NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
206 reports5,300 miles · Dec 6, 2013
Electrical System
I BOUGHT MY 2013 BRAND NEW 9/27/12. SHORTLY AFTER I RECEIVED IT I NOTICED SONGS WOULD SKIP OR START OVER ON THE IPOD AS WELL AS THE CD. A FEW MONTHS LATER THE RADIO STATION WOULD CHANGED CHANNELS FOR NO REASON. THESE THINGS HAPPENED IF I WAS BACKING OUT OF A PARKING SPACE, GOING OVER A SLIGHT BUMP OR JUST DRIVING NORMALLY ON…
Read full complaint
I BOUGHT MY 2013 BRAND NEW 9/27/12. SHORTLY AFTER I RECEIVED IT I NOTICED SONGS WOULD SKIP OR START OVER ON THE IPOD AS WELL AS THE CD. A FEW MONTHS LATER THE RADIO STATION WOULD CHANGED CHANNELS FOR NO REASON. THESE THINGS HAPPENED IF I WAS BACKING OUT OF A PARKING SPACE, GOING OVER A SLIGHT BUMP OR JUST DRIVING NORMALLY ON A REGULAR ROAD OR A FREEWAY. I'VE GONE TO TWO TOYOTA DEALERSHIP WHO CAN'T FIND ANY PROBLEM AND BECAUSE THE PROBLEMS ARE INTERMITTENT THEY SAY THEY CAN'T DIAGNOSE IT. I'VE HAD TWO CASEWORKERS AT TOYOTA OF AMERICA AND THEY SAY THERE IS NOTHING THEY CAN DO. IN THE PAST MONTH WHEN I PULLED IN THE GARAGE THE HEADLIGHT "SOMETIMES" TURN OFF WHEN I TURN OFF THE IGNITION. OTHER TIMES THEY STAY ON THE NORMAL 30 SECONDS. I'VE ALSO HAD A COUPLE OF ISSUES THAT OTHER HIGHLANDER OWNERS MENTIONED ON YOUR WEBSITE MAINLY WHEN I'M AT A STOP AND THE LIGHT TURNS GREEN A COUPLE OF TIMES WHEN I STEP ON THE GAS THE CAR ENGINE REVS A FEW SECONDS THEN LURCHES FORWARD. ALSO RECENTLY THE DASHBOARD LIGHTS DIM OR BRIGHTEN FOR NO REASON AT ALL. MY CONCERN IS THAT IT SEEMS PROBLEMS ARE INCREASING AND I JUST DON'T KNOW EXACTLY WHAT STEPS TO TAKE NEXT. *TR
NHTSA ODI #10555104
1,250 miles · Nov 30, 2013
Fuel System, GasolineVehicle Speed Control
WHEN DRIVING THE VEHICLE AT 35MPH WHEN YOU STEP ON THE GAS PEDAL THERE'S A DELAY ON ACCELERATION ESPECIALLY WHEN THE VEHICLE IS GOING UPHILL. IT STARTED WHEN THE VEHICLE MILEAGE WAS AT 1250 MILES ITS ON AND OFF. *TR
NHTSA ODI #10554216
4,600 miles · Nov 12, 2013
Service BrakesCrash
I STARTED MY VEHICLE, IN MY GARAGE, TO WARM IT UP FOR ITS FIRST SCHEDULED MAINTENANCE AT THE DEALERSHIP. THE PARKING BRAKE WAS ENGAGED FROM MY LAST USE OF THE VEHICLE THE NIGHT PRIOR (I ALWAYS APPLY THE PARKING BRAKE BEFORE EXITING MY CAR). AS MY HIGHLANDER WARMED UP, I BEGAN REMOVING A FEW PERSONAL ITEMS SO THAT THEY WOULD …
Read full complaint
I STARTED MY VEHICLE, IN MY GARAGE, TO WARM IT UP FOR ITS FIRST SCHEDULED MAINTENANCE AT THE DEALERSHIP. THE PARKING BRAKE WAS ENGAGED FROM MY LAST USE OF THE VEHICLE THE NIGHT PRIOR (I ALWAYS APPLY THE PARKING BRAKE BEFORE EXITING MY CAR). AS MY HIGHLANDER WARMED UP, I BEGAN REMOVING A FEW PERSONAL ITEMS SO THAT THEY WOULD BE OUT OF THE VEHICLE DURING MY SERVICE AT THE DEALERSHIP. I PLACED MY PERSONAL ITEMS AT THE END OF MY GARAGE, ADJACENT TO THE FRONT-END OF THE VEHICLE. AS I TURNED FOR MY 3RD TRIP BACK TO