IllustrationTL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE SUN ROOF EXPLODED. THE VEHICLE WAS TAKEN TO A DEALER TO BE REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 66,000. UPDATED 03/15/16*LJ *TR
2006 Toyota Highlander
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Toyota Highlander do not stand out strongly from the model-year median of 186.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Highlander years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
400–25K
2725–50K
4350–75K
2175–100K
33100–150K
35150K+
199 reports with mileage · 78 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports4 fire reports19 injury reports
Visibility complaints
12 reportsWINDSHIELD CRACKED FOR NO APPARENT REASON. THIS IS THE SECOND TOYOTA VEHICLE THAT THIS HAS HAPPENED WITH OVER THE LAST TWO YEARS. VEHICLE WAS PARKED IN GARAGE. TOYOTA GAVE ME A CASE NUMBER [XXX] TO REFERENCE. HAS ANYONE ELSE HAD A PROBLEM WITH TOYOTA WINDSHIELDS CRACKING FOR NO APPARENT REASON? INFORMATION REDACTED P…
Read full complaint
WINDSHIELD CRACKED FOR NO APPARENT REASON. THIS IS THE SECOND TOYOTA VEHICLE THAT THIS HAS HAPPENED WITH OVER THE LAST TWO YEARS. VEHICLE WAS PARKED IN GARAGE. TOYOTA GAVE ME A CASE NUMBER [XXX] TO REFERENCE. HAS ANYONE ELSE HAD A PROBLEM WITH TOYOTA WINDSHIELDS CRACKING FOR NO APPARENT REASON? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
DRIVER SIDE SUN VISOR WILL NOT STAY IN THE UP POSITION AGAINST THE CEILING. IMPAIRS DRIVER'S VISION. *TR
THE WEBASTO SUNROOF HAD A SAFETY RECALL THAT I DIDN'T RESPOND TO IN TIME. THE SERIAL NUMBER IS 6256887. THE FORM SAID IF I WAITED TO LONG I WOULD NEED TO FILE A CLAIM...I SHOULD HAVE PAID MORE ATTENTION TO THE FINE PRINT! *TR
THE SUN VISOR ON THE PASSENGER SIDE WILL NOT STAY UP. IT JUST KEEPS COMING DOWN AND THIS CAN BE DANGEROUS WHILE DRIVING. I'VE HAD 5 DIFFERENT TOYOTAS AND NEVER HAD THIS PROBLEM BEFORE. *TR
TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT AFTER SHUTTING THE VEHICLE OFF AND EXITING, THE FRONT DRIVER'S WINDOW ROLLED DOWN INTO THE DOOR PANEL. NEITHER THE DEALER, NOR THE MANUFACTURER, WERE MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE …
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT AFTER SHUTTING THE VEHICLE OFF AND EXITING, THE FRONT DRIVER'S WINDOW ROLLED DOWN INTO THE DOOR PANEL. NEITHER THE DEALER, NOR THE MANUFACTURER, WERE MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 118,000.
THE DRIVER SUN VISOR WILL NOT STAY UP AND FALLS DOWN OBSTRUCTING MY VIEW WHILE DRIVING. WHILE DOING RESEARCH ON THE INTERNET THERE SEEMS TO BE A LARGE NUMBER OF COMPLAINTS OF THIS SAME DEFAULT OF TOYOTA HIGHLANDERS SUN VISORS FALLING DOWNING AND NOT REMAINING SEATED IN THE UPRIGHT POSITION. THERE IS NOT ANY GARAGE DOOR OPENERS…
Read full complaint
THE DRIVER SUN VISOR WILL NOT STAY UP AND FALLS DOWN OBSTRUCTING MY VIEW WHILE DRIVING. WHILE DOING RESEARCH ON THE INTERNET THERE SEEMS TO BE A LARGE NUMBER OF COMPLAINTS OF THIS SAME DEFAULT OF TOYOTA HIGHLANDERS SUN VISORS FALLING DOWNING AND NOT REMAINING SEATED IN THE UPRIGHT POSITION. THERE IS NOT ANY GARAGE DOOR OPENERS OR ANY OTHER DEVICES ON THE VISOR TO CAUSE EXTRA HEAVINESS THAT WOULD LEAD TO THE FAILING OF THE VISOR. I HAVE TO PUT TAPE ON THE VISOR TO PROVIDE MYSELF WITH AN UNOBSTRUCTED VIEW TO SAFELY DRIVE. *TR
DRIVER'S SIDE SUN VISOR WILL NOT STAY IN PLACE, HAS BEGUN DROPPING DOWN OBSCURING MY VISION WHILE DRIVING. *TR
