Power Train. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

32 crash reports3 fire reports16 injury reports

What owners actually said

286 reports

Mileage unknown · May 17, 2011

Equipment

Read full complaint

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THE AIR CONDITIONING UNIT WOULD INVOLUNTARILY SWITCH FROM BLOWING COOL AIR TO HOT AIR WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE CONTROL BOARD FOR THE AIR CONDITIONING UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS ALSO TOLD THAT THE FAILURE WAS COMMON DUE TO THE WIRING. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN AND THE VIN WAS UNAVAILABLE.

NHTSA ODI #10401234

135,000 miles · Apr 19, 2011

Exterior Lighting

TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED WHEN DRIVING AT LOW SPEEDS THE RIGHT REAR BRAKE LIGHTS DO NOT ILLUMINATE WHEN DEPRESSED. THE FAILURE WAS BROUGHT TO HIS ATTENTION BY ANOTHER DRIVER. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR HAD IT BEEN REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE…

Read full complaint

NHTSA ODI #10396837

55,000 miles · Apr 19, 2011

Visibility

2004 TOYOTA HIGHLANDER......DRIVER SUN VISOR DOES NOT STAY UP. BLOCKS VISION. TOYOTA WILL NOT FIX AT THEIR EXPENSE. RESEARCH SHOWS THAT THERE ARE NUMEROUS COMPLAINTS OF THE SAME NATURE. THIS IS A DESIGN FLAW AND TOYOTA NEEDS TO STEP UP. *TR

NHTSA ODI #10396828

83,000 miles · Apr 13, 2011

Exterior Lighting

Read full complaint

THE LENSES OF THE DAYTIME RUNNING LAMPS/HIGH BEAMS HAVE DEVELOPED WHITE, OVAL-SHAPED BUBBLING/MELTING MARKS OF APPROXIMATELY 0.5 TO 0.75 INCHES IN DIAMETER, IN THE CENTER OF THE LENSES, DIRECTLY IN FRONT OF THE LAMPS. I FIRST NOTICED THIS IN DECEMBER 2010 JUST PRIOR TO CHANGING THE ORIGINAL LAMPS (THEREFORE THE REPLACEMENT LAMPS DID NOT CAUSE THIS PROBLEM). I REPORTED THIS TO TOYOTA, CASE NUMBER 1012071480. TOYOTA TOLD ME TO TAKE THIS UP WITH THE SERVICE DEPARTMENT OF A DEALER. AT THE DEALERSHIP, I WAS INITIALLY QUOTED A PRICE OF $988 TO REPLACE THE ASSEMBLIES. AFTER DISCUSSION WITH THE SERVICE MANAGER AND HIS FOLLOW-UP WITH TOYOTA, THE PRICE WAS LOWERED TO $396 TO PAY ONLY FOR LABOR, PARTS TO BE PROVIDED AT NO CHARGE. I OPTED TO NOT HAVE THIS DONE FOR THIS PRICE. POSSIBLE SAFETY ISSUES: 1) DAMAGED/MELTING LENSES COULD IMPACT THE EFFECTIVENESS OF THE HIGH BEAMS AND/OR THE DAYTIME RUNNING LAMPS; 2) HEAT THAT IS HOT ENOUGH TO DAMAGE/MELT THE LENSES COULD BE A FIRE HAZARD; 3) DAMAGED/MELTING LENSES COULD BE AN INDICATION OF AN ELECTRICAL PROBLEM. I HAVE DIGITAL PHOTOS TAKEN IN DECEMBER 2010 SHOWING THE DAMAGED/MELTING LENSES THAT I HAVE PROVIDED TO TOYOTA AND WOULD BE PLEASED TO PROVIDE TO NHTSA. I HAVE ALSO RETAINED THE ORIGINAL LAMPS, AND THE CAR STILL HAS THE DAMAGED/MELTED LENSES. *TR

NHTSA ODI #10395715

14,000 miles · Mar 28, 2011

Steering

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED WHEN THE ENGINE WAS STARTED THE STEERING ANGLE SENSOR WARNING LIGHT ILLUMINATED AND THE STEERING BECAME DIFFICULT TO HANDLE. THE VEHICLE WAS TOWED TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT WAS UNABLE TO LOCATE A FAILURE. THE VEHICLE WAS TEST DRIVEN AND THE FAI…