GET THE LAST OF MY PERSONAL ITEMS OUT, I SEE MY HIGHLANDER STARTING TO ROLL BACKWARDS. I WAS AT THE FRONT-END OF MY VEHICLE WHEN IT STARTED MOVING IN REVERSE. I WAS UNABLE TO SAFELY ENTER THE VEHICLE WHILE IT WAS IN REVERSE MOTION. MY VEHICLE BACKED UP OVER A CURB AND MADE IMPACT WITH BUSHES AND A BUILDING STRUCTURE. I QUESTION IF FAULTY CONSTRUCTION OF THE PARKING BRAKE ALLOWED IT TO DISENGAGE AND INDEPENDENTLY INITIATE MOVEMENT IN REVERSE. *LN *TR
NHTSA ODI #10551850
1,000 miles · Nov 8, 2013
EngineFuel/propulsion System
OCCASIONAL THROTTLE NO RESPONSE WHEN TRYING TO ACCELERATE MODERATELY FROM A STOP, OR FROM A VERY LOW SPEED (I.E.-COASTING AROUND A 90 DEGREE TURN WITH THE ENGINE AT IDLE SPEED.) I THEN PUSH HEAVILY ON THE ACCELERATOR PEDAL, AND IT REVS UP, DOWNSHIFTS, AND RACES AHEAD. IT IS DANGEROUS, IN TRAFFIC. I HAVE BROUGHT IT TO THE DEALE…
Read full complaint
OCCASIONAL THROTTLE NO RESPONSE WHEN TRYING TO ACCELERATE MODERATELY FROM A STOP, OR FROM A VERY LOW SPEED (I.E.-COASTING AROUND A 90 DEGREE TURN WITH THE ENGINE AT IDLE SPEED.) I THEN PUSH HEAVILY ON THE ACCELERATOR PEDAL, AND IT REVS UP, DOWNSHIFTS, AND RACES AHEAD. IT IS DANGEROUS, IN TRAFFIC. I HAVE BROUGHT IT TO THE DEALER TWICE, AND THEY CANNOT REPRODUCE THE PROBLEM. TWO SO CALLED FACTORY REPS RODE AROUND WITH ME THE SECOND TIME, WITH A COMPUTER CONNECTED. DIAGNOSTICS SHOWS NO ERROR CODES. *TR
NHTSA ODI #10551534
490 miles · Nov 2, 2013
EngineVehicle Speed Control
AT TOTALLY RANDOM TIMES, AFTER A FEW MILES OF DRIVING OR FROM A SLOW SPEED, VEHICLE HESITATES WHEN ACCELERATING. MOST ANNOYING AND DANGEROUS IS THE WAY IT DOESN'T RESPOND TO THE ACCELERATOR FOR A FEW SECONDS AFTER STOPPING AT A STOP SIGN OR STOP LIGHT OR WHEN GOING SLOWLY AS IN ENTERING THE FREEWAY. TOOK VEHICLE TO TOYOTA DEALE…
Read full complaint
AT TOTALLY RANDOM TIMES, AFTER A FEW MILES OF DRIVING OR FROM A SLOW SPEED, VEHICLE HESITATES WHEN ACCELERATING. MOST ANNOYING AND DANGEROUS IS THE WAY IT DOESN'T RESPOND TO THE ACCELERATOR FOR A FEW SECONDS AFTER STOPPING AT A STOP SIGN OR STOP LIGHT OR WHEN GOING SLOWLY AS IN ENTERING THE FREEWAY. TOOK VEHICLE TO TOYOTA DEALERSHIP AND OF COURSE VEHICLE RAN FINE FOR THE TIME THEY DROVE IT. TECH CHECKED FOR ANY TROUBLE CODES AND NONE WERE FOUND. THIS PROBLEM SEEMS LIKE AN ACCIDENT WAITING TO HAPPEN. HAVE GOTTEN NOTHING BUT THE RUN-AROUND AND DENIAL FROM THE NATIONAL TOYOTA "CASE MANAGER". (AT FIRST I THOUGHT THIS HESITATION OCCURRED BECAUSE THE VEHICLE WAS NEW, BUT AFTER 5,000 MILES, I AM STILL EXPERIENCING THE SAME ISSUE AT RANDOM TIMES.) *TR
NHTSA ODI #10550635
100 miles · Oct 22, 2013
Exterior Lighting
WHEN THE HEADLIGHTS ARE ON DIM, VISIBILITY IS NOT ADEQUATE. A DISTINCT BLACK LINE APPEARS ACROSS THE HORIZON ABOVE WHICH THE DRIVER CANNOT SEE. *TR
NHTSA ODI #10548868
Mileage unknown · Oct 18, 2013
Exterior LightingVisibility/wiper
