2018 Toyota Highlander

My 2018 Highlander Transmission (8 speed model UA80) began a whine noise characteristic of Customer Support Bulletin POL19-04 when the vehicle hit 101k miles. Toyota performed an inspection on 8/9/2024 and recommends full transmission + transfer case replacement. The dealer confirmed also confirmed the issue is characteristic of POL19-04, but because the vehicle was manufactured 6-months after vehicles bracketed in POL19-04 (based on the transmission serial number) it is not included in the support program therefore not covered. Toyota UA80 transmissions have continued to have this issue (example - T-SB-0008-21 for '21 UA80 transmission). While Toyota acknowledges replacement of transmission is necessary to maintain a safe drivetrain, no customer-facing error messages are evident. Also note - transmission fluid has been maintained only using Toyota's recommended Fluid (Toyota branded WS ATF) at Toyota's specified intervals.

As I was returning to my house and about to pull into our garage I was driving very slowly, riding the brake in fact. I was going less than 1 mph but as I first entered the garage my car engine suddenly roared very loudly and sped inside. I pressed as hard as I could on the brakes and the car skidded towards the left and slammed into the garage wall. I firmly believe that the only thing that kept my car from traveling farther was the garage door frame. Between my braking and then turning off the engine, I came to a stop. There were skid marks on the pavement at the garage entrance from the hard braking and both the driver's door and the passenger door on that side were severely damaged. The car was now angled to the left and not pointed straight into the garage as it should have been. At no time did I press on the accelerator.

The contact owns a 2018 Toyota Highlander. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle was towed to the dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 130,000.

On a trip to NC on June 27 2024, then on to Hilton Head SC on 6/29, multiple system warning lights suddenly appeared on the dash including ABS, Lane Departure Warning, BSM, notifying me that those safety features were not available on the vehicle. Sometimes the the lights would disappear, especially if the vehicle was stopped and the engine was turned off at a rest area. Because the check engine light was not lit, I continued to our NC destination. We continued our trip on 6/29 to Hilton Head, and the lights continued to appear, sometimes staying on for an hour or more. I called my Binghamton NY Toyota dealer who advised me to have the problem looked. I was able to have the car seen at Savannah Toyota (GA) where they diagnosed the problem as an issue with rust and debris on the left front speed sensor. I had the recommended service performed. The service report says that I requested replacing the ABS sensor, which is totally false, because I had no idea what the problem was, I just wanted it fixed. The part was ordered and replaced the next morning. All the lights were back on the next day when I drove back from Savannah to Hilton Head. I did not have time to go back to the dealer, but did notify the service manager of the situation. I drove the vehicle back to NY with the warning lights on (most of the time). I now have a service appt with my local dealer on 7/9/24 to determine the next step.

My vehicle is stalling when driving and other Toyota Highlanders of same model and year were/are having the same issue and have been recalled for the fuel pump. Having my vehicle stall when driving in the busy highways of Texas are very dangerous especially when some speed limits go up to 80mph. The problem has been reproduced and witnessed by a mechanic. The Toyota dealership stated that my VIN is not included in the recall so they could not fix it. There was no warning before the first time my vehicle stalled while driving in the highway. Unsure of how dealerships only stick to just the specific VINs that are effected when other VINs of the same model and year are having the same issue but are not willing to fix the issue.

Whining noise from transmission on 2018 Toyota Highlander XLE model . Toyota has acknowledged this on large numbers of vehicles manufactured during the same year (TSB-0160-18). They have a voluntary recall for some of these vehicles during this year (2018), but not all of them. The transmission can fail which would cause the vehicle to stop running. On a highway or busy road, this presents a very large danger to both the vehicle occupants and also other people on the road. The vehicle has been inspected by both the dealership an an independent transmission shop and identified as the same transmission issue. Toyota will not correct this issue other than to say the transmission needs to be replaced as it will fail at some point in time. No other warning indicators other than the whining sound from the transmission. The symptoms appeared around 48700 miles on the vehicle.

Transaxle/Transmission failed at approx 67000 Miles. Emits a whining sound, very similar to symptoms as other transaxle/transmissions from model yr 2017 covered by the manufacturer for replacement of transaxle/transmission. This vehicle, model year 2018, is not covered by the existing transaxle/transmission replacement program, as explained by the dealership. Yet reviewing many forums, it is said that many of the later 2017/2018 Highlanders received the same transaxle/transmissions as the model year 2017 covered for replacement by the manufacturer, hence they exhibit the same symptoms when they fail. Estimated cost to replace the transaxle/transmission by the dealership $ 8000.00. The manufacturer needs to step up.

Transmission is bad. Toyota dealership says it needs to be replaced. Really? In a 2018 Toyota. I thought these were good cars. Supposed to last a long time. That’s why I paid over $30,000 for it. And this is what I get. There is something wrong with this scenario. I could have bought a much cheaper car and it would still be functioning fine.

Driving along [XXX] in Alabama to Mississippi, the Highlander completely shut off - the dash & radio were blank. The steering wheel locked up. Luckily there was no vehicles behind or beside us when this happened. Within seconds, the truck came back on. 15 minutes prior, we were sitting in a parking lot to eat lunch & while in idle, the truck shuddered a few times, like the gas pedal was pressed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)