NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
12 reportsClear category filterMileage unknown · Jul 27, 2025
Fuel/propulsion System
A persistent smell of fuel occurred while in slow moving traffic and after vehicle was parked after use. Upon close inspection, the fuel injector fuel rail end cap exhibited a slow fuel leak. This component caused a recall for year model highlanders for 2014 production year describing the same type of component failure. The comp…
Read full complaint
A persistent smell of fuel occurred while in slow moving traffic and after vehicle was parked after use. Upon close inspection, the fuel injector fuel rail end cap exhibited a slow fuel leak. This component caused a recall for year model highlanders for 2014 production year describing the same type of component failure. The component has faulty end cap weldment that fails, causing the same failure mode being observed in my highlander. This is a fire hazard! Fuel rails should not be failing like this. A replacement fuel rail assembly has been order from Salinas Toyota. The original component can be made available for inspection/testing. I will also take a video of the leak and provide file upon request.
NHTSA ODI #11676467
Mileage unknown · Jul 5, 2024
EngineFuel/propulsion System
I purchased the car in 2020 with 73K miles on it. It has sporadically had incidents of unintended acceleration. I happens when I slow for a stop sign, red light, or crosswalk. My foot is on the brake when this occurs, the engine then goes into high gear and no amount of pressure on the brake will stop it. I put the car in pa…
Read full complaint
I purchased the car in 2020 with 73K miles on it. It has sporadically had incidents of unintended acceleration. I happens when I slow for a stop sign, red light, or crosswalk. My foot is on the brake when this occurs, the engine then goes into high gear and no amount of pressure on the brake will stop it. I put the car in park and turn the key off. There are no warning lights. It has happened more frequently in 2024. On [XXX], I tried to come to a stop at a crosswalk in Plymouth MA. The UA occurred, putting the folks in the crosswalk and myself in danger. The next day I contacted the dealer and Toyota. The upshot - they said the car is fine, it must be my mats or shoes or something that is not their fault. I've been driving Toyotas for 40 years, I've never had a mat or shoe problem. There is something faulty with the acceleration/braking system. The last occurrence was [XXX] in Plympton MA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11599219
Mileage unknown · Jul 10, 2021
Fuel/propulsion System
My car will stall with no warning. I have taken my car multiple times to the dealership and the problem has not been able to be repaired. There have been other years of Toyota recalled for this exact same problem however, mine has not been. This is a serious safety concern!