I PURCHASED THE TOYOTA HIGHLANDER IN DECEMBER OF 2012. IMMEDIATELY WE KNEW SOMETHING WAS WRONG WITH THE HEADLIGHTS. THEY ARE FOCUSED DOWN TOWARD THE ROAD AND HAVE A LINE OF "SHADE" ABOVE. THE HIGHLANDER LIGHTS ARE SO DIM, WE DON'T KNOW IF THEY ARE WORKING. WE ARE "OVERDRIVING" OUR VISIBILITY AT NIGHT AND WE CANNOT SEE ANY ROA…
Read full complaint
I PURCHASED THE TOYOTA HIGHLANDER IN DECEMBER OF 2012. IMMEDIATELY WE KNEW SOMETHING WAS WRONG WITH THE HEADLIGHTS. THEY ARE FOCUSED DOWN TOWARD THE ROAD AND HAVE A LINE OF "SHADE" ABOVE. THE HIGHLANDER LIGHTS ARE SO DIM, WE DON'T KNOW IF THEY ARE WORKING. WE ARE "OVERDRIVING" OUR VISIBILITY AT NIGHT AND WE CANNOT SEE ANY ROAD SIGNS BECAUSE THE LIGHTS ARE FOCUSED TO FAR DOWN THEY DO NOT ILLUMINATE SIGNS ON THE SIDE OF THE ROAD. IN ADDITION, IN HILLY AREAS, THEY ONLY ILLUMINATE THE BOTTOM OF THE HILL (AND THE SHADED PART IS ABOVE) SO YOU CANNOT SEE WHERE YOU ARE HEADED.THE TOPS OF THE HILLS ARE COMPLETELY BLOCKED BY THE "SHADED" PART. THIS IS A VERY DANGEROUS SITUATION! ALSO, THEY DO NOT GET WARM, SO THE SNOW AND ICE ACCUMULATES ON THESE LIGHTS AND OBSCURES VISIBILITY EVEN FURTHER! I HAVE OWNED MANY MANY CARS, INCLUDING SEVERAL TOYOTA'S AND HAVE NEVER HAD A HEADLIGHT PROBLEM. I DO NOT KNOW WHAT TO DO WITH THIS CAR AS I CANNOT DRIVE IT AT NIGHT. *TR
NHTSA ODI #10548358
24,000 miles · Oct 2, 2013
Air BagsService BrakesVehicle Speed ControlCrash
PULLING INTO PARKING SPACE - BRAKES APPLIED - CAR LURCHED FORWARD (UNINTENDED ACCELERATION) - BRAKES DID NOT ENGAGE - CAR JUMPED THE CURB, CROSSED THE SIDEWALK AND HIT A TREE - AIRBAG DID NOT DEPLOY. *TR
NHTSA ODI #10546569
300 miles · Sep 19, 2013
Equipment
WHILE DRIVING TO MICHIGAN FROM ILLINOIS WHILE USING VEHICLE BUILD IN JBL NAVIGATION UNIT ON A NEWLY PURCHASED 2013 TOYOTA HIGHLANDER LIMITED WITH ONLY 300 MILES AT THE TIME, IN THE MIDDLE OF THE TRIP NAVIGATION UNIT REBOOTED/CRASHED AFTER COMING BACK UP THE PROGRAMMED DIRECTIONS WERE LOST, SINCE THIS NAVIGATION UNIT HAS A PROGRA…
Read full complaint
WHILE DRIVING TO MICHIGAN FROM ILLINOIS WHILE USING VEHICLE BUILD IN JBL NAVIGATION UNIT ON A NEWLY PURCHASED 2013 TOYOTA HIGHLANDER LIMITED WITH ONLY 300 MILES AT THE TIME, IN THE MIDDLE OF THE TRIP NAVIGATION UNIT REBOOTED/CRASHED AFTER COMING BACK UP THE PROGRAMMED DIRECTIONS WERE LOST, SINCE THIS NAVIGATION UNIT HAS A PROGRAMMED SAFETY FEATURE THE DESTINATION CANNOT BE RE-PROGRAMMED WHILE DRIVING, WE HAVE TO EXIT THE HIGHWAY AND STOP TO REPROGRAM THE DESTINATION AGAIN, ALSO THE SAME ISSUE HAPPENED ON THE WAY BACK. TOYOTA CUSTOMER SERVICE HAS BEEN CONTACTED AND THE CASE WAS OPEN (#1308280087) THEY ADVISE ME TO TAKE THE VEHICLE TO A DEALER, SO THE DEALER CAN CONTACT TOYOTA TECHNICIAN AND TRY TO ISOLATE AN ISSUE. SERVICE MANAGER CONTACTED THE TECHNICIAN WHO STATED THE PROBLEM HAS TO BE REPRODUCED; OTHERWISE THERE IS NOTHING