VISIBILITY - THE DRIVER'S SIDE SUN VISOR APPEARS TO HAVE A "LOOSE SPRING". IT WON'T FULLY STAY IN THE UP POSITION AND WHEN PLACED DOWN, IT ALSO DROOPS. BOTH SITUATIONS IMPACT THE DRIVER'S VISION. *LN
SUN VISOR FALLS DOWN, OFTEN WHEN GOING OVER A BUMP, IMPAIRING VISION. THIS STARTED HAPPING AROUND 45,000 MILES AND NOW THE VISOR WILL NOT STAY UP. *TR
Official recalls
716V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
11V112000 · Vehicle Speed Control:accelerator Pedal
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
Consequence & remedy
Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V499000 · Service Brakes, Hydraulic:foundation Components:master Cylinder
Oct 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
Consequence & remedy
Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V223000 · Equipment:other:labels
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
PE06055 · Sudden Loss Of Power Steering Assist
Opened Nov 21, 2006 · Closed Mar 28, 2007
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PE06-055 BASED ON TWO COMPLAINTS OF LOSS OF EPS ASSIST IN 43,931 MY 2006 TOYOTA HIGHLANDER HYBRID VEHICLES.ONE OF THE COMPLAINTS ALLEGED THAT A LOSS IN POWER STEERING ASSIST RESULTED IN A CRASH.IN RESPONSE TO AN INFORMATION REQUEST LETTER FROM ODI, TOYOTA SUBMITTED INFORMATION ABOUT 6 ADDITIONAL CONSUMER COMPLAINTS, INCLUDING 2 ALLEGING CRASHES, AND 109 WARRANTY CLAIMS RELATED TO THE EPS ASSEMBLY IN THE SUBJECT VEHICLES.ODI?S ANALYSIS OF THE CRASH INCIDENTS REVEALED THAT EACH INCIDENT OF ALLEGED LOSS IN POWER STEERING ASSIST OCCURRED AT VERY LOW SPEEDS AND PRESENTED MINOR SAFETY CONSEQUENCES.TOYOTA'S RESPONSE ALSO IDENTIFIED THREE POTENTIAL ISSUES THAT COULD RESULT IN A LOSS OF EPS ASSIST IN THE SUBJECT VEHICLES.TWO OF THE CONDITIONS ARE RELATED TO ELECTRICAL CURRENT SURGES WITHIN THE EPS ECU.THE OTHER IS RELATED TO EPS MOTOR MAGNETS BECOMING DISLODGED BECAUSE OF POOR ADHESION.THE TWO ISSUES RELATED TO CURRENT SURGES CAN ONLY OCCUR WHEN THE VEHICLE IS BEING PARKED OR BEING OPERATED AT VERY LOW SPEEDS.THE THIRD ISSUE COULD THEORETICALLY OCCUR AT ANY SPEED, BUT OCCURS AS A RESULT OF A SPECIFIC TYPE OF IMPACT TO ONE OF THE FRONT WHEELS.TOYOTA STATES THAT IN ALL THREE CASES, AND DURING ANY LOSS OF POWER STEERING ASSIST TO THE VEHICLE, THE FRONT WHEELS CAN STILL BE DIRECTED WITHOUT ASSIST, MANUALLY, VIA THE STEERING WHEEL. ODI'S ANALYSIS OF THE COMPLAINT DATA AND OTHER INFORMATION SUBMITTED BY TOYOTA INDICATES THAT THERE IS A LOW OVERALL FAILURE RATE FOR ALL OF THE CONDITIONS COMBINED THAT CAN RESULT IN LOSS OF EPS IN THE SUBJECT VEHICLES (18 COMPLAINTS PER 100,000 VEHICLES AND A 0.2% WARRANTY CLAIM RATE) AND THERE IS NO EVIDENCE OF ANY FAILURE THAT COULD CAUSE A LOSS OF STEERING CONTROL.THE CHANGE IN STEERING EFFORT IS GREATEST AT VERY LOW SPEEDS WHEN THE STEERING IS AT OR NEAR END OF TRAVEL.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (2)
