NHTSA owner reports · September 18, 2026 snapshot.
Seat Belts complaints
9 reportsClear category filterMileage unknown · Mar 14, 2024
Seat BeltsUnknown Or Other
The ECU requires a reflash or replacement. The hybrid batteries over heat and regen braking randomly shuts off during braking or before/after due to overheating becuswe the cooling fans do not engage past level 1 or 2. The fans in fact never go full speed unless commanded by a Toyota service tech via the software during fan tes…
Read full complaint
The ECU requires a reflash or replacement. The hybrid batteries over heat and regen braking randomly shuts off during braking or before/after due to overheating becuswe the cooling fans do not engage past level 1 or 2. The fans in fact never go full speed unless commanded by a Toyota service tech via the software during fan testing. Upon testing I noticed they not once went high enough to be audible and thus overheated. Manu forms indicate this is a common issue and requires 180-$300 for a reflash and/or replacement of the compu) ECU to alleviate this issue. Second issue I've found is the 3rd row seat belts just like some other MY Highlanders have their restraints cut at the shackle holding them to the body of the vehicle. I have seen several sheered this way including my own vehicle.
NHTSA ODI #11577484
Mileage unknown · Jan 12, 2024
Air BagsSeat BeltsCrashInjury
I was in a car accident yesterday two cars hit me from behind my daughter was in the third row and my other kids in the second row. The air bags didn't deploy and my daughters seatbelt in the third row didn't lock when the cars impacted my vehicle her seat belt kept going forward with her. Also my seat belt unlocked and came off…
Read full complaint
I was in a car accident yesterday two cars hit me from behind my daughter was in the third row and my other kids in the second row. The air bags didn't deploy and my daughters seatbelt in the third row didn't lock when the cars impacted my vehicle her seat belt kept going forward with her. Also my seat belt unlocked and came off upon impact of car
NHTSA ODI #11565038
Mileage unknown · Feb 1, 2023
Seat Belts
Unable to buckle 3rd row passenger side seat belt buckle. Safety of my children were put at risk as I didn’t realize this until recently since our family grew. No warning indicating lights are on.
NHTSA ODI #11505054
98,000 miles · Sep 23, 2014
Seat Belts
THE SEAT BELT WARNING LIGHT CAME ON. AS YOU KNOW AND ANNOUNCED BY TOYOTA THERE IS A RECALL FOR THIS CABLE. HOWEVER TOYOTA IS, I FEEL DRAGGING THERE FEET DOING ABSOLUTELY NOTHING. CAN YOU CONTACT TOYOTA AND FIND OUT WHAT IS BEING DONE. ALL I GET IS THE STANDARD ANSWER----WORKING ON IT. NO FIX YET. *TR
NHTSA ODI #10638304
Mileage unknown · Apr 10, 2014
Seat Belts