THEY CAN DO. LOOKS LIKE THIS ISSUE ONLY HAPPENS ON LONG TRIPS, WHICH IS IMPOSSIBLE FOR THE DEALER TO REPRODUCE USING MY VEHICLE. TOYOTA CUSTOMER SERVICE HAS BEEN CONTACTED AGAIN ABOUT THE ISSUE; TOYOTA IS IGNORING THE PROBLEM THAT HAS BEEN REPORTED ON MULTIPLE FORUM SIDES AND UNWILLING TO WORK OUT A RESOLUTION BY DUPLICATING THE ISSUE IN-HOUSE. ALSO THE NAVIGATION UNIT DOES HAVE AN OUTDATED MAPS (HALF OF THE ADDRESSES THAT I HAVE ENTERED COULD NOT BE LOCATED) AND UPDATE IS NOT BEEN OFFERED AFTER THE COMPLAINT. JBL NAVIGATION SOFTWARE VERSION: 2.2.0 NAV ID: NQNA2011Q4. *TR
NHTSA ODI #10544457
1,146 miles · Sep 18, 2013
Engine
WHEN TURNING LEFT OUT OF MY NEIGHBORHOOD I SLOWED DOWN AND THEN TRIED TO RETURN TO SPEED BUT THE VEHICLE HESITATED THEN SUDDENLY JERKED UP TO THE DESIRED SPEED. ONE OTHER TIME ON AN INTERSTATE I HAD TO SLOW DOWN BEHIND A TRUCK AND THEN WHEN I TRIED TO ACCELERATE BACK TO SPEED IN THE PASSING LANE THE CAR HESITATED FOR SEVERAL SEC…
Read full complaint
WHEN TURNING LEFT OUT OF MY NEIGHBORHOOD I SLOWED DOWN AND THEN TRIED TO RETURN TO SPEED BUT THE VEHICLE HESITATED THEN SUDDENLY JERKED UP TO THE DESIRED SPEED. ONE OTHER TIME ON AN INTERSTATE I HAD TO SLOW DOWN BEHIND A TRUCK AND THEN WHEN I TRIED TO ACCELERATE BACK TO SPEED IN THE PASSING LANE THE CAR HESITATED FOR SEVERAL SECONDS AND AGAIN ACCELERATED RAPIDLY (CARS IN THE PASSING LANE HAD TO BRAKE QUICKLY. I COULD DESCRIBE OTHER TIMES BUT THE SAME THING (THE HESITATION AND THEN THE EXTREMELY RAPID ACCELERATION) I HAVE TAKEN IT DO THE DEALER BUT THEY SAID THAT THEY COULD NOT FIND ANYTHING.
NHTSA ODI #10544226
Official recalls
3Mar 27, 2014
Toyota is recalling certain model year 2013 Highlander vehicles manufactured March 13, 2013, through August 6, 2013. In the affected vehicles, the second row left hand seat may not lock in place when positioned in the forward front or second adjusting position. As such, the vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: If the seat does not lock into the seat track, there may be an increased risk of injury to an occupant in the event of a crash.
Remedy: Toyota will notify owners, and dealers will modify the second row left hand seat so that it will lock into the seat track, free of charge. The recall began on May 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18006 · Steering Column Separation
Opened Nov 16, 2018 · Closed Apr 2, 2024
Status: closed (inferred from source dates) · Steering; Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18005 · Upper Steering Column Separation
Opened May 4, 2018 · Closed Nov 20, 2018
Status: closed (inferred from source dates) · Steering; Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Additional source detail variants (2)
Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Steering
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Illustration