NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
45 reportsClear category filter33,830 miles · Apr 20, 2010
Vehicle Speed ControlCrash
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. WHILE DRIVING AT SPEEDS OF 35-40 MPH, THE VEHICLE ACCELERATED WITHOUT WARRANT. THE CONTACT APPLIED THE BRAKES BUT THE VEHICLE CONTINUED TO ACCELERATE AND THE BRAKES WOULD NOT ENGAGE. THE VEHICLE PROCEEDED TO CRASH INTO A CURB SEVERAL TIMES BEFORE COMING TO A STOP. THE CONTACT STATED…
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. WHILE DRIVING AT SPEEDS OF 35-40 MPH, THE VEHICLE ACCELERATED WITHOUT WARRANT. THE CONTACT APPLIED THE BRAKES BUT THE VEHICLE CONTINUED TO ACCELERATE AND THE BRAKES WOULD NOT ENGAGE. THE VEHICLE PROCEEDED TO CRASH INTO A CURB SEVERAL TIMES BEFORE COMING TO A STOP. THE CONTACT STATED ALSO SHE HAD PREVIOUSLY RECEIVED NOTIFICATION OF NHTSA RECALL CAMPAIGN ID NUMBER 10V023000 (VEHICLE SPEED CONTROL: ACCELERATOR PEDAL) BUT HAD NOT TAKEN THE VEHICLE FOR RECALL REPAIRS. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 33830.
NHTSA ODI #10326622
Mileage unknown · Apr 10, 2010
Equipment Adaptive/mobilityVehicle Speed Control
TOYOTA SAFETY RECALL NOTICE. I RECEIVED A SAFETY RECALL NOTICE FROM TOYOTA ABOUT FLOOR MAT INTERFERENCE WITH THE ACCELERATOR PEDAL. WHILE THE PEDAL MAY GET STUCK ON THE FLOOR MAT, IT IS HIGHLY UNLIKELY THAT THIS WILL CAUSE A SUDDEN INCREASE IN ACCELERATION. COMMON SENSE TELLS YOU THAT IF THE PEDAL GETS STUCK, THE VEHICLE WILL RE…
Read full complaint
TOYOTA SAFETY RECALL NOTICE. I RECEIVED A SAFETY RECALL NOTICE FROM TOYOTA ABOUT FLOOR MAT INTERFERENCE WITH THE ACCELERATOR PEDAL. WHILE THE PEDAL MAY GET STUCK ON THE FLOOR MAT, IT IS HIGHLY UNLIKELY THAT THIS WILL CAUSE A SUDDEN INCREASE IN ACCELERATION. COMMON SENSE TELLS YOU THAT IF THE PEDAL GETS STUCK, THE VEHICLE WILL REMAIN AT THE SPEED IN WHICH THE PROBLEM OCCURRED. THIS ALSO IS TRUE FOR THE ALLEGED STICKY ACCELERATOR PROBLEM. IT IS DISAPPOINTING THAT THE NTMVSA HAS NOT RECOGNIZED THIS PROBLEM AND IS ALLOWING TOYOTA TO CONTINUE DOWN THIS ROAD. *TR
NHTSA ODI #10324837
25,000 miles · Apr 7, 2010
Vehicle Speed Control
TL*THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. WHILE THE CONTACT WAS DRIVING UP AN INCLINE APPROXIMATELY 60 MPH WITH THE CRUISE CONTROL IN ACTIVATION THE SPEED RATE INCREASED TO 85 MPH OR HIGHER. WHEN THE BRAKES WERE APPLIED, THE VEHICLE CAME TO A COMPLETE STOP; HOWEVER, THE IDENTICAL FAILURE OCCURRED THREE WEEKS AFTER THE FIRST …
Read full complaint
TL*THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. WHILE THE CONTACT WAS DRIVING UP AN INCLINE APPROXIMATELY 60 MPH WITH THE CRUISE CONTROL IN ACTIVATION THE SPEED RATE INCREASED TO 85 MPH OR HIGHER. WHEN THE BRAKES WERE APPLIED, THE VEHICLE CAME TO A COMPLETE STOP; HOWEVER, THE IDENTICAL FAILURE OCCURRED THREE WEEKS AFTER THE FIRST FAILURE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN WAS UNABLE DIAGNOSE THE FAILURE. THE FAILURE MILEAGE WAS 25,000. THE CURRENT MILEAGE WAS 38,000.
