IllustrationAS I BEGIN DRIVING AND COME TO STOP IT TENDS TO REV UP AND THEN DROPS BACK TO NORMAL. IT FEELS LIKE VEHICLE REVS UP A LITTLE WHILE YOU ARE TRYING TO STOP IT BY PRESSING THE BRAKE PEDAL.IT FEELS LIKE VEHICLE DOES NOT WANT TO STOP AND YOU HAVE THE FEELINGS TO PRESS THE BRAKE EVEN HARDER.
2013 Toyota Highlander
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2013 Toyota Highlander do not stand out strongly from the model-year median of 186.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Highlander years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
670–25K
3325–50K
3350–75K
1275–100K
11100–150K
3150K+
159 reports with mileage · 47 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports0 fire reports12 injury reports
Power Train complaints
11 reportsHEAD GASKET LEAKED CAR LESS THAN 100K MILES AND LESS THAN 5 YEARS. GOOGLE SEARCH SHOWED SIMILAR PROBLEMS WITH OTHER HIGHLANDERS.
I AM ASKING THAT THE NHTSA INVESTIGATE THE 2013 HIGHLANDER LIMITED FOR THE ABILITY TO TURN OFF THE CAR WHILE IN "DRIVE" AFTER PARKING. WE PURCHASED OUR CAR NEW FORM THE DEALER, AND EVER SINCE WE HAVE BEEN ABLE TO TURN THE CAR OFF THE VEHICLE AFTER PARKING BUT IN "DRIVE" WHICH HAS LED TO THE CAR UNINTENTIONALLY ROLLING DOWNHILL …
Read full complaint
I AM ASKING THAT THE NHTSA INVESTIGATE THE 2013 HIGHLANDER LIMITED FOR THE ABILITY TO TURN OFF THE CAR WHILE IN "DRIVE" AFTER PARKING. WE PURCHASED OUR CAR NEW FORM THE DEALER, AND EVER SINCE WE HAVE BEEN ABLE TO TURN THE CAR OFF THE VEHICLE AFTER PARKING BUT IN "DRIVE" WHICH HAS LED TO THE CAR UNINTENTIONALLY ROLLING DOWNHILL ON SEVERAL TIMES. ON TWO OCCASIONS IT HAS LED TO THE CAR NOT RESTARTING. WE HAVE ASKED OUR LOCAL DEALER AND SERVICE PEOPLE, AT TOYOTA OF SEATTLE, ABOUT THIS SEVERAL TIMES AND HAVE BEEN TOLD, ALBEIT WITH INCONSTANT REASONING, THAT THE CAR WAS DESIGNED TO HAVE THIS CAPABILITY. WE HAVE TWO SMALL CHILDREN AND TO US THIS SEEM EXTREMELY DANGEROUS, AS THE ONLY WAY TO BE ALERTED TO THE FACT THAT YOU'VE LEFT THE CAR IN "DRIVE", OTHER THAN THE VEHICLE ROLLING, IS A BEEP SOUND. HOWEVER, THIS BEEP IS THE EXACT SAME SOUND ALERT YOU GET WHEN YOUR LIGHTS ARE ON, OR A DOOR IS OPEN, OR YOU'RE RUNNING OUT OF GAS -- MAKING IT A COMMON SOUND THAT DOES NOT SIGNIFY A DANGEROUS SITUATION. ALSO, OFTEN THIS SOUND DOES NOT REGISTER IN THE BRAIN UNTIL YOU ARE OUT OF THE VEHICLE, BECAUSE THE SAME SOUND IS USED TO ALERT THAT A DOOR HAS BEEN OPENED BEFORE THE CAR WAS TURNED OFF. IN WHICH CASE, THE NOISE GOES AWAY AFTER YOU GET OUT AND CLOSE THE DOOR. WE HAVE HAD SEVERAL OCCASIONS WHERE OUR CHILDREN HAVE GOTTEN OUT OF THE PARKED VEHICLE WHILE WE'RE TRYING TO DETERMINE THE SOURCE OF THE BEEP AND THEN THE CAR WILL START ROLLING. I AM A CAREFUL PERSON, SO GIVEN MY INNUMERABLE CLOSE CALLS WITH THIS ISSUE I ENCOURAGE YOU TO INVESTIGATE THIS ISSUE BEFORE SOMEONE IS KILLED. THANK YOU OF YOUR TIME. SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNS A 2013 TOYOTA HIGHLANDER. WHILE THE VEHICLE WAS BEING REVERSED, THE HATCHBACK OPEN WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE GEAR SHIFT LEVER WAS PLACED IN PARK BEFORE EXITING THE VEHICLE. WHILE ATTEMPTING TO CLOSE THE HATCH, THE VEHICLE STARTED TO ROLL BACKWARDS AND KNOCKED THE CONTACT TO THE G…
Read full complaint
TL* THE CONTACT OWNS A 2013 TOYOTA HIGHLANDER. WHILE THE VEHICLE WAS BEING REVERSED, THE HATCHBACK OPEN WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE GEAR SHIFT LEVER WAS PLACED IN PARK BEFORE EXITING THE VEHICLE. WHILE ATTEMPTING TO CLOSE THE HATCH, THE VEHICLE STARTED TO ROLL BACKWARDS AND KNOCKED THE CONTACT TO THE GROUND. THE VEHICLE ROLLED DOWN AN EMBANKMENT AND CRASHED INTO A TREE. THE CONTACT SUSTAINED INJURIES TO THE HIP AND ARMS, WHICH DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT TOWED FROM THE CRASH SITE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 39,000. UPDATED 09/01/16*LJ
TL* THE CONTACT OWNS A 2013 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 75 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE TRANSMISSION. IN ADDITION, THE FAILURE OCCURRED WHEN DRIVING 40 MPH OR HIGHER. THE CONTACT MENTIONED THAT THE VEHICLE WAS SERVICED UNDER A MANUFACTURER WARRANTY FOR THE TRANSMI…
Read full complaint
TL* THE CONTACT OWNS A 2013 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 75 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE TRANSMISSION. IN ADDITION, THE FAILURE OCCURRED WHEN DRIVING 40 MPH OR HIGHER. THE CONTACT MENTIONED THAT THE VEHICLE WAS SERVICED UNDER A MANUFACTURER WARRANTY FOR THE TRANSMISSION IN NOVEMBER OF 2015. THE CONTACT STATED THAT THE TRANSMISSION UTILIZED WAS REBUILT. THE DEALER DIAGNOSED THAT THE TRANSMISSION UTILIZED FOR THE REPAIR MET THE MANUFACTURER STANDARDS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200.
