NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
11 reportsClear category filterMileage unknown · Jan 15, 2026
Electrical SystemEngineFuel/propulsion System
I was driving my car at over 70 mph on a highway, no check engine, no issues, just had oil changed when check hybrid system alert came on with check engine light. I started to change lanes to get to shoulder when my car just died, completely. It died in the middle of the highway merging with another major road, so I was stuck be…
Read full complaint
I was driving my car at over 70 mph on a highway, no check engine, no issues, just had oil changed when check hybrid system alert came on with check engine light. I started to change lanes to get to shoulder when my car just died, completely. It died in the middle of the highway merging with another major road, so I was stuck between 2 lanes of 70mph traffic on either side. The time to react to the sudden warning to my car dying was less than 2 minutes. I quickly called 911 to ask for help and was told someone had already reported my breakdown as well because my car had died in a horribly dangerous area. I was very lucky that a state trooper came quickly and blocked off my car until it could be towed for repair. I was told that I need a new Hybrid Battery. The fact that I had no signs of failure before complete shut down makes for a very dangerous driving situation and makes me second guess ever buying a Prius again.
NHTSA ODI #11711067
Mileage unknown · Jul 8, 2023
Fuel/propulsion System
Hybrid system shut down. DC power converter shutting down. Car shut down on me in middle of road almost caused a crash. There was a recall in 2018 but I never received a notice and now as of 2023 there are no active recalls.
NHTSA ODI #11531034
115,000 miles · May 12, 2020
Fuel/propulsion System
WHILE DRIVING DOWN CITY STREET AT APPROX. 25 MPH, THE VEHICLE SUDDENLY LOST ALL POWER AND HAD TO BE EMERGENCY STEERED WITHOUT POWER STEERING TO THE SIDE OF THE ROAD, NARROWLY AVOIDING A CRASH. THE DASHBOARD SHOWED "CHECK HYBRID SYSTEM"; VEHICLE WAS INOPERABLE AND HAD TO BE TOWED. *TR
NHTSA ODI #11324344
130,000 miles · Jan 30, 2020
Fuel/propulsion SystemSteeringWheels
AFTER RECEIVING THE COMPUTER UPDATE MY FUEL MILEAGE HAS DROPPED 10 MILES. THE OTHER PROBLEM IN THE RATE OF TIRE WEAR AND PULL. I TOOK THE CAR IN FOR AN ALIGNMENT TO A TOYOTA DEALERSHIP BECAUSE IT WAS PULLING THEY TOLD ME THEY DID THE ALIGNMENT. AFTER I GOT MY CAR BACK IT WAS STILL PULLING I QUESTIONED THEM AND THEY SAID THAT WAS…
Read full complaint
AFTER RECEIVING THE COMPUTER UPDATE MY FUEL MILEAGE HAS DROPPED 10 MILES. THE OTHER PROBLEM IN THE RATE OF TIRE WEAR AND PULL. I TOOK THE CAR IN FOR AN ALIGNMENT TO A TOYOTA DEALERSHIP BECAUSE IT WAS PULLING THEY TOLD ME THEY DID THE ALIGNMENT. AFTER I GOT MY CAR BACK IT WAS STILL PULLING I QUESTIONED THEM AND THEY SAID THAT WAS NORMAL. THE LAST THING IS I GOT NEW TIRES PUT ON THE CAR AND HAD TO REPLACE THEM 10 MONTHS LATER BECAUSE THERE WAS ABOUT 15 PERCENT TREAD LIFE LEFT. THE TIRES WERE ROTATED PROPERLY.