NHTSA ODI #10324367
34,000 miles · Apr 5, 2010
Power TrainVehicle Speed ControlCrash
WHILE DRIVING IN REVERSE MY 2008 TOYOTA HIGHLANDER GAS PEDAL CONTINUED ACCELERATION AFTER BRAKING AND CRASHED INTO MY GARAGE. *TR
NHTSA ODI #10323859
20,000 miles · Mar 25, 2010
Electrical SystemVehicle Speed Control
MY 2008 TOYOTA HIGHLANDER HAS HAD ONE INCIDENT WHERE THE ACCELERATOR GOT STUCK. I BROUGHT THE VEHICLE TO BERNARDI TOYOTA IN FRAMINGHAM, MA ON 3/2/2010 AND THEY ADVISED THAT MY VEHICLE IS NOT PART OF THE RECALL AND THEY ALSO CONDUCTED DIAGNOSTICS ON THE VEHICLE AND REPORTED THAT ALL SYSTEMS ARE NORMAL. I AM CONCERNED ABOUT ALL OF…
Read full complaint
MY 2008 TOYOTA HIGHLANDER HAS HAD ONE INCIDENT WHERE THE ACCELERATOR GOT STUCK. I BROUGHT THE VEHICLE TO BERNARDI TOYOTA IN FRAMINGHAM, MA ON 3/2/2010 AND THEY ADVISED THAT MY VEHICLE IS NOT PART OF THE RECALL AND THEY ALSO CONDUCTED DIAGNOSTICS ON THE VEHICLE AND REPORTED THAT ALL SYSTEMS ARE NORMAL. I AM CONCERNED ABOUT ALL OF THE CONFUSING INFORMATION PERTAINING TO THIS PROBLEM OFFERED BY TOYOTA AND THE FACT IT HAPPENED ONCE TO MY VEHICLE, I AM WORRIED IT MIGHT HAPPEN AGAIN.
NHTSA ODI #10322088
5,000 miles · Mar 17, 2010
Vehicle Speed ControlCrash
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. WHILE DEPRESSING THE BRAKE PEDAL FROM SPEEDS OF 5 MPH, THE VEHICLE SUDDENLY ACCELERATED. THE CONTACT ATTEMPTED TO STOP THE VEHICLE BY DEPRESSING THE BRAKES HOWEVER, THE BRAKE PEDAL FELL ONTO THE FLOOR BOARD AND DID NOT ENGAGE. THE VEHICLE PROCEEDED TO CRASH INTO A CONCRETE STATUE. T…
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. WHILE DEPRESSING THE BRAKE PEDAL FROM SPEEDS OF 5 MPH, THE VEHICLE SUDDENLY ACCELERATED. THE CONTACT ATTEMPTED TO STOP THE VEHICLE BY DEPRESSING THE BRAKES HOWEVER, THE BRAKE PEDAL FELL ONTO THE FLOOR BOARD AND DID NOT ENGAGE. THE VEHICLE PROCEEDED TO CRASH INTO A CONCRETE STATUE. THE VEHICLE DID NOT COME TO A STOP AND PROCEEDED TO CRASH INTO A VEHICLE. THE CONTACT DID NOT REPORT ANY INJURIES. THE POLICE ARRIVED TO THE SCENE BUT A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO A LOCAL INDEPENDENT MECHANIC. NO REPAIRS WERE MADE TO THE VEHICLE. THE VIN WAS NOT AVAILABLE WHEN THE COMPLAINT WAS FILED. THE APPROXIMATE CURRENT AND FAILURE MILEAGES WERE 5,000.
