IllustrationI WAS DRIVING ALONG ON THE FREEWAY TRYING TO GET HOME AND SUDDENLY MY PRIUS LOST POWER. I WAS PANICKING, GOOD THING I HAD MY BROTHERS WITH ME OR ELSE I WOULD HAVE LOST IT. WE DIDN'T KNOW WHAT WAS GOING ON! WE MANAGED TO GET OFF THE FREEWAY SAFELY, BUT WE WERE DISTRESSED.
2011 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2011 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
720–25K
4125–50K
4450–75K
5075–100K
74100–150K
49150K+
330 reports with mileage · 188 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 262 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports7 fire reports16 injury reports
Electrical System complaints
68 reportsJUNE 29TH 2018 WAS IN THE CAR WASH GOING THORUGH WHEN THE DASH BOARD PANEL SAID TRACTION BATTERY LOW PUT IN PARK THE BATTERY INDICATOR SHOWED ONE BAR LIGHT ON BUT I COULDNT PUT IT IN PARK FOR I WAS STILL GOING THORGH CAR WASH WHEN IT WAS DONE WASHING PUT CAR IN DRIVE AND IT WAS VERY SLOW IN DRIVING IT TOOK IT AWHILE TO COME …
Read full complaint
JUNE 29TH 2018 WAS IN THE CAR WASH GOING THORUGH WHEN THE DASH BOARD PANEL SAID TRACTION BATTERY LOW PUT IN PARK THE BATTERY INDICATOR SHOWED ONE BAR LIGHT ON BUT I COULDNT PUT IT IN PARK FOR I WAS STILL GOING THORGH CAR WASH WHEN IT WAS DONE WASHING PUT CAR IN DRIVE AND IT WAS VERY SLOW IN DRIVING IT TOOK IT AWHILE TO COME BACK UP IN POWER JULY 6TH TOOK IT TO LOCAL DEALER AND I THINK THEY THOUGHT I WAS NUTS THEY SAID THEY NEVER HEARD OF SUCH OF A THING HAPPING LIKE THAT. THOUGHT MATBE IT WAS THE NEW BATTERY THEY PUT IN MY CAR IN MARCH OF 20018 SO I WANT THIS ON RECORD THAT I HAD IT CHECKED EVEN CALLED AND CHECKED ON LINE IF THERE WAS A TRECALL ONLY THING I FOUND WAS A 2014 RECALL ON MY YEAR BUT NOT MY VION OF THE ELECTRICAL SYSTEM SOFTWARE. IS IT POSSABLE THAT IS WHAT HAPPENED TO MY CAR. HOPE YOU CAN GIVE ME A ANSWER
THE HONK / SPIRAL CABLE IS DEFECTIVE - ONLY NOTICED IT IN 2015 (BROUGHT TO THE DEALER) BUT NEVER USED THE HONK BEFORE THAT - COULD HAVE BEEN EARLIER... IT ONLY WORKS WHEN THE STEERING WHEEL IS COMPLETELY TURNED TO ONE SIDE. SINCE CAR HAS NEVER BEEN INVOLVED IN ACCIDENT , THIS IS A MANUFACTURE DEFECT AND NOT WEAR AND TEAR - TOYO…
Read full complaint
THE HONK / SPIRAL CABLE IS DEFECTIVE - ONLY NOTICED IT IN 2015 (BROUGHT TO THE DEALER) BUT NEVER USED THE HONK BEFORE THAT - COULD HAVE BEEN EARLIER... IT ONLY WORKS WHEN THE STEERING WHEEL IS COMPLETELY TURNED TO ONE SIDE. SINCE CAR HAS NEVER BEEN INVOLVED IN ACCIDENT , THIS IS A MANUFACTURE DEFECT AND NOT WEAR AND TEAR - TOYOTA SHOULD COVER IT - I SEE THEY HAVE ON OTHER MODELS - I CAME CLOSE TO 2 SERIOUS ACCIDENTS WHEN I WAS UNABLE TO WARN DISTRACTED DRIVERS - THE COST IS HIGH AND THIS IS WHY I DID NOT NOT GET IT FIXED IN 2015 WHEN I FIRST NOTICED IT (THE CAR WAS ONLY 4 YEARS OLD) -
I WAS GETTING ON THE INTERSTATE AND ALL OF A SUDDEN I LOST POWER AND MY DASH LITE UP CHECK HYBRID SYSTEM /ABS/ BREAKS. I CAN NOT DRIVE MY CAR BECAUSE IT HAS NO POWER PLEASE HELP THANK YOU
THE HEADLIGHTS KEEP BURNING OUT, I HAVE REPLACED THE DRIVERS SIDE 3 TIMES IN 12 MONTHS AND THE PASSENGER SIDE TWICE. I ONLY USE SYLVANIA BRAND, BUT HAVE SWITCHED TO DIFFERENT BRIGHTNESS TO SEE IF IT HAS ANY IMPACT, IT HAS A SLIGHT IMPACT BUT NOT MUCH. THE HEADLIGHTS ARE NOT ON WHEN NOT NEEDED.