I BELIEVE THERE IS A MANUFACTURING FLAW IN THE 2008 TOYOTA HIGHLANDER SEAT BELTS. WHEN I INITIALLY PURCHASED MY HIGHLANDER (NEW), THERE WAS A CHILD SAFETY SEAT IN THE REAR PASSENGER-SIDE SEAT, WHICH USED THE LATCH SYSTEM FOR INSTALLATION (DID NOT REQUIRE USE OF SEAT BELT). WHEN I FIRST WENT TO INSTALL A BOOSTER SEAT IN THAT PO…
Read full complaint
I BELIEVE THERE IS A MANUFACTURING FLAW IN THE 2008 TOYOTA HIGHLANDER SEAT BELTS. WHEN I INITIALLY PURCHASED MY HIGHLANDER (NEW), THERE WAS A CHILD SAFETY SEAT IN THE REAR PASSENGER-SIDE SEAT, WHICH USED THE LATCH SYSTEM FOR INSTALLATION (DID NOT REQUIRE USE OF SEAT BELT). WHEN I FIRST WENT TO INSTALL A BOOSTER SEAT IN THAT POSITION, WHICH WOULD REQUIRE THE SEAT BELT TO BE USED, THE SEAT BELT DID NOT WORK (COULD NOT EXTEND BELT, WOULD NOT RETRACT, ETC.). THE BELT HAD NEVER BEEN USED AND DOES NOT WORK. I HAVE FILED SEVERAL COMPLAINTS WITH TOYOTA, BUT THEY SAID THEY WOULD NOT COVER THE REPLACEMENT OF MY SEAT BELT, BECAUSE I WAS OUTSIDE OF MY WARRANTY TIME (# OF MILES). FIRST, THE BELT HAD NEVER BEEN USED (BECAUSE A CHILD SAFETY SEAT HAD ALWAYS BEEN IN THAT POSITION SINCE I PURCHASED THE VEHICLE). SECOND, THE # OF MILES DRIVEN HAS NO DIRECT CORRELATION TO HOW OFTEN A REAR SEAT BELT IS USED. IT MAY HAVE A DIRECT CORRELATION TO HOW OFTEN THE DRIVER'S BELT IS USED, BUT NONE OF THE OTHER POSITIONS. NOW, THE OTHER SIDE REAR SEAT BELT IS STARTING TO HAVE PROBLEMS...OFTENTIMES IT DOES NOT RETRACT PROPERLY/GETS LOCKED WHEN IT SHOULDN'T, ETC. THE FRONT BELTS ALSO LOCK-UP VERY EASILY AND ARE HARD TO GET UNLOCKED ONCE LOCKED. I BELIEVE THERE TO BE A FLAW IN THE MANUFACTURING/COMPONENTS OF THESE BELTS AND FEEL TOYOTA SHOULD COVER REPLACING THEM. THIS IS A SAFETY ISSUE!!! *TR
NHTSA ODI #10578836
Mileage unknown · Mar 12, 2013
Seat Belts
2008 TOYOTA HIGHLANDER. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO SEAT BELT MALFUNCTION AND REQUESTS AN INVESTIGATION AND REIMBURSEMENT. *SMD AS THE CONSUMER WAS DRIVING ON THE HIGHWAY, HER SON WAS SECURED IN HIS CAR SEAT, PLAYING QUIETLY WITH THE ATTACHED SEAT BELT. AT THE POINT, THE SEAT BELT WRAPPED AROUND HIS NE…
Read full complaint
2008 TOYOTA HIGHLANDER. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO SEAT BELT MALFUNCTION AND REQUESTS AN INVESTIGATION AND REIMBURSEMENT. *SMD AS THE CONSUMER WAS DRIVING ON THE HIGHWAY, HER SON WAS SECURED IN HIS CAR SEAT, PLAYING QUIETLY WITH THE ATTACHED SEAT BELT. AT THE POINT, THE SEAT BELT WRAPPED AROUND HIS NECK. THE CONSUMER PULLED OVER AND ATTEMPTED TO FREE HER SON FROM CHOKING, SHE WAS UNABLE TO DO SO, ALTHOUGH LOOSENING THE BELT SUFFICIENTLY ALLOWED HIM TO BREATH. FIRST RESPONDERS HAD DIFFICULTY REMOVING THE BELT, FINALLY THEY HAD TO CUT THE SEAT BELT TO PERMIT HER SON TO BE TAKEN OUT OF THE SEAT.