NHTSA ODI #11424211
371,500 miles · Feb 3, 2017
Fuel System, GasolineFuel/propulsion System
AT 37,500 MILES WHILE MOVING THE CHECK ENGINE AN TRACTOR OFF WARNING LIGHT CAME ON. THE DEALER CHARGED $125.00 TO REPLACE THE GAS CAP. IF THIS IS A SYSTEMIC PROBLEM WITH TOYOTA I BELIEVE IT SHOULD BE RECALLED. THANK YOU *TR
NHTSA ODI #10949221
63,000 miles · Jan 16, 2017
EngineFuel/propulsion System
UPON ENTERING INTO CAR AFTER IT HAD BEEN PARKED I SMELLED GASOLINE. WIFE SAID SHE HAD JUST FILLED UP BEFORE COMING HOME AND PERHAPS SPILLED SOME. I GOT OUT OF VEHICLE AND CHECKED AND SAW SMALL PUDDLE OF GASOLINE WHERE CAR HAD BEEN PARKED. MOVED CAR AWAY FROM HOUSE AND RAISED HOOD TO VENT ENGINE COMPARTMENT. I REMOVED FRONT S…
Read full complaint
UPON ENTERING INTO CAR AFTER IT HAD BEEN PARKED I SMELLED GASOLINE. WIFE SAID SHE HAD JUST FILLED UP BEFORE COMING HOME AND PERHAPS SPILLED SOME. I GOT OUT OF VEHICLE AND CHECKED AND SAW SMALL PUDDLE OF GASOLINE WHERE CAR HAD BEEN PARKED. MOVED CAR AWAY FROM HOUSE AND RAISED HOOD TO VENT ENGINE COMPARTMENT. I REMOVED FRONT SKID PLATE/PANEL TO FIND LEAK AND ALLOW FURTHER AIR CIRCULATION. I POWER CYCLED KEY AND SAW FUEL LEAK AGAIN. AFTER FURTHER INVESTIGATION FOUND WERE MAIN FUEL LINE WAS MISTING ONTO ENGINE AND SURROUNDING PARTS. LEAKS WERE COMING FROM MIDDLE PORTION OF HOSE AND NOT AT CONNECTIONS. NEXT DAY I HAD MY CAR TOWED TO THE DEALER. THEY SUSPECTED RODENT DAMAGE. UPON INSPECTION THERE WAS NO EVIDENCE OF "CHEWING" OR OTHER TYPE OF EXTERNAL DAMAGE. A REPLACEMENT LINE WAS ORDERED AND INSTALLED. I WAS CHARGED FOR THE REPAIRS. I HAVE KEPT THE ORIGINAL FUEL LINE FOR FURTHER INVESTIGATION. DEALER HAD NO EXPLANATION OF THE CAUSE OF THE FAILURE. I FEEL BLESSED THAT WE DID STOP WHEN WE DID OTHERWISE IT WOULD OF RESULTED IN AN GASOLINE FED ENGINE FIRE BECAUSE OF THE GAS SPRAYING ONTO THE EXHAUST AND OTHER HOT ENGINE PARTS IN A CONFINED AREA.
NHTSA ODI #10945482
5,000 miles · Aug 19, 2016
EngineFuel/propulsion SystemUnknown Or Other
VEHICLE HESITATES WHEN ACCELERATING, USUALLY WHEN MAKING A TURN FROM A STOP OR MOVING SLOWLY. IT IS ESPECIALLY HAZARDOUS WHEN TRYING TO MAKE A LEFT TURN IN FRONT OF ONCOMING TRAFFIC. HAS HAPPENED MULTIPLE TIMES, NOT JUST THE DATE BELOW. THE DEALER CAN NOT DUPLICATE THE PROBLEM. WE BOUGHT THE CAR IN EARLY 2014 NEW, AND NOTICED T…
Read full complaint
VEHICLE HESITATES WHEN ACCELERATING, USUALLY WHEN MAKING A TURN FROM A STOP OR MOVING SLOWLY. IT IS ESPECIALLY HAZARDOUS WHEN TRYING TO MAKE A LEFT TURN IN FRONT OF ONCOMING TRAFFIC. HAS HAPPENED MULTIPLE TIMES, NOT JUST THE DATE BELOW. THE DEALER CAN NOT DUPLICATE THE PROBLEM. WE BOUGHT THE CAR IN EARLY 2014 NEW, AND NOTICED THIS PROBLEM BEFORE 5,000 MILES. THE CAR NOW HAS 22,000 MILES AND IT STILL DOES THIS INTERMITTENTLY.
