NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
134 reports142,299 miles · Sep 7, 2019
Electronic Stability Control (esc)Service Brakes
THIS IS FOR A 2009 TOYOTA HIGHLANDER HYBRID LIMITED WITH ABOUT 142000 MILES. THE VEHICLE HAS NOT BEEN IN ANY ACCIDENTS AND IS NOT ABUSED IN ANY WAY. ALL MAINTENANCE ARE UP TO DATE WITH THE MAJOR TIMING KIT REPLACED MOST RECENTLY AT ABOUT 140000. WHILE DRIVING THE VEHICLE ON NORMAL ROADS (SOMETIMES HIGHWAY, SOMETIME CITY ROADS…
Read full complaint
THIS IS FOR A 2009 TOYOTA HIGHLANDER HYBRID LIMITED WITH ABOUT 142000 MILES. THE VEHICLE HAS NOT BEEN IN ANY ACCIDENTS AND IS NOT ABUSED IN ANY WAY. ALL MAINTENANCE ARE UP TO DATE WITH THE MAJOR TIMING KIT REPLACED MOST RECENTLY AT ABOUT 140000. WHILE DRIVING THE VEHICLE ON NORMAL ROADS (SOMETIMES HIGHWAY, SOMETIME CITY ROADS), I GET THREE WARNINGS THAT POP UP AT THE CENTER SCREEN BETWEEN THE AIR VENTS; 1) CHECK ABS, 2) CHECK BRAKE SYSTEM, AND 3) BRAKE MALFUNCTION. FOR THE FIRST TWO WARNINGS, IT IS FOLLOWED BY "HAVE YOUR VEHICLE CHECKED BY DEALER." BUT, FOR THE THIRD WARNING, IT IS ACCOMPANIED BY "STOP THE VEHICLE IN A SAFE PLACE IMMEDIATELY AND CONTACT DEALER." THESE WARNINGS ALSO CORRESPOND TO THREE LIGHTS THAT POP UP BY THE SPEEDOMETER; 1) VSC, 2) ABS, AND 3) BRAKE. THE LIGHTS STAY ON FOR TWO TO THREE DAYS AT A TIME AND THEN WILL GO AWAY WITHOUT ANY REASONABLE EXPLAINATION. THIS HAPPENS ABOUT EVERY OTHER WEEK. I WAS UNABLE TO BRING IT TO A DEALERSHIP WHEN THE LIGHT IS ON AS I LIVE VERY FAR AWAY FROM THE DEALERSHIP. WHEN I CALL AND DESCRIBE THE WARNINGS, I AM TOLD THAT THIS MAY BE A PROBLEM WITH THE ACTUATOR AND IT IS COMMON. THE DEALER ESTIMATED THE COST TO BE AROUND $3500. I DID A QUICK SEARCH ONLINE AND FIND THAT THIS IS A COMMON PROBLEM AMONG SAME GENERATION HIGHLANDERS. I SHOULD NOT HAVE TO PAY FOR THIS AND THE MANUFACTURER NEEDS TO GET THE VEHICLE RIGHT. I FEEL UNSAFE DRIVING THIS VEHICLE WITH THE UNCERTAINTY OF BEING ABLE TO STOP SAFELY WHEN NECESSARY. I UNDERSTAND THAT TOYOTA HAD A RECALL ON THE BRAKE SYSTEM FOR THE PRIUS AND CAMRY, BUT DID NOT INCLUDE THE HIGHLANDER. THEY SHOULD HAVE SINCE THIS IS A SAFETY PROBLEM THAT IS COMMON WITH THE FIRST AND SECOND GENERATION HIGHLANDERS. PLEASE GET TOYOTA TO TAKE RESPONSIBILITY BEFORE AN ACCIDENTS OCCURS. BRAKES ARE AN IMPORTANT SAFETY FEATURE THAT SHOULD NOT BE COMPROMISED.
NHTSA ODI #11253911
Mileage unknown · Sep 5, 2019
Steering
A CLUNKING OR THUMPING NOISE COMES FROM THE LOWER STEERING COLUMN AS YOU MAKE A LEFT OR RIGHT HAND TURN. THE THUMPING NOISE HAS BEEN STEADILY INCREASING OVER THE PAST WEEKS.