NHTSA ODI #10502901
82,600 miles · Nov 20, 2012
Seat BeltsSteering
TL* THE CONTACT OWNS 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE PARKED THE REAR PASSENGER DOOR SIDE SEAT BELT WOULD NOT RELEASE AND AS A RESULT IT HAD TO BE CUT. THE CONTACT ALSO STATED HE HEARD A KNOCKING NOISE EMITTING FROM THE STEERING COLUMN. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING. THE TECHNI…
Read full complaint
TL* THE CONTACT OWNS 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE PARKED THE REAR PASSENGER DOOR SIDE SEAT BELT WOULD NOT RELEASE AND AS A RESULT IT HAD TO BE CUT. THE CONTACT ALSO STATED HE HEARD A KNOCKING NOISE EMITTING FROM THE STEERING COLUMN. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING. THE TECHNICIAN STATED THE SEAT BELT AND THE LOWER STEERING SHAFT NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 82,600 AND THE CURRENT MILEAGE WAS 93,000. UPDATED 12/12/12 *CN
NHTSA ODI #10485260
57,000 miles · Jul 27, 2010
Child SeatSeat Belts
DURING A RECENT ROAD TRIP VISITING FAMILY, MY SON WAS RIDING IN THE THIRD ROW SEAT IN OUR TOYOTA HIGHLANDER. SHORTLY BEFORE ARRIVING AT HIS GRANDPARENTS, HE TOLD ME THAT HE HAD BECOME TWISTED IN HIS SEATBELT. AS WE WERE WITHIN 10 MINUTES OF OUR DESTINATION, I TOLD HIM THAT I WOULD HANDLE THE SITUATION WHEN WE ARRIVED. A FEW M…
Read full complaint
DURING A RECENT ROAD TRIP VISITING FAMILY, MY SON WAS RIDING IN THE THIRD ROW SEAT IN OUR TOYOTA HIGHLANDER. SHORTLY BEFORE ARRIVING AT HIS GRANDPARENTS, HE TOLD ME THAT HE HAD BECOME TWISTED IN HIS SEATBELT. AS WE WERE WITHIN 10 MINUTES OF OUR DESTINATION, I TOLD HIM THAT I WOULD HANDLE THE SITUATION WHEN WE ARRIVED. A FEW MINUTES LATER HE SAID THAT THE BELT WAS GETTING TIGHTER AND I ASKED HIM IF I NEEDED TO STOP AND HE SAID THAT WOULD BE A GOOD IDEA. BEFORE I COULD GET STOPPED (LESS THAT A BLOCK), HE INDICATED THAT HE WAS HAVING TROUBLE BREATHING. WHEN I LOOKED BACK, I WAS STARTLED TO FIND THAT THE SEAT BELT HAD BECOME WRAPPED AROUND HIS NECK AND HAD RATCHETED BACK IN, PINNING HIS NECK BACK AGAINST THE SIDE OF THE CAR. EVEN AFTER STOPPING, I WAS UNABLE TO PULLED THE SEAT BELT OUT TO GET IT OUT FROM AROUND MY SON'S NECK -- HE WAS STRANGLING IN FRONT OF MY EYES. FORTUNATELY, I WAS IN A CITY WITH RESIDENTS CLOSE BY, ONE OF WHICH HEARD ME SCREAMING AND RUNNING DOOR TO DOOR, WHO BROUGHT OUT A KITCHEN KNIFE TO CUT THE BELT AND RELEASE MY SON. I REALIZE THAT THESE RATCHET-TYPE SEAT BELTS ARE DESIGNED AS A SAFETY FEATURE IN THE THIRD ROW SEAT OF MANY MAKES AND MODELS, HOWEVER, FEEL THAT THIS DESIGN ALSO PRESENTS A STRANGULATION CONCERN. IN CASES SUCH AS MINE, THERE WAS NO WAY TO GET THE SEAT BELT RELEASED AND IF THIS HAD OCCUR WHILE ON RURAL ROADS OR THE INTERSTATE, THE AVAILABILITY OF A KNIFE WOULD HAVE BEEN MORE DIFFICULT TO COME BY. I FEEL THAT EITHER AN EMERGENCY RELEASE BUTTON SHOULD BE DESIGNED FOR THE RATCHET SEAT BELTS OR CONSUMERS NEED TO BE AWARE OF THE POTENTIAL FOR STRANGULATION AND ADVISED TO CARRY SCISSORS FOR THIS POSSIBILITY. I HAVE VOICED MY CONCERNS TO TOYOTA AND THEY ARE REPLACING THE SEAT BELT FREE OF CHARGE, HOWEVER, I FEEL THAT IT IS IMPORTANT THAT INDIVIDUALS BE AWARE OF THIS POSSIBILITY AND BE PREPARED. *TR
NHTSA ODI #10345693
Mileage unknown · Mar 18, 2010
Seat BeltsVisibility
WE HAVE A TOYOTA HIGHLANDER (2008) WHICH IS HAVING SAFETY ISSUES. THE PASSENGER SEAT BELT KEEPS GOING OFF. THERE IS NOTHING IN THE SEAT BUT THE BELL KEEPS GOING OFF. IT DOESN'T HAPPEN ALL THE TIME BUT IT DOES IT OFTEN ENOUGH THAT IT COULD BE A SAFETY ISSUE. MY SECOND COMPLAINT IS THE WINDOW. THE WINDSHIELD KEEPS CHIPPING WHEN AN…
