCIDENT AND I FEAR FOR MY LIFE AND PUBLIC SAFETY. WHAT WILL HAPPEN I DRIVE ON A HIGHWAY AT 60MPH AND THE BRAKE WILL NOT WORK?? TOYOTA DENIES ANY TECHNICAL ERROR WITH THE CAR AND BLAMES THE ACCIDENT ON ME. THERE ARE PLENTY OF REPORTS OF SIMILAR ACCIDENTS REPORTED BY CONSUMERS ON THIS SAME ISSUE HERE: HTTP://TOWNHALL-TALK.EDMUNDS.COM/DIRECT/VIEW/.F0DB60B. *TR
NHTSA ODI #10482485
Official recalls
6Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
Illustration