NHTSA ODI #10897242
16,000 miles · Dec 14, 2015
Fuel/propulsion SystemPower TrainVehicle Speed Control
FROM STOP (AT TRAFFIC LIGHT, MERGING, ETC), PRESS ON GAS PEDAL FOR ACCELERATION AND VEHICLE DOES NOT GO, HESITATES, THEN DOES ACCELERATE. THIS HAS HAPPENED MULTIPLE TIMES, INTERMITTENTLY, AND HAS BEEN REPORTED TO TITUS WILL TOYOTA DEALERSHIP. SINCE THEY HAVE NOT DUPLICATED IT, PROBLEM CONTINUES INTERMITTENTLY. NEVER KNOW WHE…
Read full complaint
FROM STOP (AT TRAFFIC LIGHT, MERGING, ETC), PRESS ON GAS PEDAL FOR ACCELERATION AND VEHICLE DOES NOT GO, HESITATES, THEN DOES ACCELERATE. THIS HAS HAPPENED MULTIPLE TIMES, INTERMITTENTLY, AND HAS BEEN REPORTED TO TITUS WILL TOYOTA DEALERSHIP. SINCE THEY HAVE NOT DUPLICATED IT, PROBLEM CONTINUES INTERMITTENTLY. NEVER KNOW WHEN THIS WILL OCCUR. IT IS VERY DISCONCERTING AND DANGEROUS. THIS VEHICLE HAS A LOT OF "COMPUTER" GLITCHES WITH GPS MAPPING, BLUETOOTH, AUTO LIGHTS, ETC. MAYBE RELATED?
NHTSA ODI #10809977
17,000 miles · Aug 26, 2015
Fuel/propulsion System
UPON ACCELERATION THE VEHICLE HESITATES FOR 3-5 SECONDS, IT HAS HAPPENED NUMEROUS TIMES. WENT TO THE DEALER AND THEY SAY NOTHING WRONG. VERY DANGEROUS PULLING INTO A HIGHWAY.
NHTSA ODI #10759535
7,600 miles · Jul 28, 2015
Electrical SystemEngineFuel/propulsion System
I PURCHASED THE 2013 HIGHLANDER NEW FROM A DEALER IN VIENNA, VA IN JULY 2013. THE AUTO STARTED A STRING OF ENGINE HESITANCY TO ACCELERATE PROBLEMS AT AROUND 5,000 MILES WHICH WAS REPORTED TO THE DEALER AT THE 5,000 MILE CHECK-UP AND AGAIN AT THE 7,500 MILE CHECKUP. THE SERVICE DEPARTMENT COULD NOT DUPLICATE THE PROBLEM AND GAVE …
Read full complaint
I PURCHASED THE 2013 HIGHLANDER NEW FROM A DEALER IN VIENNA, VA IN JULY 2013. THE AUTO STARTED A STRING OF ENGINE HESITANCY TO ACCELERATE PROBLEMS AT AROUND 5,000 MILES WHICH WAS REPORTED TO THE DEALER AT THE 5,000 MILE CHECK-UP AND AGAIN AT THE 7,500 MILE CHECKUP. THE SERVICE DEPARTMENT COULD NOT DUPLICATE THE PROBLEM AND GAVE THE ENGINE A CLEAN BILL OF HEALTH. WE MOVED TO MN IN MAY 2014 AND THE HESITANCY OF THE CAR TO MOVE (ACCELERATE) FROM A STOPPED POSITION FOR SEVERAL SECONDS AFTER ENGAGING THE GAS PETAL CONTINUES AND IS INCREASING IN FREQUENCY. THE CAR HAS BEEN TAKEN IN TO THE LOCAL TOYOTA DEALER ON THREE OCCASIONS WITH THE SAME ANSWER THAT THERE IS NO PROBLEM WITH THE CAR. I HAVE BEEN IN TWO NEAR ACCIDENTS WHILE PULLING OUT IN TRAFFIC ON TO A HIGH SPEED DIVIDED HIGHWAY AND CONSIDER THIS A VERY SERIOUS SAFETY ISSUE. IT HAPPENS RANDOMLY, (THREE TIMES THIS PAST WEEK), BUT A PATTERN HAS DEVELOPED - MOST INCIDENTS OCCUR WHILE IDLING AT INTERSECTIONS FOR SOME TIME WAITING FOR TRAFFIC TO CLEAR, TRAFFIC LIGHTS, ETC, AND THEN MAKING A LEFT HAND TURN ONTO THE ROADWAY. THE CAR HAS EXHIBITED THIS BEHAVIOR ONLY A COUPLE TIMES WHILE MAKING A RIGHT HAND TURN FROM A IDLING START. THE SENSATION IS THAT THE ENGINE STALLED AND NO MATTER WHAT IS DONE WITH THE GAS PETAL NOTHING HAPPENS FOR