NHTSA ODI #10320466
10,245 miles · Mar 16, 2010
Service Brakes, HydraulicVehicle Speed Control
NOTED RECENTLY ON MYCARSTATS.COM SIX COMPLAINTS REGISTERED WITH NHTSA REGARDING 2008 HIGHLANDER BRAKE PROBLEMS AND FIVE COMPLAINTS REGISTERED WITH NHTSA REGARDING 2008 HIGHLAND ELECTRIC PROBLEMS THAT INVOLVE BRAKES AND ELECTRONIC CONTROLS. I AM SUBMITTING THE FOLLOWING EXPERIENCES WITH MY 2008 HIGHLANDER BECAUSE THEY MIRROR MAN…
Read full complaint
NOTED RECENTLY ON MYCARSTATS.COM SIX COMPLAINTS REGISTERED WITH NHTSA REGARDING 2008 HIGHLANDER BRAKE PROBLEMS AND FIVE COMPLAINTS REGISTERED WITH NHTSA REGARDING 2008 HIGHLAND ELECTRIC PROBLEMS THAT INVOLVE BRAKES AND ELECTRONIC CONTROLS. I AM SUBMITTING THE FOLLOWING EXPERIENCES WITH MY 2008 HIGHLANDER BECAUSE THEY MIRROR MANY OF THE COMPLAINTS. THE BRAKES ON MY HIGHLANDER HAVE BEEN AN ISSUE FROM THE FIRST WEEKS OF OWNERSHIP. I HAVE TAKEN THE CAR TO A LOCAL TOYOTA DEALERSHIP AND COMPLAINED ABOUT THE BRAKES. THE DEALERSHIP DID ADJUST THE EMERGENCY BRAKE WHICH THEY INDICATED WAS OUT OF ADJUSTMENT BUT HAVE STATED THAT THE BRAKES ARE WORKING NORMALLY. MY SPECIFIC COMPLAINT IS BRAKE RESPONSE. THERE IS ROUGHLY AN INCH OF PEDAL TRAVEL BEFORE THE BRAKES BEGIN TO RESPOND. IF ONE MUST MAKE A HARD EMERGENCY STOP THE VSC CONTROL WILL ENGAGE. ON ONE OCCASION, WHILE DRIVING IN TOWN A CAR RAN THROUGH A TRAFFIC LIGHT IN FRONT OF ME. I HIT THE BRAKES HARD - THE VSC LIGHT CAME ON - AND THE CAR SLOWLY STOPPED. THERE WAS NO ACCIDENT BUT IT WAS EXTREMELY CLOSE. I HAVE FOUND THAT IF I ROUTINELY PRESS ON THE BRAKE PEDAL UNTIL THE VSC LIGHT COMES ON THAT THE PEDAL TRAVEL IS REDUCED. I TOOK THE HIGHLANDER TO AAA AUTO DIAGNOSTICS AND THEY CONFIRMED THE PEDAL/VSC. AAA WAS UNABLE TO READ THE HIGHLANDER COMPUTER BECAUSE THEY DID NOT HAVE THE PROPRIETARY TOYOTA COMPUTER INTERFACE. THE LOCAL TOYOTA DEALER HAS STATED THAT THE DEPRESSED PEDAL AND VSC LIGHT RESPONSE IS NORMAL. I ALSO NOTED COMPLAINTS OF SUDDEN ACCELERATION WHEN PUTTING THE CAR INTO GEAR. I HAVE NEVER EXPERIENCED A SURGE TO THE DEGREE MENTIONED IN THE COMPLAINTS REFERENCED ABOVE, HOWEVER, WHILE PUTTING THE CAR INTO DRIVE WITH MY FOOT ON THE BRAKE I HAVE HAD THE CAR SURGE FORWARD. I NOW ALWAYS HAVE THE EMERGENCY BRAKE ON WHILE PUTTING THE VEHICLE INTO DRIVE. THE DATE LISTED BELOW IS THAT OF MY FIRST COMPLAINT TO THE LOCAL TOYOTA DEALER. *TR
NHTSA ODI #10320164
21,000 miles · Mar 12, 2010
Vehicle Speed ControlCrash
2008 TOYOTA HIGHLANDER . UNINTENDED VEHICLE ACCELERATION. PULLED INTO PARKING SPACE AND APPLIED BRAKE BUT VEHICLE SPEED UP. VEHICLE WENT UP AND OVER THE CURB AND CONTINUED TO ACCELERATE. THE MUFFLER HIT THE CURB AND STOPPED THE CAR FROM GOING FURTHER. WHILE CAR WAS STILL TRYING TO GO FORWARD, MANAGED TO GET THE CAR IN PARK AND T…
Read full complaint
2008 TOYOTA HIGHLANDER . UNINTENDED VEHICLE ACCELERATION. PULLED INTO PARKING SPACE AND APPLIED BRAKE BUT VEHICLE SPEED UP. VEHICLE WENT UP AND OVER THE CURB AND CONTINUED TO ACCELERATE. THE MUFFLER HIT THE CURB AND STOPPED THE CAR FROM GOING FURTHER. WHILE CAR WAS STILL TRYING TO GO FORWARD, MANAGED TO GET THE CAR IN PARK AND TURNED OFF THE ENGINE. EXTENSIVE DAMAGE DONE TO THE UNDERCARRIAGE OF THE CAR. CAR WAS TOWED TO TOYOTA DEALER. CASE NUMBER FROM TOYOTA IS [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10319270
