2021 Toyota Highlander

On August 24, 2026, my vehicle was parked, turned off, and locked for more than 6 hours in a parking lot. Without warning, the vehicle experienced a spontaneous thermal event/self combustion. The fire and thermal damage were entirely localized to the dashboard area inside the passenger cabin. The engine compartment, battery area and front mechanical components remained completely unaffected by the fire. The vehicle was off, motor was cold and car was closed and parked for about 6 hours when this incident occurred.

My system information warning signal and chime indicates that an unbuckled passenger is present in my front passenger seat when nobody is there. Additionally, buckling the seat belt does not turn off the signal and chime. The sporadic signal and chime can continue for a very long time before eventually stopping. However, after another 30 seconds or so, it can start again. This cycle can continue for over an hour. It tends to occur more frequently above 35mph, but can also occur under that speed. From my research, this problem appears similar to another recall (Recall #23TA15 / Campaign 23V-865000), however my VIN currently isn't included in that recall.

This is a formal report of Recall Non-Compliance regarding Safety Recall 23V-720 (Toyota Recall 23TA12) on my 2021 Highlander Hybrid. An authorized dealership performed the recall on May 6, 2024, utilizing Op Code 23TA12R1 (Inspection & Install Fasteners). The dealership only addressed the lower bumper and failed to properly remedy the upper bumper retention tabs, stating it isn’t part of recall. The upper bumper cover has completely separated from the fenders during normal daily driving. The upper plastic mounting slots are torn out and clips will not hold. The dealership is refusing further repairs, instructing me to file a car insurance claim or pay a body shop myself to correct an un-remedied federal safety defect. The vehicle currently remains an active structural road hazard because the official recall remedy completely failed to secure the bumper assembly from detaching. A TAS case has been opened at the dealer, but federal intervention is requested to ensure recall compliance.

The back hatch of the car has issues closing regularly. Nearly half of the time you push the button to shut the back hatch when it is open it will not close and has to be shut manually. Typically, it shuts an inch or two and then beeps at you and when you push the button again nothing happens but beeping. This is an issue because it is very difficult to close. Even as a 6' 200+ lb man who does strength training regularly, shutting the back hatch is difficult to do manually let alone for my much smaller wife. This has let to her having to ask for help from strangers in a parking lot to help close the door which is unsafe, particularly since we have small children. Toyota has acknowledged that this is a known issue and have stated that there is nothing that they can do to fix it. This acknowledgement came when the car was very new and my father was the owner and again just a few months ago when we brought up the issue again with Toyota.

Have been having issues with my 2021 highlander power liftgate strut failure. It will not open at times unless you have to repeat pressing the button. It makes a noise that you know it is definitely not working right. This has been going on for three years and the service department keeps telling me it is working fine for right now...

Car has stopped while pumping gas seems to be specifically after rain. There was a heavy rain and immediately after while pumping gas car was not able to start. Received message steering power low. Happened 3 times after first incident while pumping gas. Car was checked by a mechanic and believe it might be a defect with a part called purge flow ? After part was inspected all check engine lights and alerts on cars went away for a few weeks. Once again we had light rain and the same issue restarted , with unable to power car after pumping gas

I bought this vehicle used on 04/23/2024 with 18,596 miles on the odometer. When I was inspecting the vehicle prior to delivery at the dealership, I noticed a crack low on the windshield. The dealership replace the windshield prior to my taking delivery of the vehicle. In the spring of 2025 I had a crack develop in the windshield and had to have it replaced. Another crack has since developed (it is now 2/25/26), and I will, once again, have to have the windshield replaced. I have not driven on any freeways recently, so no high-speed travel. I have been driving for over 40 years and have never had this frequency of windshield failures. I have become aware that this issue is discussed by numerous newer model year (2021, 2022, 2023, etc) Toyota Highlander owners. Some have replaced their windshield multiple times like me. It would appear that there may be an issue in the design/aerodynamics of the front/windshield or a defect in the structure of the body that supports the windshield, that leads to this increased frailty of the windshield. I would very much like to see the NHTSA look into this issue and to force Toyota to look carefully at the high number of windshield failure incidents in these vehicles.

•The transmission malfunctioned and developed an abnormal internal noise at approximately 67,000 miles, which is an unexpected failure at low mileage. The vehicle had been properly maintained and had no prior mechanical issues. Atlanta Toyota inspected the vehicle and confirmed the transmission had failed and required full replacement. The dealer also stated that as a result of the transmission failure, other related components showed excessive and abnormal wear. A second independent service center inspected the vehicle and confirmed the same diagnosis. The vehicle is available for inspection upon request. • This unexpected transmission failure created a serious safety risk due to the possibility of sudden loss of power, inability to accelerate, or complete transmission failure while driving. I rely on this vehicle daily to transport my child to school and to commute to work. A sudden failure while in traffic could result in becoming stranded or involved in a collision. • The vehicle was inspected by an authorized Toyota dealer and an independent service center. Both stated that the failure was unusual given the low mileage and normal use of the vehicle. • There were no warning lights, messages, or diagnostic trouble codes prior to the failure and afterward. The only symptom was an abnormal internal noise from the transmission, which began suddenly at approximately 66,000 miles. • The vehicle has received regular maintenance and is used for normal daily driving. There was no abuse, heavy towing, or unusual use that would explain a transmission failure at this mileage.