NHTSA ODI #11253498
34,784 miles · Aug 20, 2019
Air BagsCrashInjury
TL* THE CONTACT OWNED A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED WHILE PARKING THE VEHICLE IN A PARKING, THE VEHICLE ACCELERATED INDEPENDENTLY, WENT OVER A CEMENT BARRIER, AND CONTINUED ACCELERATING WITH SPEED. THE CONTACT WAS NOT ABLE TO CONTROL THE VEHICLE. THE CONTACT THEN ENTERED ANOTHER PARKING LOT, THE CONTACT ATTEMPTED …
Read full complaint
TL* THE CONTACT OWNED A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED WHILE PARKING THE VEHICLE IN A PARKING, THE VEHICLE ACCELERATED INDEPENDENTLY, WENT OVER A CEMENT BARRIER, AND CONTINUED ACCELERATING WITH SPEED. THE CONTACT WAS NOT ABLE TO CONTROL THE VEHICLE. THE CONTACT THEN ENTERED ANOTHER PARKING LOT, THE CONTACT ATTEMPTED TO TURN THE STEERING WHEEL, AS A RESULT THE CONTACT CRASHED INTO A CORNER DUNKIN DONUT STORE. THE AIR BAG FAILED TO DEPLOY. THE CONTACT SUSTAINED MINOR FACE INJURIES DUE TO THE GLASS, NECK INJURED FROM THE STEERING WHEEL AND BACK THAT REQUIRED MEDICAL ATTENTION; THE CONTACT WAS HOSPITALIZED FOR TWO DAYS. THE FRONT PASSENGER, SUSTAINED CHEST INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW LOT. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE VEHICLE WAS DESTROYED. THE CONTACT MENTION THAT THE VEHICLE WAS PREVIOUSLY TAKEN FOR SERVICE AT MILLENNIUM TOYOTA DEALER (267 N FRANKLIN ST, HEMPSTEAD, NY 11550, (516) 874-2581) AND WAS INFORMED THE SERVICE WAS COMPLETED AND ALL WAS GOOD. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 34,784. *TR CONSUMER STATED BAGS FAILED TO DEPLOY.*JB
NHTSA ODI #11245214
126,000 miles · Aug 13, 2019
Steering
STEERING WHEEL IS CLICKING VERY BAD WHEN MAKING TURNS. CAR SHOP CHECKED EVERYTHING OUT AND DECIDED IT WAS COMING FROM THE STEERING COLUMN. CAR WAS IN A PRIOR CAR ACCIDENT IN 2012 WITH NO REPORTED FRAME DAMAGE. TAKING CAR TO LOCAL TOYOTA DEALERSHIP, AS RECOMMENDED FROM REGULAR CAR SHOP.
NHTSA ODI #11243710
110,000 miles · Jul 17, 2019
Engine
OIL COOLANT LINE BURSTS WHICH CAUSES IMMEDIATE LOSS OF ALL OIL. PROBLEM HAPPENS WHILE VEHICLE IS IN MOTION, AND IN THIS CASE WHILE IN MOTION ON A HIGH TRAFFICKED FREEWAY. FIX COST ABOUT $1,000 OUT OF POCKET. THIS IS A VERY LARGE LEAK WHICH COVERS THE GROUND, ENGINE, AND UNDERCARRIAGE. IF THE OIL LINE RUPTURES WHILE DRIVING, TH…
Read full complaint
OIL COOLANT LINE BURSTS WHICH CAUSES IMMEDIATE LOSS OF ALL OIL. PROBLEM HAPPENS WHILE VEHICLE IS IN MOTION, AND IN THIS CASE WHILE IN MOTION ON A HIGH TRAFFICKED FREEWAY. FIX COST ABOUT $1,000 OUT OF POCKET. THIS IS A VERY LARGE LEAK WHICH COVERS THE GROUND, ENGINE, AND UNDERCARRIAGE. IF THE OIL LINE RUPTURES WHILE DRIVING, THE LOW ENGINE OIL MESSAGE AND ENGINE OIL PRESSURE WARNINGS WILL ILLUMINATE. CONTINUED USE AFTER THESE WARNINGS WILL RESULT IN COMPLETE ENGINE FAILURE DUE TO OIL STARVATION. THE LINE IS KNOWN TO BE DEFECTIVE, AND A REVISED PART HAS BEEN ISSUED BY TOYOTA BUT RECALL HAS NOT BEEN ISSUED. COVERED UNDER A WARRANTY ISSUED BY TOYOTA BUT COVERS UNDER A SHORT TIME FRAME.