DIM HEADLIGHT PROBLEM WHILE DRIVING AT NIGHT, UNABLE TO SEE ROAD CLEARLY WITH LOW BEAM HEADLIGHTS ON AT NIGHT, HAVE TO USE HIGH BEAM HEADLIGHTS TO SEE ROAD. THIS IS A HUGE SAFETY ISSUE FOR ME
TL* THE CONTACT OWNS A 2011 TOYOTA PRIUS. ON SEVERAL OCCASIONS, THE CONTACT HAD TO ADD FOUR QUARTS OF OIL WITHIN 10,000 MILES OF DRIVING. ON ANOTHER OCCASION, THE CONTACT HAD TO ADD THREE AND A HALF QUARTS OF OIL. THE CONTACT STATED THAT THE OIL PRESSURE INDICATOR FAILED TO OPERATE AND WARN HIM THAT THE OIL WAS LOW. THERE WERE N…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA PRIUS. ON SEVERAL OCCASIONS, THE CONTACT HAD TO ADD FOUR QUARTS OF OIL WITHIN 10,000 MILES OF DRIVING. ON ANOTHER OCCASION, THE CONTACT HAD TO ADD THREE AND A HALF QUARTS OF OIL. THE CONTACT STATED THAT THE OIL PRESSURE INDICATOR FAILED TO OPERATE AND WARN HIM THAT THE OIL WAS LOW. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THEY HAD NOT RECEIVED MANY COMPLAINTS AND THAT THE VEHICLE WAS OUT OF WARRANTY. THE FAILURE MILEAGE WAS 98,000.
TL* THE CONTACT OWNS A 2011 TOYOTA PRIUS. THE CONTACT STATED THAT THE VEHICLE'S HORN LOST FUNCTIONALITY. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.
DASH BOARD KEEPS BEEPING, YET I HAVE REPLACED THE KEY BATTERY 3 TIMES AND NOW DEALER SAYS KEY NOT DETECTED, YET CAR RUNS SO THE KEY IS DETECTED BUT THE BEEPING WILL NOT STOP. TOOK TO DEALER PAID 89.99 FOR DIAGNOSTIC PER DEALER. DEALER NOW SAYS THE LEFT HARNESS NEEDS REPLACED FOR $1802 PLUS TAX. I FEEL MANUFACTURER SHOULD ALLO…
Read full complaint
DASH BOARD KEEPS BEEPING, YET I HAVE REPLACED THE KEY BATTERY 3 TIMES AND NOW DEALER SAYS KEY NOT DETECTED, YET CAR RUNS SO THE KEY IS DETECTED BUT THE BEEPING WILL NOT STOP. TOOK TO DEALER PAID 89.99 FOR DIAGNOSTIC PER DEALER. DEALER NOW SAYS THE LEFT HARNESS NEEDS REPLACED FOR $1802 PLUS TAX. I FEEL MANUFACTURER SHOULD ALLOW CONSUMERS WHO BOUGHT THERE PRODUCT BE GIVEN INFORMATION ABOUT HISTORY OF FAULTY ELECTRICAL WIRES EVEN WHEN IT IS NOT A SAFETY HAZARD. JUST TURN OFF THE BEEPING NOISE IF THAT IS THE ONLY ISSUE. MILEAGE 58847...
TL* THE CONTACT OWNS A 2011 TOYOTA PRIUS. WHILE DRIVING VARIOUS SPEEDS AT NIGHT, THE FRONT DRIVER SIDE HEADLIGHT BECAME INOPERABLE. ON ANOTHER OCCASION, THE FRONT PASSENGER SIDE HEADLIGHT ALSO FAILED WITHOUT WARNING. THE DEALER RECOMMENDED THAT BOTH BULBS BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED TWO Y…
Read full complaint
TL* THE CONTACT OWNS A 2011 TOYOTA PRIUS. WHILE DRIVING VARIOUS SPEEDS AT NIGHT, THE FRONT DRIVER SIDE HEADLIGHT BECAME INOPERABLE. ON ANOTHER OCCASION, THE FRONT PASSENGER SIDE HEADLIGHT ALSO FAILED WITHOUT WARNING. THE DEALER RECOMMENDED THAT BOTH BULBS BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED TWO YEARS LATER WHERE BOTH HEADLIGHTS FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Official recalls
618V684000 · Hybrid Propulsion System
Oct 4, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
16V487000 · Air Bags:side/window
Jun 30, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
Consequence & remedy
Consequence: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
16V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
14V053000 · Electrical System:software; Hybrid Propulsion System: Inverter
Feb 12, 2014
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
13V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.