NHTSA ODI #11303039
158,000 miles · Oct 18, 2019
EngineFuel/propulsion System
I WAS MAKING A LEFT TURN AT A VERY BUSY LOS ANGELES INTERSECTION AND DURING NEEDED ACCELERATION TO TURN, THE PRIUS LOST POWER FOR A FULL SECOND AND THEN POWER CAME BACK SLOWLY AND I BARELY MADE IT THROUGH THE INTERSECTION, A T BONE COLLISION WAS IMMINENT, AND I MISSED GETTING HIT BY INCHES. ALL THE WARNING LIGHTS ON THE DASH IL…
Read full complaint
I WAS MAKING A LEFT TURN AT A VERY BUSY LOS ANGELES INTERSECTION AND DURING NEEDED ACCELERATION TO TURN, THE PRIUS LOST POWER FOR A FULL SECOND AND THEN POWER CAME BACK SLOWLY AND I BARELY MADE IT THROUGH THE INTERSECTION, A T BONE COLLISION WAS IMMINENT, AND I MISSED GETTING HIT BY INCHES. ALL THE WARNING LIGHTS ON THE DASH ILLUMINATED AND I WAS FRAZZLED. THE HYBRID BATTERY WAS 2/3 RDS FULL AT THE TIME. THERE HAVE BEEN OTHER INSTANCES WHERE THE CAR LOST POWER FOR BRIEF MOMENTS WHEN THE HYBRID BATTERY WAS LOW AND DIDNT THINK ANYTHING OF IT AT THE TIME. THE MPG HAS REMAINED BELOW 40 AND AFTER HYBRID FAILURE, AROUND 26. ALSO, I HAD A GEN 2 PRIUS AND THE CATALYTIC CONVERTER WENT BAD AROUND 150,000. CALIFORNIA PUNISHES CONSUMERS BY NOT ALLOWING AFTER MARKET CATS AND FORCES THEM TO BUY OEM AT AN EXTREME MARK UP. WITHOUT A PROPER CAT, YOU CANT HAVE CAL SMOG APPROVAL, NO APPROVAL, NO REGISTRATION. TOTAL WASTE OF RESOURCE WHEN THE ACTUAL COST OF REPLACEMENT OF THE CAT IS AROUND $2K AT THE DEALER. IF I LIVED IN AZ, AFTER MARKET IS $475. AT THAT POINT A CAR OF THAT AGE AND MILAGE IS WORTH AROUND $2-3K. BATTERY AND CAT REPLACEMENT COSTS SHOULD NOT ECLIPSE THE VALUE OF THE CAR. STILL DOESN'T MENTION THE REST OF THE MECHANICAL AND SAFTEY APPARATUS . IF AN ENGINE WORKS HALF TIME ON A HYBRID, WHY DOES THE CAT BURN OUT SO SOOOON? THE SCAM IS BAKED INTO THE VEHICLE AND OUR GOVT SUPPORTS IT. FIX CARB!
NHTSA ODI #11269305
151,000 miles · Aug 9, 2019
Electrical SystemEngineFuel/propulsion System
WHILE DRIVING AT CA FREEWAY SPEED (65MPH) THE CAR GOES LIMP. THE ACCELERATOR FAILS TO WORK AND EVEN FLOORING THE VEHICLE MAKES NO DIFFERENCE. AT THIS POINT THE SPEED OF THE VEHICLE DECREASES AND I HAVE TO IMMEDIATELY PULL TO THE SHOULDER. THE "CHECK HYBRID SYSTEM" ALERT SHOWS ON THE DASH AND ALSO ELECTRIC POWER STEERING AND CHEC…
Read full complaint
WHILE DRIVING AT CA FREEWAY SPEED (65MPH) THE CAR GOES LIMP. THE ACCELERATOR FAILS TO WORK AND EVEN FLOORING THE VEHICLE MAKES NO DIFFERENCE. AT THIS POINT THE SPEED OF THE VEHICLE DECREASES AND I HAVE TO IMMEDIATELY PULL TO THE SHOULDER. THE "CHECK HYBRID SYSTEM" ALERT SHOWS ON THE DASH AND ALSO ELECTRIC POWER STEERING AND CHECK ENGINE LIGHT. THIS ISSUE HAS BEEN GOING ON FOR THE PAST YEAR AND I HAVE TAKEN IT TO SEVERAL TOYOTA DEALERSHIPS WITH NO RESOLVE. I HAVE SPENT A TOTAL OF $4500 WITHOUT TOYOTA OF VALLEJO OR THE NOW BANKRUPT TOYOTA OF FAIRFIELD SOLVING THE ISSUE. THIS IS A LIFE THREATENING ISSUE AND HAPPENED SEVERAL TIMES WITH CHILDREN IN THE VEHICLE. SHOW IN VIDEO: HTTPS://WWW.YOUTUBE.COM/WATCH?V=CA5HJRSNFSG
NHTSA ODI #11242826
115,000 miles · Dec 6, 2018
Fuel/propulsion SystemUnknown Or Other
TOYOTA AFTER 2 MONTHS HAS NOT RESOLVED THIS ISSUE/RECALL. SINCE THAT I HAVE TO STOP TO SHARE MY CAR ON TURO AND I'LL HAVE A LOST OF INCOME. I'M ASKING FOR A COMPENSATION
NHTSA ODI #11156577
113,000 miles · Oct 22, 2018
