2021 Toyota Highlander

About 15 minutes prior to the incident, the interior shade cover was closed beneath the moonroof. Mostly sunny day about 85° F, about 55mph, the moonroof exploded. The sound was that of a shotgun, followed by wind noise and tinkling noises of shattered glass just beyond the shade cover. Upon external examination, 100% of the glass sliding moonroof was shattered, approximately 30% of the glass had departed the vehicle from a forward and central portion of the glass area. The remaining glass was bowed outward. The roof aft of the moonroof displayed 1-3 millimeter length flags of clear coat paint where the glass shards had etched the painted surface and the rear spoiler fairing panel over the aft hatch had gouges in the plastic composition along the upper surface of said fairing. All components on the vehicle were factory installed. Vehicle had 10,000 miles and was in service just over 5 months. There were no indications of an impeding problem. The moonroof was secured with tape and cardboard to prevent shards of glass from departing the vehicle. The dealership body shop estimates repairs at $4319. Safety threat: If shade were open at the time of explosive incident, shards of glass would fall onto driver and passengers, which might create a loss of control from panic (explosion was very loud and disconcerting) glass in facial area (between eyes and sunglasses) or falling into clothing at the neck area and creating a painful bloody situation at highway speeds. Shards of glass departing incident vehicle might reach a following vehicle (motorcyclist) depending upon upward trajectory of glass and forward speed. Might affect vehicles traveling in opposite direction. Driver following incident with window down might be exposed to shards of glass slip streaming into that vehicle.

I purchased my Toyota Highlander Hybrid only about 2 months ago. Since then, I've experienced several incidences of sudden acceleration. In a few of them, I was approaching a stop sign and began to slow down. Suddenly, I felt the car accelerate on its own. In both instances, I slammed on the brakes and the car jerked then stopped. There was one instance when I was going down hill and I was stepping on the brakes, but the car seemed to accelerate on its own until I stepped on the brakes again. Fortunately, there were no collisions. However, this is a serious safety problem.