2018 Toyota Highlander

My husband took my car from the carport and parked it in the driveway near the water hose to wash the car. When he finished, it would not start. The message “Braking Power Low” , “STOP in a Safe Place”, “ See Owner’s Manual”showed up. Of course, we could not find anything in the large owner’s manual concerning that! I checked with my VIN to see if mine was included in the recall regarding this same matter, but it was NOT, just as all other Toyota Highlander 2018 owners who complained were told!!! We will find out tomorrow and pray it won’t be a lot of money. We have a Thanksgiving trip planned to see our grandchildren. Today is Sunday and we planned to leave on Tuesday. I shudder to think what could have happened if it suddenly stopped on [XXX] with all the holiday traffic. My husband was looking to buy a car after the first of the year and was going to buy a Toyota. After this, he has reconsidered. Toyota needs to see all these complaints and how many were not included in the recall!!! Something’s not right! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I brought my car to the dealership due to a small whining noise when accelerating over 30mph. Technician determined the noise is coming from internal transmission failure and recommended replacement. The small whining noise was the only indication something was wrong. No check engine or warning lights on my dashboard. The car is under 50,000 miles at the time.

Around 29,000 miles, I noticed a severe brake vibration while slowing down or stopping from speeds above 55 mph. The vehicle is driven very carefully and not harshly. As of today (11/14/2024), the vehicle is 77 months old and only has 49,000 miles on it. I had been told by Toyota that the rotors are not warped, so it must be a defective part in the braking system.

While driving the car at approximately 40 mphs the car suddenly jolted and stopped moving. Luckily no one was behind and I pulled over also noticing check engine light came on. I immediately called Toyota and was able to drive it to them. I spent $140 diagnosis fees for them to say it was ignition coil B. After replacing the coil the light and same problems continued. We took the car to another mechanic, spent $600 diagnosis fees to find out it is the ECM. We then contacted the Toyota dealer asking about previous recalls that were on the ECM for 2018 Toyota Highlanders which is our car. They stated our car based off the VIN has no recalls. How could this recall be for 2018 Toyota Highlanders but not for our 2018 Toyota Highlander with the same issues? Our car only has 80,000 miles.

The 2018 Toyota Highlander has less than 100K miles on it and has been diagnosed with an $11K repair for essentially a new engine! The dealership (Coughlin Toyota, Heath OH) has said it needs cylinder head assembly for $10,684.20. The error message we are getting is a "Check Engine" light "Take Vehicle to Dealership" and the AWD/ Traction Control shuts off. When searching online forums, there are MANY people experiencing the same problem, apparently a well know issue with Toyota (not just Highlanders). We have only owned this vehicle for a few years and believe this is a manufacturer error that desperately needs investigated. Please.

Brake Booster did not work. We were almost in 2 wrecks due to it taking longer to stop the vehicle. The dealer finally fixed it after I paid over $1500. They didn't care about how this was a known defect in 2018 Toyota Highlanders and took forever to identify and fix. No one has looked at it since just got it back today. Once the brake light went on the dash board I brought it in. I did wait one day when it went off, but once it came back on again I was going to, but then was scared when it didn't come on and then I could barely stop.

The 2018 engine (3.5L DOHC V6 D-4S Engine with Dual VVT-i Direct Shift) with 52,500 miles has by now (2024) developed a large oil leak coming from the valve cover to cam tower seal, and requires replacement of valve cover assembly and gasket priced at $2173.51 by a local Toyota dealer. I'm the original owner with the car always being garaged and maintained by the book at the dealer. Toyota of America is refusing any assistance with the defective engine component even though it is under the 60,000 miles powertrain warranty, but past the 60 months warranty period. The leak likely developed prior to the first 60 months of use, but was just now noticeable to the technician. Leaking engine oil on hot components of the engine bay may result in smoke, burning odor, and even fires.

The contact owns a 2018 Toyota Highlander. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, and it was determined that there was low compression in cylinder #1. The contact was informed that the engine was damaged and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 61,000.