EngineFuel/propulsion SystemVehicle Speed Control
IN MOTION WHILE ACCELERATING PAST A SLOWER CAR. HEARD AND FELT A PRONOUNCED THUMP AND LOST ENGINE POWER ON BUSY LOCAL THOROUGHFARE. MOVED TO A TURN LANE AND STOPPED. MULTIPLE DASHBOARD LIGHTS AND "CHECK HYBRID SYSTEM" ON LED DISPLAY. POWER OFF CAR, AND BACK ON TWICE AND GOT THE SAME ERROR ON DISPLAY. FOUND THAT CAR COULD MO…
Read full complaint
IN MOTION WHILE ACCELERATING PAST A SLOWER CAR. HEARD AND FELT A PRONOUNCED THUMP AND LOST ENGINE POWER ON BUSY LOCAL THOROUGHFARE. MOVED TO A TURN LANE AND STOPPED. MULTIPLE DASHBOARD LIGHTS AND "CHECK HYBRID SYSTEM" ON LED DISPLAY. POWER OFF CAR, AND BACK ON TWICE AND GOT THE SAME ERROR ON DISPLAY. FOUND THAT CAR COULD MOVE ON EV POWER AND I GOT IT INTO A SAFER LOCATION AT AN ADJACENT PARKING LOT. HAD VEHICLE TOWED TO REPAIR FACILITY. AS A DRIVER THIS WAS DISCONCERTING AS I COULD NOT CLEARLY DETERMINE IF THE CAR WAS AT ALL DRIVEABLE. IF A DRIVER WERE TO STOP IMMEDIATELY IN THE SAME SITUATION THEY WOULD BE ON THE ROADWAY. IF I HAD NOT PRESSED ON THE ACCELERATOR PEDAL AFTER POWERING ON THE CAR AGAIN I WOULD NOT HAVE KNOWN I COULD MOVE THE CAR TO A SAFER LOCATION. DISPLAY SHOULD READ "HYBRID SYSTEM FAILURE" THEN "LIMITED EV POWER AVAILABLE" THEN "MOVE TO SAFE AREA IF NECESSARY" CAUSE: HYBRID INVERTER FAILURE. REPAIRED BY TOYOTA UNDER 2014 EOE AND NEW 10/2018 RECALL J0A
NHTSA ODI #11141949
58,000 miles · Sep 14, 2016
Fuel/propulsion System
TL* THE CONTACT OWNS A 2011 TOYOTA PRIUS. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS A FRACTURE IN THE FUEL TANK THAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTAC…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA PRIUS. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS A FRACTURE IN THE FUEL TANK THAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT THIS WAS A GLOBAL RECALL (TOYOTA/AUSTRALIA: FUEL SUCTION PLATE), BUT WAS NOT YET A RECALL IN THE UNITED STATES. THE FAILURE MILEAGE WAS 58,000.
NHTSA ODI #10906450
15,000 miles · Mar 19, 2014
Fuel/propulsion SystemService Brakes
MY CAR HESITATES TO STOP OR SLOW DOWN WHEN BRAKES ARE APPLIED DRIVING OVER A POTHOLE, SLICK SURFACE, METAL ROAD COVER OR A MANHOLE. INSTEAD OF SLOWING/STOPPING, THE CAR SEEMS TO EJECT FORWARD. I TOOK IT TO THE DEALERSHIP WHERE I BOUGHT MY CAR AND DROVE WITH A SERVICE TECH AND HE SAID IN OVER 20 YEARS OF HIS EXPERIENCE, HE'S …
Read full complaint
MY CAR HESITATES TO STOP OR SLOW DOWN WHEN BRAKES ARE APPLIED DRIVING OVER A POTHOLE, SLICK SURFACE, METAL ROAD COVER OR A MANHOLE. INSTEAD OF SLOWING/STOPPING, THE CAR SEEMS TO EJECT FORWARD. I TOOK IT TO THE DEALERSHIP WHERE I BOUGHT MY CAR AND DROVE WITH A SERVICE TECH AND HE SAID IN OVER 20 YEARS OF HIS EXPERIENCE, HE'S NEVER SEEN THIS. I TRIED TO EXPLAIN THAT THIS CAR (AND TECHNOLOGY WITH REGENERATIVE BRAKING) IS ONLY 3 YEARS OLD, BUT HE DIDN'T SEEM TO BUY MY COMPLAINT, NOR WERE WE ABLE TO REPRODUCE THIS ISSUE WHEN I DROVE WITH A TECHNICIAN AROUND THE BLOCK. THERE ARE SEVERAL ONLINE DISCUSSIONS REGARDING THIS PARTICULAR ISSUE : HTTP://MONEY.CNN.COM/2010/02/04/AUTOS/PRIUS_TIMELINE/?WPMP_SWITCHER=MOBILE HTTP://WWW.EETIMES.COM/AUTHOR.ASP?SECTION_ID=30&DOC_ID=1284377. *TR
NHTSA ODI #10573372
Official recalls
6Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
Illustration