2003 Toyota Prius

The contact owns a 2003 Toyota Prius. The contact stated that while driving at 65 MPH, the steering wheel began to vibrate with an unknown message displayed on the instrument panel. As the failure persisted, the message disappeared, and the contact was able to drive to her destination. Upon restart of the vehicle, the contact received a do not drive message on the instrument panel with the steering wheel vibrating. Due to the failure, the contact had the vehicle towed to a dealer where it was diagnosed with a defective steering sensor. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 11V304000 (Steering). The manufacturer was notified of the failure and referred her to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 176,000.

WE PURCHASED A 2003 TOYOTA PRIUS IN JUNE OF 2018. IT HAS APPROXIMATELY 140,000 MILES ON IT. WHEN THE WEATHER STARTED GETTING COLDER IN OCTOBER OF 2018, THE CAR EXHIBITED THE FOLLOWING PROBLEM: CAR STEERING WHEEL SHAKES VIOLENTLY FOR SEVERAL SECONDS WHILE EXITING THE DRIVEWAY USUALLY AS WE ARE TURNING THE STEERING WHEEL. THE VEHICLE WAS IN MOTION WHEN THE SHAKING OCCURRED AND IT WAS OFTEN AFTER MAKING A TURN AND/OR STRAIGHTENING THE STEERING WHEEL. IN ORDER TO STOP THE SHAKING, THE CAR HAS TO BE STOPPED. WE HAVE DONE SOME SEARCHES ONLINE AND IT APPEARS THAT THIS PROBLEM IS COMMON FOR THE 2003 TOYOTA PRIUS. HOWEVER, WE CALLED 3 DEALERS AND THEY ALL SAY THEY DON'T KNOW ABOUT IT AND THEY HAVE TO SEE THE CAR AS IT IS SHAKING TO DETERMINE THE CAUSE OF THE ISSUE. SINCE THE WEATHER IS NOW WARMER, IT IS UNLIKELY IT WILL OCCUR UNLESS WE GET A COLD MORNING. WE CANNOT LEAVE THE CAR AT A DEALERSHIP INDEFINITELY. WE WERE PLANNING A TRIP TO IDAHO AND ARE AFRAID TO HAVE THE CAR ON THE ROAD BECAUSE OF THIS ISSUE. DO YOU KNOW ANYTHING THAT WE CAN DO TO CORRECT THIS DEFECT? SHOULD WE CONTACT TOYOTA DIRECTLY?

THIS HAS HAPPENED SEVERAL TIMES INTERMITTENTLY; THE STEERING WHEEL SHAKES WHEN BACKING OUT OF THE GARAGE TURNING INTO THE "TURN-AROUND" SPOT, IT HAS ALSO HAPPENED WHILE TURNING INTO MY DRIVEWAY. MOSTLY AT SLOW SPEEDS, THERE IS A NOISE, GRINDING TYPE, COMING FROM THE STEERING COLUMN. THE DEALER SAID THE BRAKES COULD BE DOING IT, SO THEY REPLACED THE FRONT PADS AND RE-SURFACED THE ROTORS, (AFTER THE $175) THE PROBLEM PERSISTS. WHEN I PUT MY VIN INTO THE NHTSA WEBSITE, THEY TELL ME THERE IS NO RECALL BUT ON .NHTSA.GOV/RECALLS#VEHICLE IT IS INCLUDED, BY YEAR AND IT MUST HAVE BEEN MADE BEFORE 12-31-2002 BECAUSE THAT'S WHEN WE GOT IT. MOST RECENTLY ON 02/27/2017, BUT HAS BEEN GOING SINCE NOV. OF 2016

TL* THE CONTACT OWNS A 2003 TOYOTA PRIUS. WHILE DRIVING 10 MPH, AND MAKING A LEFT TURN, THE STEERING WHEEL SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE CAUSE OF THE FAILURE COULD NOT BE FOUND. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V304000 (STEERING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2003 TOYOTA PRIUS. WHILE DRIVING AT APPROXIMATELY 35 MPH, THE STEERING WHEEL SHOOK INTENSELY. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 11V304000 (STEERING), BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 162,000.

TL* THE CONTACT OWNS A 2003 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 35 MPH, AN UNKNOWN WARNING MESSAGE DISPLAYED AND THE STEERING WHEEL WAS VERY DIFFICULT TO TURN. THE VEHICLE WAS RESTARTED AND FUNCTIONED AS NORMAL. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V304000 (STEERING). THE FAILURE MILEAGE WAS 63,000.