Read full complaint

NHTSA ODI #10393110

41,845 miles · Mar 21, 2011

Vehicle Speed ControlCrashInjury

Read full complaint

ON FEBRUARY, 18, 2011 AT APPPROXIMATELY 1:30 P.M. I GOT INTO MY 2004 TOYOTA HIGHLANDER, WHICH WAS PARKED IN A PRIVATE PARKING LOT AT 1 MEETINGHOUSE RD. IN CHELMSFORD, MA. I TURNED THE KEY ON, STARTED THE CAR, AND PUT THE GEAR IN REVERSE TO BACK OUT OF THE PARKING SPACE. AS I TOUCHED THE ACCELERATOR PEDAL WITH MY RIGHT FOOT, THE CAR ACCELERATED UNCONTROLLABLY AT A SPEED THAT DID NOT CORRESPOND WITH THE PRESSURE I HAD PUT ON THE PEDAL. I IMMEDIATELY PUT MY FOOT ON THE BRAKES, BUT THERE WAS NO RESPONSE FROM THE BRAKE SYSTEM. THE STEERING WHEEL WAS TURNED TO BACK OUT IN A COUNTERCLOCKWISE DIRECTION, AND WITHIN NO MORE THAN 4 SECONDS, THE CAR CRASHED INTO A BUILDING APPROXIMATELY 20 FEET FROM WHERE THE CAR WAS INITIALLY PARKED. THE CAR WAS TOTALLY UNRESPONSIVE TO MY EFFORTS TO BRAKE SUBSEQUENT TO THIS SUDDEN AND INEXPLICABLE ACCELERATION. I'M LUCKY I WASN'T KILLED, BECAUSE MY VEHICLE WAS TOTALED. *TR

NHTSA ODI #10392355

118,000 miles · Feb 17, 2011

Engine And Engine Cooling

COOLANT LOSS DUE TO STRIPPED HEAD BOLTS IN THE ENGINE BLOCK. ENGINE OVER HEATED. NO HEAT.*TR

NHTSA ODI #10383048

42,000 miles · Feb 15, 2011

Equipment

TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE GPS NAVIGATION SYSTEM ON THE VEHICLE FAILED WHICH CAUSED THE AIR CONDITIONING, HEAT, DEFROST AND THE RADIO TO FAIL. THE CONTACT HAD THE VEHICLE INSPECTED BY THE DEALER AND WAS TOLD THAT THE NAVIGATION SYSTEM NEEDED TO BE REPLACED; HOWEVER, THE DEALER DID N…

Read full complaint

NHTSA ODI #10382783

78,000 miles · Feb 10, 2011

Engine And Engine Cooling

Read full complaint

TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT NOTICED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INFORMED THE CONTACT THAT THE CYLINDER BEHIND THE INTAKE MANIFOLD WAS LEAKING AND THAT SHE WOULD NEED TO REPLACE THE ENGINE. THE DEALER ADVISED THE CONTACT THAT SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY THEY WOULD NOT BE ABLE TO PROVIDE HER WITH ANY ASSISTANCE. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS WAITING FOR A RESPONSE. THE VEHICLE WAS NOT REPAIRED DUE TO THE COST. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 78,000.

NHTSA ODI #10381449

35,000 miles · Feb 8, 2011

Equipment

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 45 MPH WITH THE AIR CONDITIONER ACTIVATED, HEAT BEGAN BLOWING FROM THE VENTILATION AS OPPOSED TO COLD AIR. THE FAILURE WOULD OCCUR INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE MILEAGE WAS 35,000 AN…

Read full complaint

NHTSA ODI #10381108

Official recalls

11V539000 · Engine And Engine Cooling

Nov 9, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

Consequence & remedy

Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

11V112000 · Vehicle Speed Control:accelerator Pedal

Feb 24, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

Consequence & remedy

Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

10V499000 · Service Brakes, Hydraulic:foundation Components:master Cylinder

Oct 21, 2010

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

Consequence & remedy

Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.

06V253000 · Vehicle Speed Control:accelerator Pedal

Jul 13, 2006

ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.

Consequence & remedy

Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

04V181000 · Latches/locks/linkages:doors:latch

Apr 15, 2004

CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.

Consequence & remedy

Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.

Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ10003 · Unintended And Uncontrolled Acceleration

Opened Feb 16, 2010 · Closed Mar 1, 2011

Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Additional source detail variants (6)

Electrical System:software

Vehicle Speed Control:accelerator Pedal