Read full complaint
WE HAVE A TOYOTA HIGHLANDER (2008) WHICH IS HAVING SAFETY ISSUES. THE PASSENGER SEAT BELT KEEPS GOING OFF. THERE IS NOTHING IN THE SEAT BUT THE BELL KEEPS GOING OFF. IT DOESN'T HAPPEN ALL THE TIME BUT IT DOES IT OFTEN ENOUGH THAT IT COULD BE A SAFETY ISSUE. MY SECOND COMPLAINT IS THE WINDOW. THE WINDSHIELD KEEPS CHIPPING WHEN ANYTHING HITS IT. THERE ARE SEVERAL TIMES WHEN I HAD TO REPLACE THIS WINDOW. THERE COULD BE NO OTHER CARS AROUND BUT IF SOMETHING HITS IT WILL SPIDER. MY THIRD ISSUE IS THERE IS A NOISE THAT HAPPENS WHEN WE START THE CAR. ITS IN THE ENGINE AND WE CANT FIND IT. I HAVE TAKEN THE CAR INTO TOYOTA BUT OF COURSE THEY CANT FIND ANYTHING. I HAVE HAD NOTHING BUT EXPENSIVE ISSUES WITH THIS UNSAFE CAR. I WANT TO KNOW IF THERE HAVE BEEN ANY RECALLS ON THESE ISSUES? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10320768
Official recalls
11Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Apr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Consequence & remedy
Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Apr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
Consequence & remedy
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Additional source detail variants (2)
Air Bags:side/window
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Air Bags
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 27, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Apr 18, 2008
TOYOTA IS RECALLING 90,189 MY 2008 HIGHLANDER AND HIGHLANDER HYBRID PASSENGER VEHICLES EQUIPPED WITH A THIRD ROW SEAT. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE NON-DRIVER DESIGNATED SEATING POSITIONS (DSP) ON THESE VEHICLES IS EQUIPPED WITH SEAT BELT ASSEMBLIES THAT HAVE A FEATURE THAT CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) TO AN AUTOMATIC LOCKING RETRACTOR (ALR). THE BELTS CONVERT TO THE ALR MODE AFTER THE WEBBING HAS BEEN FULLY WITHDRAWN FROM THE RETRACTOR. THE SYSTEM IS DESIGNED SO THAT AS THE BELT IS RELEASED INTO THE RETRACTOR, THE SYSTEM REMAINS IN THE ALR MODE SO THAT A CHILD RESTRAINT SYSTEM (CRS) CAN BE TIGHTLY SECURED.
Consequence & remedy
Consequence: HOWEVER, FOR THE TWO THIRD ROW DSP'S ON THESE VEHICLES, THE ALR MODE DEACTIVATES BEFORE THE WEBBING IS FULLY RETRACTED, SO THAT IT WILL NOT LOCK WHEN CERTAIN REAR-FACING CRS'S THAT HAVE A SHORT SEAT BELT ROUTING PATH ARE INSTALLED IN THE VEHICLE. THIS CAN ALLOW THE SEAT BELT WEBBING TO SPOOL OUT DURING NORMAL DRIVING MANEUVERS, WHICH COULD AFFECT THE STABILITY OF A CHILD RESTRAINT INSTALLED AT THOSE SEATING POSITIONS. AS SUCH, THIS COULD DISCOURAGE THE USE OF A CHILD RESTRAINT AND IN THE EVENT OF A CRASH, THE CHILD MAY NOT BE ADEQUATELY PROTECTED POSSIBLY RESULTING IN INJURY.
Remedy: DEALERS WILL INSTALL A NEWLY DESIGNED SEAT BELT COMPONENT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 18, 2008. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18006 · Steering Column Separation
Opened Nov 16, 2018 · Closed Apr 2, 2024
Status: closed (inferred from source dates) · Steering; Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18005 · Upper Steering Column Separation
Opened May 4, 2018 · Closed Nov 20, 2018
Status: closed (inferred from source dates) · Steering; Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Additional source detail variants (2)
Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Steering
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Illustration