WHILE DRIVING, THE STEERING WHEEL BEGINS TO SHUDDER. AT ONE POINT, IT POWER STEERING MAKES A SPONTANEOUS TURN TO THE LEFT, WHICH I PREVENT WITH MY HANDS, BUT NEVERTHELESS MOVES THE CAR TO THE LEFT ENOUGH TO CAUSE AN ACCIDENT IF THE DRIVER IS NOT PAYING CLOSE ATTENTION, OR HAPPENS TO BE TOO NEAR ANOTHER CAR. THE POWER STEERING IMMEDIATELY SHUTS OFF, AND THE REST OF THE TRIP CONTINUES WITH NO POWER STEERING, UNTIL THE CAR IS TURNED OFF. THE NEXT TIME THE CAR IS TURNED ON, THE POWER STEERING IS BACK (UNTIL IT HAPPENS AGAIN). *TR

VIOLENT SHAKING OF THE STEERING WHEEL WHEN TURNING IN COLD WEATHER. IT HAS HAPPENED MOST DAYS THIS WINTER WHEN TEMPERATURES WERE BELOW 45F DEGREES. IT WAS MOSTLY AN ANNOYANCE AT FIRST, AND WOULD HAPPEN WHEN STARTING THE CAR, BUT TWICE IT HAS NEARLY CAUSED A CRASH. THE FIRST NEAR COLLISION FROM SHAKING WAS IN JANUARY WHEN TRYING TO PARK BETWEEN TWO CARS IN A PARKING SPOT AND I COULDN'T CONTROL THE WHEEL UNTIL I PUT THREW THE CAR INTO PARK, TURNED IT OFF, AND TURNED IT ON AGAIN. THE SECOND, AND MOST SERIOUS INCIDENT SO FAR I NEARLY HIT A PEDESTRIAN IN A CROSSWALK WHILE TRYING TO MAKE A RIGHT TURN IN DOWNTOWN SEATTLE ON A DAY WHEN IT WAS IN THE 20'S. TURNING RIGHT THE STEERING WHEEL STARTED SHAKING SO VIOLENTLY IT BROKE FREE FROM MY GRIP, I LOST CONTROL OF THE CAR AND IT VEERED LEFT INTO THE ONCOMING LANE TOWARDS A PEDESTRIAN. I SLAMMED ON THE BRAKES AND ONLY MISSED HIM BY ABOUT 3 FEET. I CONTACTED TOYOTA AND WAS INFORMED THAT THERE HAD BEEN A 2 YEAR SERVICE CAMPAIGN TO REPLACE THE EPS, BUT THAT THE CAMPAIGN EXPIRED 12/31/13, AND THEY WERE THEREFORE UNABLE TO DO A REPLACEMENT BECAUSE I DIDN'T BRING THE CAR INTO THE DEALERSHIP BEFORE THE DEADLINE, AND THEY DON'T SEE IT AS A SAFETY ISSUE. WE WERE NEVER CONTACTED BY TOYOTA ABOUT THE SERVICE CAMPAIGN, AND THE ISSUE DID NOT BECOME DANGEROUS OR EVEN PARTICULARLY BOTHERSOME UNTIL NEARLY A MONTH AFTER THE CAMPAIGN EXPIRED. DUE TO THIS NEARLY CAUSING TWO ACCIDENTS IN A SHORT TIME SPAN JUST PAST THE CAMPAIGN DEADLINE, AND THE FACT THAT IT SEEMS TO BE A COMMON PROBLEM ON THIS MODEL OF PRIUS, I BELIEVE THIS SHOULD BE ESCALATED TO A GENERAL RECALL OR EXTENDED WARRANTY BASED ALSO ON MILEAGE INSTEAD OF SOLELY ON THE CALENDAR YEAR TO NOT PENALIZE LOWER MILEAGE VEHICLES COMING INTO THE PROBLEM BEYOND THE EXPIRATION OF THE CLASS ACTION LAWSUIT MANDATED SERVICE CAMPAIGN. *TR

STARTED VEHICLE , BEGAN TO PULL OUT OF DRIVEWAY AND STEERING WHEEL BEGAN TO SHAKE VIOLENTLY. HAD TO STOP VEHICLE TO WAIT FOR STEERING WHEEL TO STOP SHAKING. HAS BEEN DOING IT EVERYTIME I GO TO START VEHICLE . SEEMS TO DO O.K. DRIVING AT SPEEDS ABOVE 10 MPH. STARTING TO GET SLIGHT VIBRATION AT HIGHWAY SPEEDS. TOYOTA DEALERSHIP SAYS POWER STEERING RACK NEEDS TO BE REPLACED AT A COST OF $3400.00. *TR