NHTSA ODI #11232713
115,000 miles · Jul 10, 2019
Engine
I WAS DRIVING DOWN THE INTERSTATE IN WISCONSIN DURING RUSH HOUR WHEN I TOOK OFF MY CRUISE CONTROL TO SLOW DOWN TO TAKE THE NEXT EXIT. I NOTICED AN ABNORMAL DOWN SHIFT WHEN I TOOK OFF THE CRUISE CONTROL. ALMOST IMMEDIATELY THE OIL AND TRACTION CONTROL LIGHTS CAME ON. AS I SLOWED TO THE STOP SIGN AT THE END OF THE EXIT THE DISPLAY…
Read full complaint
I WAS DRIVING DOWN THE INTERSTATE IN WISCONSIN DURING RUSH HOUR WHEN I TOOK OFF MY CRUISE CONTROL TO SLOW DOWN TO TAKE THE NEXT EXIT. I NOTICED AN ABNORMAL DOWN SHIFT WHEN I TOOK OFF THE CRUISE CONTROL. ALMOST IMMEDIATELY THE OIL AND TRACTION CONTROL LIGHTS CAME ON. AS I SLOWED TO THE STOP SIGN AT THE END OF THE EXIT THE DISPLAY SCREEN BEGAN DINGING AND READ LOW OIL PRESSURE AND IMMEDIATELY STOP THE CAR AND TURN OFF THE ENGINE. I IMMEDIATELY PULLED OVER ONCE OUT OF THE WAY OF TRAFFIC AND SHUT DOWN THE CAR. UPON CHECKING THE OIL THERE WAS NONE ON THE DIPSTICK. THERE WAS OIL DRIPPING DOWN FROM THE GRILL ALL UNDERNEATH THE CAR INCLUDING IN THE FRONT TIRE WHEEL WELLS. I ALSO HEARD KNOCKING FROM THE ENGINE, SO I AM CONCERNED THAT THE LIFTERS AND THE TOP END OF THE ENGINE MAY BE COMPROMISED. THIS A KNOWN ISSUE WITH TOYOTA, WHO HAS REFUSED TO ISSUE A RECALL FOR FAULTY OIL LINES AND SEALS. LUCKILY, I WAS AT AN EXIT WHERE I COULD SAFELY PULL OVER BEFORE MORE MAJOR DAMAGE WAS DONE TO THE VEHICLE. MY PERSONAL SAFETY, THE SAFETY OF MY FAMILY AS WELL AS OTHER DRIVERS COULD HAVE COMPROMISED BY THE NEGLECT THAT TOYOTA HAS SHOWN BY CONTINUING TO IGNORE THIS ISSUE.
NHTSA ODI #11230911
48,469 miles · Jun 24, 2019
Engine
WHEN VEHICLE IS STATIONARY, ENGINE ALWAYS MAKES STRANGE NOISE UPON INITIAL START.
NHTSA ODI #11222048
152,700 miles · Jun 20, 2019
Engine
I WAS TURNING INTO A PARKING LOT AND I STARTED GETTING "LOW OIL PRESSURE" ALERTS ON MY DASHBOARD. I WAS WORRIED IF IT WAS A SENSOR ISSUE AND KEPT MOVING TILL I PARKED MY VEHICLE. UPON FURTHER INVESTIGATION, I SAW THAT OIL HAD STARTED TO DRIP FROM WHERE I HAD TURNED, AND WHEN I PARKED THE CAR THE OIL DRIP GOT BIGGER AND HAD POOLE…
Read full complaint
I WAS TURNING INTO A PARKING LOT AND I STARTED GETTING "LOW OIL PRESSURE" ALERTS ON MY DASHBOARD. I WAS WORRIED IF IT WAS A SENSOR ISSUE AND KEPT MOVING TILL I PARKED MY VEHICLE. UPON FURTHER INVESTIGATION, I SAW THAT OIL HAD STARTED TO DRIP FROM WHERE I HAD TURNED, AND WHEN I PARKED THE CAR THE OIL DRIP GOT BIGGER AND HAD POOLED UNDER THE VEHICLE. BASED ON THE INFORMATION I GOT FROM THE TOYOTA DEALERSHIP, THIS WAS A KNOWN ISSUE WHICH STARTS AS A SMALL LEAK BUT DUE TO PRESSURE, THE OIL COOLER PIPE BURSTS OPEN. THIS KNOWN PROBLEM IS DOCUMENTED HERE: HTTPS://WWW.TOYOHEADQUARTERS.COM/THREADS/2007-2011-TOYOTA-SIENNA-HIGHLANDER-AND-VENZA-ENGINE-OIL-COOLER-PIPE-LEAK-LSC-ZE2.358/ TOYOTA REFUSED TO PAY MY REPAIR BILL AS I WAS OVER THE MILEAGE REQUIREMENT BY 2700 MILES. I CANNOT UNDERSTAND WHY TOYOTA DID NOT CONSIDER THIS A SAFETY ISSUE/RECALL. IF THIS HAD HAPPENED WHILE I WAS DRIVING ON THE HIGHWAY, MY ENGINE COULD HAVE BEEN COMPLETELY DAMAGED AND THE HEAVILY LEAKING OIL COULD HAVE CONTRIBUTED TO AN ACCIDENT(S). THE TOYOTA DEALERSHIP ALSO AGREED WITH ME THAT THIS SHOULD HAVE BEEN A SAFETY RECALL. TOYOTA CLAIMS THEY SENT OUT A LETTER FOR THIS WARRANTY ENHANCEMENT (ZE2) WHICH I NEVER RECEIVED. TOYOTA HAS REFUSED TO ESCALATE THIS ISSUE WITHIN THE COMPANY.