ANYWHERE UP TO 4-5 SECONDS. WITH TRAFFIC MOVING AT 60 MILES AN HOUR AND ONE IS ATTEMPTING TO MERGE INTO TRAFFIC, A FIVE SECOND DELAY BRINGS THE ON-COMING TRAFFIC ALMOST 450 FEET CLOSER TO ONE BEFORE THE CAR STARTS TO MOVE REQUIRING MORE DISTANCE IN TRAFFIC GAPS TO OVERCOME A POTENTIAL STALL IN THE ROADWAY. I HAVE COME ACROSS ANOTHER LOCAL OWNER WITH THE SAME PROBLEM AND NOTE AT LEAST 15 OTHER COMPLAINTS ON THE WEB OF ALMOST THE EXACT CIRCUMSTANCES. WHAT DOES IT TAKE FOR TOYOTA TO RECOGNIZE THIS AS A SAFETY ISSUE? UPDATED 12/12/2017*CN
NHTSA ODI #10744308
10 miles · Apr 6, 2015
Fuel/propulsion SystemVehicle Speed Control
EVERY TIME I SWITCH FROM BRAKE TO GAS PEDAL QUICKLY, THE CAR LOOSES POWER AS IF TO STALL. THEN IT REGAINS POWER AND ACCELERATES. IT ALSO HAPPENS IF I AM ON THE HIGHWAY AND TOUCH THE BRAKE PEDAL BEFORE ATTEMPTING TO PASS AND THEN I CAN'T GET POWER TO PASS FOR A COUPLE SECONDS. VERY SCARY AND DANGEROUS I THINK. THE DEALER EXPLAI…
Read full complaint
EVERY TIME I SWITCH FROM BRAKE TO GAS PEDAL QUICKLY, THE CAR LOOSES POWER AS IF TO STALL. THEN IT REGAINS POWER AND ACCELERATES. IT ALSO HAPPENS IF I AM ON THE HIGHWAY AND TOUCH THE BRAKE PEDAL BEFORE ATTEMPTING TO PASS AND THEN I CAN'T GET POWER TO PASS FOR A COUPLE SECONDS. VERY SCARY AND DANGEROUS I THINK. THE DEALER EXPLAINED TO ME THAT TOYOTA HAD MADE A CHANGE TO MAKE THE COMPUTER IN CHARGE OF DECIDING IF ONE COULD ACCELERATE OR NOT RATHER THAN A DIRECT LINK FROM THE GAS PEDAL TO THE CARBURETOR. THE CONDITION IS UNNERVING AND I BELIEVE POTENTIALLY DANGEROUS AS I HAVE ALMOST BEEN IN ACCIDENTS WHEN I TRY TO ACCELERATE AND THE CAR WON'T RESPOND UNTIL IT IS READY TO ALLOW IT. *TR
NHTSA ODI #10704025
Official recalls
3Mar 27, 2014
Toyota is recalling certain model year 2013 Highlander vehicles manufactured March 13, 2013, through August 6, 2013. In the affected vehicles, the second row left hand seat may not lock in place when positioned in the forward front or second adjusting position. As such, the vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: If the seat does not lock into the seat track, there may be an increased risk of injury to an occupant in the event of a crash.
Remedy: Toyota will notify owners, and dealers will modify the second row left hand seat so that it will lock into the seat track, free of charge. The recall began on May 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18006 · Steering Column Separation
Opened Nov 16, 2018 · Closed Apr 2, 2024
Status: closed (inferred from source dates) · Steering; Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18005 · Upper Steering Column Separation
Opened May 4, 2018 · Closed Nov 20, 2018
Status: closed (inferred from source dates) · Steering; Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Additional source detail variants (2)
Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Steering
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Illustration