FROM STOP (AT TRAFFIC LIGHT, MERGING, ETC), PRESS ON GAS PEDAL FOR ACCELERATION AND VEHICLE DOES NOT GO, HESITATES, THEN DOES ACCELERATE. THIS HAS HAPPENED MULTIPLE TIMES, INTERMITTENTLY, AND HAS BEEN REPORTED TO TITUS WILL TOYOTA DEALERSHIP. SINCE THEY HAVE NOT DUPLICATED IT, PROBLEM CONTINUES INTERMITTENTLY. NEVER KNOW WHE…
Read full complaint
FROM STOP (AT TRAFFIC LIGHT, MERGING, ETC), PRESS ON GAS PEDAL FOR ACCELERATION AND VEHICLE DOES NOT GO, HESITATES, THEN DOES ACCELERATE. THIS HAS HAPPENED MULTIPLE TIMES, INTERMITTENTLY, AND HAS BEEN REPORTED TO TITUS WILL TOYOTA DEALERSHIP. SINCE THEY HAVE NOT DUPLICATED IT, PROBLEM CONTINUES INTERMITTENTLY. NEVER KNOW WHEN THIS WILL OCCUR. IT IS VERY DISCONCERTING AND DANGEROUS. THIS VEHICLE HAS A LOT OF "COMPUTER" GLITCHES WITH GPS MAPPING, BLUETOOTH, AUTO LIGHTS, ETC. MAYBE RELATED?
TL* THE CONTACT OWNS A 2013 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE VEHICLE HESITATED WHEN ACCELERATING FROM A STOP OR A BREAK WITHOUT WARNING. THE FAILURE RECURRED SEVERAL TIMES AND, EACH TIME, THE CONTACT HAD TO PUMP THE ACCELERATOR PEDAL UP TO THREE TIMES IN ORDER TO ACCELERATE. THE VEHICLE WAS TAKEN TO A LOCAL DEALER …
Read full complaint
TL* THE CONTACT OWNS A 2013 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE VEHICLE HESITATED WHEN ACCELERATING FROM A STOP OR A BREAK WITHOUT WARNING. THE FAILURE RECURRED SEVERAL TIMES AND, EACH TIME, THE CONTACT HAD TO PUMP THE ACCELERATOR PEDAL UP TO THREE TIMES IN ORDER TO ACCELERATE. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO DIAGNOSED THAT ONE OF THE COMPUTER MODULES THAT REGULATED ACCELERATION WAS FAULTY. THE DEALER COULD NOT DETERMINE WHICH OF THE MODULES WAS FAULTY; THEREFORE, THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ISSUED A CASE NUMBER TO TAKE TO THE DEALER. THE FAILURE MILEAGE WAS 17,000.