NHTSA ODI #11221487
138,000 miles · Jun 6, 2019
Structure
THERE HAS BEEN A LATCHING ISSUE WITH THE REAR POWER HATCH SINCE WE HAVE OWNED THE CAR. TOYOTA ISSUED A REPAIR RECALL IN 2017 TO FIX THE ISSUE BUT IT IS BROKEN ONCE AGAIN. EITHER THEY ARE USING DEFECTIVE PARTS OR A DESIGN FLAW, BUT IT IS VERY DANGEROUS AS WE HAVE HAD THE REAR DOOR OPEN WHILE DRIVING SEVERAL TIMES. THEY DO NOT WAN…
Read full complaint
THERE HAS BEEN A LATCHING ISSUE WITH THE REAR POWER HATCH SINCE WE HAVE OWNED THE CAR. TOYOTA ISSUED A REPAIR RECALL IN 2017 TO FIX THE ISSUE BUT IT IS BROKEN ONCE AGAIN. EITHER THEY ARE USING DEFECTIVE PARTS OR A DESIGN FLAW, BUT IT IS VERY DANGEROUS AS WE HAVE HAD THE REAR DOOR OPEN WHILE DRIVING SEVERAL TIMES. THEY DO NOT WANT TO REPAIR BECAUSE THEY DO NOT THINK IT IS A SAFETY ISSUE.
NHTSA ODI #11218311
80,000 miles · May 28, 2019
Electrical System
LOCK ACTUATORS MAL-FUNCTION WHEN USING THE REMOTE OR WHEN USING THE POWER LOCKS. UNABLE TO LOCK DOORS EXCEPT MANUALLY WITH KEY OR BY HAND. AT TIMES, CERTAIN LOCKS WILL WORK AND SEEM IMPACTED BY WEATHER CONDITIONS, I.E. HUMIDITY OR RAINY DAY VS. FAIR WEATHER DAY. THIS CAUSES THE OWNER TO BELIEVE THE DOORS ARE LOCKED WHEN THEY ARE…
Read full complaint
LOCK ACTUATORS MAL-FUNCTION WHEN USING THE REMOTE OR WHEN USING THE POWER LOCKS. UNABLE TO LOCK DOORS EXCEPT MANUALLY WITH KEY OR BY HAND. AT TIMES, CERTAIN LOCKS WILL WORK AND SEEM IMPACTED BY WEATHER CONDITIONS, I.E. HUMIDITY OR RAINY DAY VS. FAIR WEATHER DAY. THIS CAUSES THE OWNER TO BELIEVE THE DOORS ARE LOCKED WHEN THEY ARE NOT AND THE INCONVENIENCE THEY ARE UNLOCKED WHEN LEAVING YOUR CAR PARKED IN A PUBLIC LOT.
NHTSA ODI #11210251
Official recalls
9Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Apr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Consequence & remedy
Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 27, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18006 · Steering Column Separation
Opened Nov 16, 2018 · Closed Apr 2, 2024
Status: closed (inferred from source dates) · Steering; Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18005 · Upper Steering Column Separation
Opened May 4, 2018 · Closed Nov 20, 2018
Status: closed (inferred from source dates) · Steering; Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Additional source detail variants (2)
Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Steering
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Illustration