2021 Toyota Highlander

•The transmission malfunctioned and developed an abnormal internal noise at approximately 67,000 miles, which is an unexpected failure at low mileage. The vehicle had been properly maintained and had no prior mechanical issues. Atlanta Toyota inspected the vehicle and confirmed the transmission had failed and required full replacement. The dealer also stated that as a result of the transmission failure, other related components showed excessive and abnormal wear. A second independent service center inspected the vehicle and confirmed the same diagnosis. The vehicle is available for inspection upon request. • This unexpected transmission failure created a serious safety risk due to the possibility of sudden loss of power, inability to accelerate, or complete transmission failure while driving. I rely on this vehicle daily to transport my child to school and to commute to work. A sudden failure while in traffic could result in becoming stranded or involved in a collision. • The vehicle was inspected by an authorized Toyota dealer and an independent service center. Both stated that the failure was unusual given the low mileage and normal use of the vehicle. • There were no warning lights, messages, or diagnostic trouble codes prior to the failure and afterward. The only symptom was an abnormal internal noise from the transmission, which began suddenly at approximately 66,000 miles. • The vehicle has received regular maintenance and is used for normal daily driving. There was no abuse, heavy towing, or unusual use that would explain a transmission failure at this mileage.

I am writing about my 2021 Toyota Highlander XLE AWD VIN # [XXX] . I purchased this vehicle brand new on 3/29/2021 at ‘Koons Easton Toyota’ in Easton, MD. In October 2025 I started hearing whining noise from the engine compartment. It was audible only when accelerating the vehicle and would go away if I took my foot off the accelerator. On 10/22/2025, I took the vehicle for inspection to ‘Ourisman Toyota 40’ dealership in Edgewood, MD. The technician told me that this is a known issue in this model/year and recommended to replace transmission as there was no other fix. He gave me a $9,995 estimate for transmission replacement. I subsequently learned that there was technical service bulletin on this exact defect released by Toyota on 2/9/2021. It said that models with UA80F transmission will make whining noise and then fail. The only remedy was to replace the transmission with brand new transmission part number 30500-0E160. This bulletin was posted on NHTSA website also. [XXX] This bulletin was released 50 days before I purchased the brand-new vehicle on 3/29/2021. My frustration and disappointment came from the fact that Toyota had known about this issue for 50 days and still proceeded to sell this vehicle to me. This is unacceptable as there should have been a recall on this defect or Toyota should have pulled the vehicle from the market. This is not about the powertrain warranty running out as that would apply to unforeseen issues that neither manufacturer nor buyer knew about in advance. It is about knowingly selling the customer a defective product even after disclosing the major defect publicly. Transmission failure can be a serious safety issue because it could have caused sudden loss of power and difficulty controlling speed. I request NHTSA to investigate these widespread Highlander transmission issues the same way Ford F150 transmission issues are being investigated. Thanks INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Complete transmission replacement for failure. Toyota said it is an unknown issue but has not issued a recall for 2020/2021 models. THIS NEEDS TO BE A RECALL. Toyota should be responsible, especially because they will not cover it if you go over your manufacturer warranty of 60k. I purchased this car last week, and had to get a full new transmission the following week because they did not disclose to me that it was failing!

I had the 60,000 mile service on February 2,2026 and after the service was completed I left the dealership and got on the freeway to go home. I heard a whining noise and immediately turned around and took it back to the dealer. I took the mechanic who worked on my car for a drive and he was able to hear the winding noise and we returned to the dealership. It took the mechanic three hours to come to the conclusion that I needed a new transmission. They still have my car and I have not heard anything about coverage or when it will be done.

- The vehicle has been experiencing shifting issues (its an automatic vehicle) when driving in all instances and at all speeds that has progressively gotten worse over the past 4-8 weeks. - As it seems to be a transmission issue (and a known one pending litigation) the safety issue is if the transmission fails during operation of the car. - It was brought to a dealership to be inspected after it was initially felt as more of a vibration than the more harsh shifting/engine sounds and issues that it is currently experiencing. The dealership thought it to be the front hub assembly/bearing that was the issue. I had the front driver side replaced and the issue still remains and has continued to worsen. It has not been inspected by the manufacturer, police, or insurance representative. - There have been no warning lamps or messages at all. - Through research it appears this is a known issue with ongoing litigation (2 class action lawsuits currently in litigation related to UA80F transmissions of which it appears that our VIN is in the affected group).