21,506 miles · Mar 10, 2010
Equipment Adaptive/mobilityVehicle Speed Control
WHILE I WAS DRIVING OUR 2008 TOYOTA HIGHLANDER (WITH 21506 MILES) TO THE TOYOTA DEALER FOR A TIRE INSPECTION, THE VEHICLE SURGED TO APPROX 80 MPH WITHOUT ACCELERATOR PEDAL ENGAGEMENT. WHEN I APPLIED BOTH FEET TO THE BRAKE PEDAL, IT SLOWED THE VEHICLE TO APPROX 60 MPH, BUT THE ENGINE CONTINUED TO RACE OUT OF CONTROL. I PUT THE …
Read full complaint
WHILE I WAS DRIVING OUR 2008 TOYOTA HIGHLANDER (WITH 21506 MILES) TO THE TOYOTA DEALER FOR A TIRE INSPECTION, THE VEHICLE SURGED TO APPROX 80 MPH WITHOUT ACCELERATOR PEDAL ENGAGEMENT. WHEN I APPLIED BOTH FEET TO THE BRAKE PEDAL, IT SLOWED THE VEHICLE TO APPROX 60 MPH, BUT THE ENGINE CONTINUED TO RACE OUT OF CONTROL. I PUT THE VEHICLE IN NEUTRAL, BUT THE ENGINE CONTINUED TO RACE. I PUT THE VEHICLE BACK INTO DRIVE AND TURNED OFF THE IGNITION. I EVENTUALLY GLIDED TO A SLOW, DIFFICULT STOP. NO OTHER VEHICLES WERE IN THE IMMEDIATE AREA. AFTER A 5 MINUTE REST IN PARK, I STARTED THE CAR AND THE ENGINE RACED. I IMMEDIATELY TURNED OFF THE IGNITION. AFTER ANOTHER 5 MINUTE DELAY, I STARTED THE VEHICLE AGAIN AND IT APPEARED NORMAL. I DROVE THE VEHICLE TO THE DEALER AND EXPLAINED WHAT HAD OCCURRED. THE DEALER COULD NOT RECREATE THE EVENT AND DID NOT SEE ANY READOUTS INDICATING WHAT HAD OCCURRED. THEY EXPLAINED IT AS A ECT TRANSMISSION THAT IS COMMON WHEN THE AIR CONDITIONING IS ON. GIVEN RECENT EVENTS, MY FEAR IT THAT THE EXPLANATION GIVEN TO ME IS NOT ACCURATE. I CALLED THE DEALER SEVERAL TIMES OVER THE PAST 2 MONTHS TO DETERMINE WHAT MY OPTIONS ARE FOR RECALL AND REPAIR. THEY CONTINUE TO TELL ME TO WAIT FOR A FLOOR MAT RECALL NOTICE FROM TOYOTA, AND PRIOR TO RECEIVING THAT NOTICE, THEY CANNOT ASSIST. I CALLED THE NATIONAL TOYOTA SERVICE CENTER 1-800-331-4331 TO FILE AN INCIDENT REPORT. I EXPLAINED THE SITUATION ABOVE, THEY GAVE ME A CASE NUMBER . THEY INDICATED THAT OUR VEHICLE WAS MADE IN JAPAN AND SHOULD NOT BE PART OF THE PEDAL RECALL. THEY ALSO INDICATED THAT WE SHOULD BE PART OF THE FLOOR MAT RECALL WHICH WILL INCLUDE A COMPUTER CHIP ADJUSTMENT THAT WILL INSTALL A BRAKE OVERRIDE TO ENSURE THAT THE BRAKE PEDAL WILL OVERRIDE THE ACCELERATOR. GIVE THE RECENT EVENTS OVER THE PAST 2 DAYS, IT APPEARS THAT MAY NOT BE WORKING PROPERLY ON OTHER VEHICLES. SINCE AUGUST 2009, THIS SITUATION HAS NOT OCCURRED AGAIN. MY FEAR IS THAT IT WILL. *TR
NHTSA ODI #10318488
29,500 miles · Mar 4, 2010
Vehicle Speed ControlCrash
ON DECEMBER 7, 2009, I HAD JUST ARRIVED AT MY PARKING APRON IN FRONT OF MY GARAGE AND WAS PUTTING THE CAR IN "PARK" AND HAD DEPRESSED THE BRAKE PEDAL TO DO SO. THE ACCELERATOR IMMEDIATELY JAMMED ON "FULL" AND THE CAR WENT THROUGH A WOODEN TWO-CAR GARAGE DOOR TAKING ALL OF THE EQUIPMENT WITH IT AND PROCEEDED EIGHTEEN (18) FEET IN…
Read full complaint