Steering:electric Power Assist System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PE06-055 BASED ON TWO COMPLAINTS OF LOSS OF EPS ASSIST IN 43,931 MY 2006 TOYOTA HIGHLANDER HYBRID VEHICLES.ONE OF THE COMPLAINTS ALLEGED THAT A LOSS IN POWER STEERING ASSIST RESULTED IN A CRASH.IN RESPONSE TO AN INFORMATION REQUEST LETTER FROM ODI, TOYOTA SUBMITTED INFORMATION ABOUT 6 ADDITIONAL CONSUMER COMPLAINTS, INCLUDING 2 ALLEGING CRASHES, AND 109 WARRANTY CLAIMS RELATED TO THE EPS ASSEMBLY IN THE SUBJECT VEHICLES.ODI?S ANALYSIS OF THE CRASH INCIDENTS REVEALED THAT EACH INCIDENT OF ALLEGED LOSS IN POWER STEERING ASSIST OCCURRED AT VERY LOW SPEEDS AND PRESENTED MINOR SAFETY CONSEQUENCES.TOYOTA'S RESPONSE ALSO IDENTIFIED THREE POTENTIAL ISSUES THAT COULD RESULT IN A LOSS OF EPS ASSIST IN THE SUBJECT VEHICLES.TWO OF THE CONDITIONS ARE RELATED TO ELECTRICAL CURRENT SURGES WITHIN THE EPS ECU.THE OTHER IS RELATED TO EPS MOTOR MAGNETS BECOMING DISLODGED BECAUSE OF POOR ADHESION.THE TWO ISSUES RELATED TO CURRENT SURGES CAN ONLY OCCUR WHEN THE VEHICLE IS BEING PARKED OR BEING OPERATED AT VERY LOW SPEEDS.THE THIRD ISSUE COULD THEORETICALLY OCCUR AT ANY SPEED, BUT OCCURS AS A RESULT OF A SPECIFIC TYPE OF IMPACT TO ONE OF THE FRONT WHEELS.TOYOTA STATES THAT IN ALL THREE CASES, AND DURING ANY LOSS OF POWER STEERING ASSIST TO THE VEHICLE, THE FRONT WHEELS CAN STILL BE DIRECTED WITHOUT ASSIST, MANUALLY, VIA THE STEERING WHEEL. ODI'S ANALYSIS OF THE COMPLAINT DATA AND OTHER INFORMATION SUBMITTED BY TOYOTA INDICATES THAT THERE IS A LOW OVERALL FAILURE RATE FOR ALL OF THE CONDITIONS COMBINED THAT CAN RESULT IN LOSS OF EPS IN THE SUBJECT VEHICLES (18 COMPLAINTS PER 100,000 VEHICLES AND A 0.2% WARRANTY CLAIM RATE) AND THERE IS NO EVIDENCE OF ANY FAILURE THAT COULD CAUSE A LOSS OF STEERING CONTROL.THE CHANGE IN STEERING EFFORT IS GREATEST AT VERY LOW SPEEDS WHEN THE STEERING IS AT OR NEAR END OF TRAVEL.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Steering
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PE06-055 BASED ON TWO COMPLAINTS OF LOSS OF EPS ASSIST IN 43,931 MY 2006 TOYOTA HIGHLANDER HYBRID VEHICLES.ONE OF THE COMPLAINTS ALLEGED THAT A LOSS IN POWER STEERING ASSIST RESULTED IN A CRASH.IN RESPONSE TO AN INFORMATION REQUEST LETTER FROM ODI, TOYOTA SUBMITTED INFORMATION ABOUT 6 ADDITIONAL CONSUMER COMPLAINTS, INCLUDING 2 ALLEGING CRASHES, AND 109 WARRANTY CLAIMS RELATED TO THE EPS ASSEMBLY IN THE SUBJECT VEHICLES.ODI?S ANALYSIS OF THE CRASH INCIDENTS REVEALED THAT EACH INCIDENT OF ALLEGED LOSS IN POWER STEERING ASSIST OCCURRED AT VERY LOW SPEEDS AND PRESENTED MINOR SAFETY CONSEQUENCES.TOYOTA'S RESPONSE ALSO IDENTIFIED THREE POTENTIAL ISSUES THAT COULD RESULT IN A LOSS OF EPS ASSIST IN THE SUBJECT VEHICLES.TWO OF THE CONDITIONS ARE RELATED TO ELECTRICAL CURRENT SURGES WITHIN THE EPS ECU.THE OTHER IS RELATED TO EPS MOTOR MAGNETS BECOMING DISLODGED BECAUSE OF POOR ADHESION.THE TWO ISSUES RELATED TO CURRENT SURGES CAN ONLY OCCUR WHEN THE VEHICLE IS BEING PARKED OR BEING OPERATED AT VERY LOW SPEEDS.THE THIRD ISSUE COULD THEORETICALLY OCCUR AT ANY SPEED, BUT OCCURS AS A RESULT OF A SPECIFIC TYPE OF IMPACT TO ONE OF THE FRONT WHEELS.TOYOTA STATES THAT IN ALL THREE CASES, AND DURING ANY LOSS OF POWER STEERING ASSIST TO THE VEHICLE, THE FRONT WHEELS CAN STILL BE DIRECTED WITHOUT ASSIST, MANUALLY, VIA THE STEERING WHEEL. ODI'S ANALYSIS OF THE COMPLAINT DATA AND OTHER INFORMATION SUBMITTED BY TOYOTA INDICATES THAT THERE IS A LOW OVERALL FAILURE RATE FOR ALL OF THE CONDITIONS COMBINED THAT CAN RESULT IN LOSS OF EPS IN THE SUBJECT VEHICLES (18 COMPLAINTS PER 100,000 VEHICLES AND A 0.2% WARRANTY CLAIM RATE) AND THERE IS NO EVIDENCE OF ANY FAILURE THAT COULD CAUSE A LOSS OF STEERING CONTROL.THE CHANGE IN STEERING EFFORT IS GREATEST AT VERY LOW SPEEDS WHEN THE STEERING IS AT OR NEAR END OF TRAVEL.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.