TL* THE CONTACT OWNS A 2013 TOYOTA HIGHLANDER. WHILE ATTEMPTING TO ACCELERATE FROM A STOP, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE HESITATED. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. TH…
Read full complaint
TL* THE CONTACT OWNS A 2013 TOYOTA HIGHLANDER. WHILE ATTEMPTING TO ACCELERATE FROM A STOP, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE HESITATED. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 16,000. MA 10/25/15
PURCHASED 2013 TOYOTA HIGHLANDER 11/24/12; TRANSMISSION HAS MALFUNCTIONED APPROXIMATELY 16 TIMES SINCE DATE OF PURCHASE. WHEN REDUCING SPEED TO APPROXIMATELY 30 TO10 M.P.H. AND THEN TRY TO ACCELERATE, THE TRANSMISSION APPEARS TO GO INTO NEUTRAL; THE DRIVE STICK REMAINS IN DRIVE! WHEN THIS HAPPENS, I SHIFT DRIVE STICK TO NEUTRAL …
Read full complaint
PURCHASED 2013 TOYOTA HIGHLANDER 11/24/12; TRANSMISSION HAS MALFUNCTIONED APPROXIMATELY 16 TIMES SINCE DATE OF PURCHASE. WHEN REDUCING SPEED TO APPROXIMATELY 30 TO10 M.P.H. AND THEN TRY TO ACCELERATE, THE TRANSMISSION APPEARS TO GO INTO NEUTRAL; THE DRIVE STICK REMAINS IN DRIVE! WHEN THIS HAPPENS, I SHIFT DRIVE STICK TO NEUTRAL AND THEN BACK TO DRIVE AND THEN TRANSMISSION CONTINUES TO WORK FINE. I DON'T THINK YOU HAVE TO EXTEND YOUR IMAGINATION TOO FAR TO REALIZE THE POSSIBILITY OF SERIOUS INJURY OR DEATH WHEN MAKING A TURN OR TRYING TO PASS SOMEONE! DEALER WILL NOT ACKNOWLEDGE THERE IS A PROBLEM WITH TRANSMISSION. THE INITIAL RESPONSE FROM DEALER WAS THE TRANSMISSION HAS TO ADJUST TO MY DRIVING HABITS? IF YOU CHECK CARCOMPLAINTS.COM OR EDMONDS.COM, YOU WILL SEE I AM NOT THE ONLY ONE WITH THIS PROBLEM. IT APPEARS THIS PROBLEM HAS EXISTED SINCE 2004. IT WOULD BE INTERESTING TO REVIEW PAST HEAD ON COLLISIONS AND TURN ACCIDENTS TO CONSIDER IF IT WAS "DRIVER ERROR" VS "TRANSMISSION FAILURE" I WOULD LIKE TO BE CONTACTED TO HAVE FURTHER DISCUSSION ON THIS PROBLEM. THANK YOU *TR UPDATED 02/20/2015 *JS
I PURCHASED A NEW 2013 TOYOTA HIGHLANDER LIMITED IN NOVEMBER 2013. A FEW DAYS LATER, UPON ACCELERATING FROM A STOP INTO A LEFT TURN, THE ENGINE CUT OFF FOR A FEW SECONDS WHILE ENTERING TRAFFIC. THIS HAPPENED A COUPLE MORE TIMES BEFORE THE FIRST CHECKUP, AT WHICH TIME I INFORMED THE SERVICE TECHNICIAN, PROBLEM WAS NOTED ON SER…
Read full complaint
I PURCHASED A NEW 2013 TOYOTA HIGHLANDER LIMITED IN NOVEMBER 2013. A FEW DAYS LATER, UPON ACCELERATING FROM A STOP INTO A LEFT TURN, THE ENGINE CUT OFF FOR A FEW SECONDS WHILE ENTERING TRAFFIC. THIS HAPPENED A COUPLE MORE TIMES BEFORE THE FIRST CHECKUP, AT WHICH TIME I INFORMED THE SERVICE TECHNICIAN, PROBLEM WAS NOTED ON SERVICE SHEET, BUT WHEN SERVICE WAS COMPLETED, THEY SAID THEY COULD FIND NO PROBLEM. THE HESITATION CONTINUED, QUITE RANDOMLY, AND SEEMED TO HAPPEN IN LEFT TURN, ACCELERATING SITUATIONS. AT NEXT SERVICE AND CHECKUP (DIFFERENT DEALER) I TOLD THEM ABOUT THE PROBLEM AND IT WAS WRITTEN UP AGAIN WITH SAME RESULT, NO PROBLEM COULD BE FOUND. THIS HAS BEEN REPORTED TO DEALER AT LEAST THREE TIMES, NO RESULTS, NO ACTION TAKEN, NO PROBLEM FOUND. I CONSIDER THIS A DANGEROUS SITUATION, ESPECIALLY WHEN MERGING INTO TRAFFIC. BASED ON INFORMATION I HAVE SEEN, IT APPEARS THAT TOYOTA SHOULD ADDRESS THIS PROBLEM ASAP. *TR
Official recalls
314V148000 · Seats
Mar 27, 2014
Toyota is recalling certain model year 2013 Highlander vehicles manufactured March 13, 2013, through August 6, 2013. In the affected vehicles, the second row left hand seat may not lock in place when positioned in the forward front or second adjusting position. As such, the vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: If the seat does not lock into the seat track, there may be an increased risk of injury to an occupant in the event of a crash.
Remedy: Toyota will notify owners, and dealers will modify the second row left hand seat so that it will lock into the seat track, free of charge. The recall began on May 21, 2014. Owners may contact Toyota at 1-800-331-4331.
13V123000 · Equipment:other:labels
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
13V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18006 · Steering Column Separation
Opened Nov 16, 2018 · Closed Apr 2, 2024
Status: closed (inferred from source dates) · Steering; Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18005 · Upper Steering Column Separation
Opened May 4, 2018 · Closed Nov 20, 2018
Status: closed (inferred from source dates) · Steering; Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Additional source detail variants (2)
Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Steering
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.