ON DECEMBER 7, 2009, I HAD JUST ARRIVED AT MY PARKING APRON IN FRONT OF MY GARAGE AND WAS PUTTING THE CAR IN "PARK" AND HAD DEPRESSED THE BRAKE PEDAL TO DO SO. THE ACCELERATOR IMMEDIATELY JAMMED ON "FULL" AND THE CAR WENT THROUGH A WOODEN TWO-CAR GARAGE DOOR TAKING ALL OF THE EQUIPMENT WITH IT AND PROCEEDED EIGHTEEN (18) FEET INTO THE GARAGE AND WAS STOPPED ONLY BY THE STAIRS TO THE CONDO AND THE HOUSE FOUNDATION. THERE WAS $9,000 DAMAGE TO THE VEHICLE AND $4,000 DAMAGE TO THE GARAGE AND STAIRS. TOYOTA HAS EXAMINED THE VEHICLE AND CLAIM IT IS NOT ONE OF THE RECALLED AUTOS AND THIS EVENT MUST HAVE BEEN MY FAULT. THIS IS VERY DISTRESSING AS I AM A SENIOR VOLUNTEER DRIVING SENIORS TO THEIR MEDICAL APPOINTMENTS AND AN "AT FAULT" ACCIDENT WOULD PREVENT MY CONTINUING THIS PROJECT. I FIRMLY BELIEVE THAT SOME DEFECT, PROBABLY ELECTRONIC CONTROLS, CAUSED THE VEHICLE TO DO WHAT IT DID AND I AM VERY AFRAID TO CONTINUE DRIVING IT. EVEN IF, TOYOTA'S CLAIM IS CORRECT THAT MY FOOT WEDGED BETWEEN THE BRAKE AND GAS PEDAL CAUSING ACCELERATION, WOULD THIS NOT ALSO BE A DESIGN DEFECT? PLEASE PROVIDE ANY INFORMATION OR ASSISTANCE AVAILABLE. *TR
NHTSA ODI #10316864
Official recalls
11Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Apr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Consequence & remedy
Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Apr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
Consequence & remedy
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Additional source detail variants (2)
Air Bags:side/window
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Air Bags
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 27, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Apr 18, 2008
TOYOTA IS RECALLING 90,189 MY 2008 HIGHLANDER AND HIGHLANDER HYBRID PASSENGER VEHICLES EQUIPPED WITH A THIRD ROW SEAT. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE NON-DRIVER DESIGNATED SEATING POSITIONS (DSP) ON THESE VEHICLES IS EQUIPPED WITH SEAT BELT ASSEMBLIES THAT HAVE A FEATURE THAT CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) TO AN AUTOMATIC LOCKING RETRACTOR (ALR). THE BELTS CONVERT TO THE ALR MODE AFTER THE WEBBING HAS BEEN FULLY WITHDRAWN FROM THE RETRACTOR. THE SYSTEM IS DESIGNED SO THAT AS THE BELT IS RELEASED INTO THE RETRACTOR, THE SYSTEM REMAINS IN THE ALR MODE SO THAT A CHILD RESTRAINT SYSTEM (CRS) CAN BE TIGHTLY SECURED.
Consequence & remedy
Consequence: HOWEVER, FOR THE TWO THIRD ROW DSP'S ON THESE VEHICLES, THE ALR MODE DEACTIVATES BEFORE THE WEBBING IS FULLY RETRACTED, SO THAT IT WILL NOT LOCK WHEN CERTAIN REAR-FACING CRS'S THAT HAVE A SHORT SEAT BELT ROUTING PATH ARE INSTALLED IN THE VEHICLE. THIS CAN ALLOW THE SEAT BELT WEBBING TO SPOOL OUT DURING NORMAL DRIVING MANEUVERS, WHICH COULD AFFECT THE STABILITY OF A CHILD RESTRAINT INSTALLED AT THOSE SEATING POSITIONS. AS SUCH, THIS COULD DISCOURAGE THE USE OF A CHILD RESTRAINT AND IN THE EVENT OF A CRASH, THE CHILD MAY NOT BE ADEQUATELY PROTECTED POSSIBLY RESULTING IN INJURY.
Remedy: DEALERS WILL INSTALL A NEWLY DESIGNED SEAT BELT COMPONENT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 18, 2008. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18006 · Steering Column Separation
Opened Nov 16, 2018 · Closed Apr 2, 2024
Status: closed (inferred from source dates) · Steering; Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18005 · Upper Steering Column Separation
Opened May 4, 2018 · Closed Nov 20, 2018
Status: closed (inferred from source dates) · Steering; Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Additional source detail variants (2)
Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Steering
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Illustration