1997 Toyota Land Cruiser

Fuel tank develops crack and leaks when filled more than 10 gallons approx 1/2 full. There is a specific point on the tank where it cracks on top. The metal is very thin at this point and possibly with newer Ethanol fuels the tank expands and contracts far more in hot weather? This problem is well documented on Toyota Land Cruiser websites, specifically IH8MUD.com. The website is telling owners to log complaints with NHTSA. I would think leaking gas is a major safety issue along with being an emissions violation. Yes the vehicle is available for inspection. Manufacturer gives no response. The FJ 60/62 Land Cruiser (model before, did have a recall on the fuel tank) No warning lamps or messages OBD2.

THE FUEL TANK LEAKS FROM A CRACK POTENTIALLY FORMED BY STRESS OF FUEL AND A PRESSURIZED SYSTEM. WHEN FULL OF FUEL, THE SYSTEM ACTIVELY DRIPS AND LEAKS FUEL OUT. EVEN WHEN NOT FULL, THERE IS A VAPOR SMELL PRESENT. HTTP://FORUM.IH8MUD.COM/THREADS/LEAKING-GAS-FROM-TOP-OF-TANK.225705/ THIS COMPLAINT HAS BEEN PRESENT AND IS DISCUSSED HERE ON THIS FORUM; INCLUDING PICTURES OF THE LOCATION, ATTEMPTED REPAIRS AND SUBSEQUENT FAILURE OF REPAIRS. THIS POSES A SIGNIFICANT FIRE HAZARD, AS ANYTHING AS MINIMAL AS A SPARK COULD LEAD TO A FIRE HAZARD. MY VEHICLE HAS ACTIVE LEAKING WITH A FULL FUEL TANK DRIPPING OF THE FUEL UNTIL A CERTAIN LEVEL, AND A FUEL ODOR PRESENT CONSTANTLY DESPITE FUEL LEVEL. THE INTERIOR OF THE VEHICLE CONSTANTLY SMELLS LIKE FUEL AS WELL. THERE HAS BEEN A RECALL ON AN OLDER MODEL 60 SERIES LAND CRUISER, AND TOYOTA APPEARS TO ACKNOWLEDGE A MANUFACTURING DEFECT IN THE PAST THAT OBVIOUSLY HAS NOT BEEN ADDRESSED EVEN 10 YEARS LATER IN MANUFACTURING.

TL* - THE CONTACT OWNS A 1997 TOYOTA LAND CRUISER. THE VEHICLE HAS INTERCO - TRXUSM/T, SIZE 265/75/16 TIRES. THE DOT#T 4FW8T5M 20504. THE CONTACT PURCHASED 6 SNOW TIRES AND 2 OF THEM HAVE BLOWN OUT WHILE DRIVING AT 62 MPH ON AN INTERSTATE HIGHWAY. THE CONTACT'S REAR PASSENGER TIRE BLEW OUT. THE RUBBER UNWRAPPED AROUND THE BEAD, AND IT EXPLODED THERE AND RIPPED THROUGH TO THE TREAD. THE TREAD REMAINED INTACT AND EACH OCCURRENCE WASIDENTICAL. THE INCIDENT OCCURRED ON DECEMBER 29, 2006 AND THE WEATHER WAS NOT A FACTOR. THE INCIDENT HAS OCCURRED SIX TIMES. TTHE CONTACT IWASCERTAIN THAT THERE WERE NO OBSTRUCTIONS ON THE HIGHWAY. THE TIRE MILEAGE WAS 1,500. THE TIRES WERE AFTER MARKET SNOW TIRES. THE TIRE DEALER AGREED TO ACCEPT THE TIRE VIA MAIL TO INVESTIGATE THE DAMAGE AT THE CONTACT'S EXPENSE. THE CONTACTWAS UNCERTAIN OF THE RECOURSE WITH THE TIRE DEALER TO REPLACE THE TIRES. THE CONTACT WAS CONCERNED ABOUT THE SAFETY RISK INVOLVED WITH THE AUTO AFTER MARKET TIRES. *AK

OUR 1997 TOYOTA LAND CRUISER IS NOW INOPERABLE DUE TO MULTIPLE FAILURES IN REPAIRS BY FOLSOM LAKE TOYOTA. COOLANT PROBLEMS HAVE BEEN NOTED SINCE 1999 WITH THE ABOVE REPAIR FACILITY FAILING TO CORRECT DEFECT. CURRENT PROBLEMS INVOLVE FOLSOM LAKE TOYOTA REFUSING TO CORRECT FAILED REPAIRS, COOLANT MIXING WITH ENGINE OIL CAUSING AUTO TO BE UNUSABLE. *JB

THREE OF THE FOUR BOLTS THAT SUPPORT THE STREERING KNUCKLE TO THE HUB AT THE RIGHT FRONT WHEEL WERE SHEARED AND BROKEN OFF OF THE VEHICLE. THIS ACTION RESULTED IN THE RUPTURING OF THE TRANSAXLE SEAL ON THE FOUR WHEEL DRIVE SUV. THE RELEASING OF THAT FLUID AND MY NOTICING IT ON THE GROUND AROUND THE WHEEL WHILE THE VEHICLE WAS PARKED, WAS THE FIRST SIGN OF ANY PROBLEM. IT WAS ONLY AFTER I HAD THE VEHICLE TOWED TO THE REPAIR SHOP THAT THE EXTENSIVE DAMAGE TO THE STREERING KNUCKLE WAS DISCOVERED.

PURCHASED TIRES SEPTEMBER 27, 1999, VEHICLE HAD 52,400 MILES. HAD SIDEWALL BLOWOUT ON 1 TIRE ON DECEMBER 8, 2000 AT 71,500 MILES (ABOUT 19,000 MILES ON TIRE). HAD SECOND BLOWOUT ON DECEMBER 20, 2000 AT 72,000 MILES (19,500 MILES ON TIRE). BOTH INCIDENTS OCCURING AT HIGH SPEEDS - 50+MPH. DOT #B73R 171X 349 (DOT NUMBER: B73R171X34 TIRESIZE: 275/70 R16)